Audio System - Rear Cargo Area Rattles With Audio ON
06-011April 7, 2006
Applies To:
2001-05 MDX - ALL
2006 MDX - From VIN 2HNYD18..6H500001 thru 2HNYD18..6H518992
Woofer/Rear Cargo Area Rattles
SYMPTOM
The rear cargo area rattles when you play the audio system.
PROBABLE CAUSE
The woofer cover does not fit properly.
CORRECTIVE ACTION
Insulate the woofer cover with EPT sealer.
REQUIRED MATERIALS
EPT Sealer (5T): P/N 06991-SA5-000
(One roll repairs about eight vehicles.)
WARRANTY CLAIM INFORMATION
In warranty:
The normal warranty applies.
Operation Number: 010004
Flat Rate Time: 0.3 hour
Failed Part: P/N 84518-S3V-A00ZA
Defect Code: 07404
Symptom Code: 04201
Template ID: 06-011A
Skill Level: Repair Technician
Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.
DIAGNOSIS
Turn up the volume on the audio system until the rattle occurs, then remove the woofer grille.
^ Refer to page 22-160 of the 2001-02 MDX service manual or page 22-417 of the 2003-06 MDX service manual, or
^ Online, enter keyword WOOFER, then select Woofer Replacement from the list.
- If the rattle disappears, go to the REPAIR PROCEDURE.
- If the rattle continues, this bulletin does not apply.
Continue your diagnosis using the appropriate service manual.
REPAIR PROCEDURE
1. Cut four 10 mm x 250 mm strips of EPT sealer.
2. Attach the four strips of EPT sealer around the woofer opening.
NOTE:
Make sure the EPT sealer covers the entire inner edge of the woofer opening.
3. Reinstall the woofer grille.
4. Recheck the audio system to make sure the rattle is gone.
Disclaimer