ABS - Lamp ON/Possible DTC's 15, 16, 17, 18, 43, 44 Set

04-015

May 11, 2004

Applies To:
2004 TL - From VIN 19UUA6...4A000001 thru 19UUA6...4A034483

ABS Indicator Comes On With DTCs 15, 16, 17, 18, 43, and/or 44

SYMPTOM

ABS indicator comes on with intermittent rear ABS sensor code(s).

PROBABLE CAUSE

Moisture in the sensor.

CORRECTIVE ACTION

Replace the appropriate rear wheel ABS sensor.

PARTS INFORMATION

Left Rear Wheel Sensor: P/N 57475-SEP-A01
Right Rear Wheel Sensor: P/N 57470-SEP-A01

WARRANTY CLAIM INFORMATION





In warranty:
The normal warranty applies.

Failed Part: P/N 57470-SEP-A01

Defect Code: 03214

Symptom Code: 03205

Skill Level: Repair Technician

Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.

DIAGNOSIS

Connect the Honda Diagnostic System (HDS) to the DLC (data link connector), and check for DTCs.

^ If DTC 15,16,17, 18, 43, and/or 44 is stored, go to REPAIR PROCEDURE.

^ If another DTC is stored, refer to the 2004 TL Service Manual for the appropriate troubleshooting.

REPAIR PROCEDURE

1. Raise the vehicle on a lift, and remove the rear wheel of the affected side.





2. Locate the rear wheel sensor, and disconnect the connector.

3. Remove the two rear wheel sensor mounting bolts. Remove the sensor.

4. Install the new rear wheel sensor, being careful not to twist the wires. Torque the two mounting bolts to 9.8 N.m (7.2 lb-ft), and connect the sensor to the harness.

5. Reinstall the rear wheel. Torque the wheel nuts to 108 N.m (80 lb-ft).

6. Clear the codes with the HDS.

7. Test-drive the vehicle. If any ABS codes come on, do the appropriate troubleshooting in the 2004 TL Service Manual.





Disclaimer