Suspension - Front Suspension Clunking On Turns

06-026

August 15, 2006

Applies To:
2005-06 RSX - ALL

Clunking Noise While Turning

SYMPTOM

The front suspension makes a clunking noise while turning.

PROBABLE CAUSE

The front springs are moving on the spring seats.

CORRECTIVE ACTION

Replace both front springs, and do a four-wheel alignment.

PARTS INFORMATION

RSX Type S
Right-Front Spring: P/N 51401-S6M-A52
Left-Front Spring: P/N 51406-S6M-A52

RSX (M/T)
Right-Front Spring: P/N 51401-S6M-C02
Left-Front Spring: P/N 51406-S6M-C02

RSX (A/T)
Right-Front Spring: P/N 51401-S6M-J02
Left-Front Spring: P/N 51406-S6M-J02

WARRANTY CLAIM INFORMATION

In warranty:
The normal warranty applies.

Operation Number: 414101

Flat Rate Time: 2.1 hours

Failed Part: P/N 51401-56M-306

Defect Code: 07403

Symptom Code: 04201

Template ID: 06-026A (RSX Type S)
06-026B (RSX M/T)
06-026C (RSX A/T)

Skill Level: Repair Technician

Out of warranty:
Any repair performed after warranty expiration may be eligible for goodwill consideration by the District Parts and Service Manager or your Zone Office. You must request consideration, and get a decision, before starting work.

DIAGNOSIS

With the engine running, while either parked or driving at 5 mph, turn the steering wheel from lock to lock and listen for a clunk.

^ If you hear a clunk, go to REPAIR PROCEDURE.

^ If you do not hear a clunk, continue with troubleshooting. This bulletin does not apply.

REPAIR PROCEDURE

1. Replace the front springs.





NOTE:
Be sure the wrapped or insulated end of the spring is installed against the spring seat.

^ Refer to page 18-20 of the 02-06 HSX Service Manual, or

^ Online, enter the keyword SUSPENSION, then select Front Damper/Spring Replacement from the list.

2. Do a four-wheel alignment.

3. Test-drive the vehicle to make sure the noise is gone.





Disclaimer