Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Lubrication of Engine Oil Seals Prior to Installation
- Coolant Hoses - Split
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Water Pump - Leaks and Noisy
- Radiator Fan - Stays On, Relay Sticks
- Exhaust - Noise Under the Vehicle
- Tire Valve Stem - Not Accessible
- Body - Door Locks Binding, Difficult to Operate
- Lock Tumblers - Binding, Difficult to Operate
- Locks - Binding/Difficult to Operate
- Door Lock Key - Binding
- Sunroof - Binding
- Clutch Pedal - Noisy When Depressed
- A/T - Buzzing Noise
- Rear Brakes - Noisy
- Engine - Slight Deviations In Fuel Economy
- Turbo - Correcting Engine Misfire at Full Throttle
- Catalytic Converter - Odor At Exhaust Pipe
- Interior Light - Stays On/Inoperative
- Interior Light - Stays On/Inoperative
- Front Seat Belt - Binding
- Seat Belts - Too Short
- Brake Lights - Not Functioning
- Interior Mirror Assembly - Loose
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- A/T - Noise Transmitted Through the Shift Cable
- Trunk Light - Stays On/Inoperative
- Engine - Excessive Cranking Time, Rough Idle
- Engine Performance - Hesitation During Cold Take Off
- Cruise Control - Vacuum Hoses Leaking
- Chemicals,Additives
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 690503 - 03/11/05
- Electrical - DTCs, Sporadic - Contact Check
- 200601 - 02/03/06
- 929002 - 06/30/90
- 688707 - 07/01/87
- 688706 - 07/01/87
- 609001 - 06/30/90
- 4698-01 - 04/21/98
- 46-97-01 - 11/25/97
- 269208 - 11/30/92
- Engine Oil Seals - Lubricate Prior to Installation
- Wiper Blades - Skipping
- Headlight - Aiming Using Hella Universal Beamsetter IV
- Electrical - Cigarette Lighter Does Not Work
- Electrical - Cigarette Lighter Does Not Work
- Paint - Industrial Fallout, Neutralization and Removal
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Child Restraint - Anchor Installation/Retrofitting
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Fuel System - Fuel Neutralization Procedure
- Oxygen Sensor - Contamination
- Cooling System - Coolant ID/Filling/Mixing Information
- Brakes - Pulsation Diagnostic Guidelines
- Oil Consumption, Explanation
- Suspension/Tires - Eliminating Vibrations
- Engine - Difficult Starting, Poor Running, No Start
- All Technical Service Bulletins
- Electrical - Electrical Malfunctions After Window Tint
- Warranty - Repurchased Vehicle Information
- Bosch Component - Manufacturing Date Codes
- Bolts/Nuts - Replacing Instructions
- SRT Archive Microfiche - Currently Available
- Special Tool Minimum Requirements - Revised
- Special Tools - Required for Vehicle Service
- Vehicle - Fluid Capacity Chart
- Engine Compartment - Corrosion Protection
- Catalog Numbers - Owners Manual, Maintenance, Warranty
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Insufficient Ventilation
- Plastilube Moly 3 - Proper Procedures Obtaining
- A/C - System Discharging and Environmental Laws
- Power Steering/Hydraulic System - Hydraulic Fluid
- Tools - New Transmission Support Tool 3147
- Transmissions - Oil Leakage After Installation
- Transmission Oil Seals/Lubricate Prior to Installation
- Engine/Transmission - Tightening Torques Revised
- Engine Oil Seals - Leakage After Replacement
- Lubrication of Engine Oil Seals Prior to Installation
- Coolant Hoses - Split
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Spark Plug - Application Chart
- Spark Plugs - New Torque Specifications
- Cylinder Head Bolts - Tightening Procedures
- Remanufactured Water Pumps - Modifications
- Water Pump - Leaks and Noisy
- Coolant Circulation Pump - Leakage Troubleshooting
- Radiator Fan - Installing Snap Lock Wiring Connector
- Radiator Fan - Stays On, Relay Sticks
- Exhaust - Noise Under the Vehicle
- Ball Joint - Separating From Wheel Bearing Housing
- Tire/Wheels - Eliminating Vibrations
- Paint - Refinishing Procedure
- Tires - Aerosol Tire Inflator Hazard
- Tire Valve Stem - Not Accessible
- Gas Strut - Replacement
- Body - Door Locks Binding, Difficult to Operate
- Central Door Locking System - Repair Procedures
- Key Code - Location
- Key Code - Location
- Key Code Location
- Key Code - Locations
- Lock Tumblers - Binding, Difficult to Operate
- Locks - Binding/Difficult to Operate
- Door Lock Key - Binding
- Sunroof - Binding
- Clutch Pedal - Noisy When Depressed
- A/T - Install Replacements With Supplied New Oil Cooler
- A/T - Buzzing Noise
- Fuel System - Injection Cleaner Adapter Kit
- ECU - Precautions
- Wiring Variations - Control Unit Multi Plug
- Sensor Plate Lever - Basic Adjustment
- Rear Brakes - Noisy
- Battery - Cold Crank Rating
- Recharging Maintenance - Free Batteries In Stock
- Distributor Caps - Driveability
- Fuel Tank - Capacity Insufficient
- Fuel Tanks - Flushing/Neutralization
- Turbocharger - Removing/Installing
- Turbocharger - Replace Oil Filter/Oil When Replacing
- Engine - Slight Deviations In Fuel Economy
- Turbo - Correcting Engine Misfire at Full Throttle
- Catalytic Converter - Poor Acceleration, Lack of Power
- Catalytic Converter - Odor At Exhaust Pipe
- Interior Light - Stays On/Inoperative
- Interior Light - Stays On/Inoperative
- Front Seat Belt - Binding
- Seat Belt System - Inspection Procedure
- Rear Seat Combination Belt - Removing/Installing
- Seat Belts - Too Short
- Brake - Insufficient Ventilation
- Odometer - Disclosure Requirements
- Brake Lights - Not Functioning
- Front Crankshaft - Oil Seal Removal Revision
- Word List - Uniform Terms for Components/Systems
- IM 240 Emissions Testing - 2 Wheel Drive Dynamometers
- Seat Belt Stop Button - Broken
- Rear Child Restraint Anchorages - Tethering Updates
- Sunroof Motor Cover - Removing and Installing
- Bonded Window - Changes in Hardening Times
- Windshield Wiper Arm Angle - Adjusting
- Windshield Wipers - Chatter/Do Not Clean Window Properly
- Interior Mirror Assembly - Loose
- Body Trim - Identifying/Painting Plastic Parts
- Oil Change - Interval Reduced to 5000 Miles
- VAG 1558 Temperature Tester
- Antifreeze Testers - Accuracy
- Coolant - Recommended Usage
- Recall 96E006000: Aftermarket Brake Hose Assembles
- Recall 85V099000: Brake Hose Cracks
- Recall 83V095000: Brake Pedal Height Too Low
- Identification/Automatic Transmission
- A/T - Application Chart
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - 010, 003 Bind In Reverse/2nd Gear Starts
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs1
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Generator V Belt Pulley - Tool For R and R
- A/C - Blower Motor Squirrel Cage Rubbing
- A/T - Final Drive Oil
- A/T - New Fluid Type
- A/T - Synthetic Oil for Final Drive
- Strut Mounting Parts - Modified
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- A/T - Noise Transmitted Through the Shift Cable
- Fuse/Relay Panel Cover - Proper Installation
- Speedometer - Gov't Regulations for Replacement
- VAG 1367 Engine Tester - Change
- Wiring - Use Quality Connectors and Proper Crimping Tool
- Stabilant 22A - Electrical Contact Enhancer
- Engine Performance - Fuel Quality and Carbon Deposits
- Gasoline - Fuel Containing Detergents Recommended
- Wheel Alignment - Data for Front and Rear Axles
- Recall 82V037000: Floor Mat Restricts Accelerator Pedal
- Paint - Acid Rain Spots
- Paint - Industrial Fallout
- Paint - Industrial Fallout Removal (Revised)
- Brake Fluid - New Super DOT 4
- Brake Fluid - Chaning or Topping Off
- Automatic Shift Lock Operation - Checking
- Brake Pressure Regulator - New Adapter for Adjustment
- Trunk Light - Stays On/Inoperative
- Loctite 325 - Proper Procedures For Obtaining
- Engine - Excessive Cranking Time, Rough Idle
- Ignition Distributor - Trigger Wheel Removal
- Sagging Sunvisors
- Engine Performance - Hesitation During Cold Take Off
- Cruise Control - Vacuum Hoses Leaking
- Differential Gear Oil Level - Maintenance Requirements
- Brake - Squeal
- Brake System - Bleeding
- Vehicle - Towing Procedures
- Body - Paint Chip Repair Procedure
- Restraint System - 'LATCH' System Installation/Retrofit
- Recall 87V08000 Sudden Unexpected Acceleration
- Oxygen Sensor - Contamination