Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Customer Interest
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Lubrication of Engine Oil Seals Prior to Installation
- Battery - Discharged
- Idle Stabilizer - Irregular/Improper Idle
- Engine - Does Not Start/Stalls
- Brakes - Eliminate Squeal
- Disc Brake - Squeal
- Rear Crankshaft Seal - Leaks Oil
- Exhaust - Noise Under the Vehicle
- Body - Door Locks Binding, Difficult to Operate
- Lock Tumblers - Binding, Difficult to Operate
- Door Lock Key - Binding
- Front Seat Cover Leather - Unsatisfactory Appearance
- Clutch Pedal - Noisy When Depressed
- Rear Brakes - Noisy
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Catalytic Converter - Odor At Exhaust Pipe
- Cruise Control - Inoperative
- Direction Light Switch - Does not Return to Neutral
- Valve Cover Gasket - Leaking
- MIL ON - Vehicle Loses Power
- Interior Mirror Assembly - Loose
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- Engine - Excessive Cranking Time, Rough Idle
- Shift Lever - Inoperative (Only Third/Fourth Gears)
- Shift Lever - Noise
- M/T - Hard Shifting
- Chemicals,Additives
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 690503 - 03/11/05
- Electrical - DTCs, Sporadic - Contact Check
- 200601 - 02/03/06
- 929002 - 06/30/90
- 688707 - 07/01/87
- 688706 - 07/01/87
- 609001 - 06/30/90
- 4698-01 - 04/21/98
- 46-97-01 - 11/25/97
- 288901 - 01/31/89
- 269208 - 11/30/92
- Engine Oil Seals - Lubricate Prior to Installation
- Wiper Blades - Skipping
- Headlight - Aiming Using Hella Universal Beamsetter IV
- Electrical - Cigarette Lighter Does Not Work
- Electrical - Cigarette Lighter Does Not Work
- Paint - Industrial Fallout, Neutralization and Removal
- Paint - Color Code Chart
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Fuel System - Fuel Neutralization Procedure
- Oxygen Sensor - Contamination
- Cooling System - Coolant ID/Filling/Mixing Information
- Brakes - Pulsation Diagnostic Guidelines
- Oil Consumption, Explanation
- Suspension/Tires - Eliminating Vibrations
- Engine - Difficult Starting, Poor Running, No Start
- All Technical Service Bulletins
- Electrical - Electrical Malfunctions After Window Tint
- Warranty - Repurchased Vehicle Information
- Bosch Component - Manufacturing Date Codes
- Special Tool Minimum Requirements - Revised
- Vehicle - Fluid Capacity Chart
- Engine Compartment - Corrosion Protection
- Catalog Numbers - Owners Manual, Maintenance, Warranty
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Insufficient Ventilation
- Plastilube Moly 3 - Proper Procedures Obtaining
- Air Conditioning - Current Flow Wiring Diagram
- A/C - System Discharging and Environmental Laws
- Power Steering - New Hydraulic Fluid
- Tools - New Transmission Support Tool 3147
- Transmissions - Oil Leakage After Installation
- Transmission Oil Seals/Lubricate Prior to Installation
- Engine/Transmission - Tightening Torques Revised
- Engine Oil Seals - Leakage After Replacement
- Lubrication of Engine Oil Seals Prior to Installation
- Battery - Discharged
- Idle Stabilizer - Irregular/Improper Idle
- Engine - Does Not Start/Stalls
- Brakes - Eliminate Squeal
- Disc Brake - Squeal
- Spark Plug - Application Chart
- Cylinder Head Bolts - Tightening Procedures
- Remanufactured Water Pumps - Modifications
- Coolant Circulation Pump - Leakage Troubleshooting
- Radiator Fan - Installing Snap Lock Wiring Connector
- Rear Crankshaft Seal - Leaks Oil
- Exhaust - Noise Under the Vehicle
- Tire/Wheels - Eliminating Vibrations
- Paint - Refinishing Procedure
- Tires - Aerosol Tire Inflator Hazard
- Gas Strut - Replacement
- Body - Door Locks Binding, Difficult to Operate
- Key Code - Locations
- Lock Tumblers - Binding, Difficult to Operate
- Door Lock Key - Binding
- Front Seat Cover Leather - Unsatisfactory Appearance
- Clutch Pedal - Noisy When Depressed
- Clutch Over Center Return Spring - Removing/Installing
- Fuel System - Injection Cleaner Adapter Kit
- ECU - Precautions
- Wiring Variations - Control Unit Multi Plug
- Sensor Plate Lever - Basic Adjustment
- Rear Brakes - Noisy
- Battery - Cold Crank Rating
- Recharging Maintenance - Free Batteries In Stock
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Distributor Caps - Driveability
- Fuel Tank - Capacity Insufficient
- Fuel Tanks - Flushing/Neutralization
- Catalytic Converter - Poor Acceleration, Lack of Power
- Catalytic Converter - Odor At Exhaust Pipe
- Manual Antenna - Installation Procedure
- Checking Window Regulator Current Draw and Stall Current
- Cruise Control - Inoperative
- Seat Belt System - Inspection Procedure
- Direction Light Switch - Does not Return to Neutral
- Brake - Insufficient Ventilation
- Dynamic Oil Pressure System - Troubleshooting Tips
- Odometer - Disclosure Requirements
- Valve Cover Gasket - Leaking
- Front Crankshaft - Oil Seal Removal Revision
- Body Dimension - Correction
- Word List - Uniform Terms for Components/Systems
- IM 240 Emissions Testing - 2 Wheel Drive Dynamometers
- MIL ON - Vehicle Loses Power
- Engine Controls - VAG 1598 Adapter Harnesses
- Seat Belt Stop Button - Broken
- Rear Child Restraint Anchorages - Tethering Updates
- Sunroof Motor Cover - Removing and Installing
- Windshield Wiper Arm Angle - Adjusting
- Windshield Wipers - Chatter/Do Not Clean Window Properly
- Interior Mirror Assembly - Loose
- Outside Mirror Glass - Replacement
- Body Trim - Identifying/Painting Plastic Parts
- VAG 1558 Temperature Tester
- Antifreeze Testers - Accuracy
- Identification/Automatic Transmission
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs1
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Generator V Belt Pulley - Tool For R and R
- A/T - Final Drive Oil
- A/T - New Fluid Type
- A/T - Synthetic Oil for Final Drive
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- Fuse/Relay Panel Cover - Proper Installation
- Speedometer - Gov't Regulations for Replacement
- VAG 1367 Engine Tester - Change
- Wiring - Use Quality Connectors and Proper Crimping Tool
- Stabilant 22A - Electrical Contact Enhancer
- Engine Performance - Fuel Quality and Carbon Deposits
- Gasoline - Fuel Containing Detergents Recommended
- Wheel Alignment - Specifications Update
- Paint - Acid Rain Spots
- Paint - Industrial Fallout
- Paint - Preventing Chipping at Rear Wheel Wells
- Paint - Industrial Fallout Removal (Revised)
- Paint - Color Code Charts
- Brake Fluid - New Super DOT 4
- Brake Fluid - DOT 4 Now Used In Production
- Brake Fluid - Chaning or Topping Off
- Brake Pressure Regulator - New Adapter for Adjustment
- Loctite 325 - Proper Procedures For Obtaining
- Engine - Excessive Cranking Time, Rough Idle
- Power Door Locking System - R and R
- Ignition Distributor - Trigger Wheel Removal
- Sagging Sunvisors
- Differential Gear Oil Level - Maintenance Requirements
- Shift Lever - Inoperative (Only Third/Fourth Gears)
- Shift Lever - Noise
- M/T - Hard Shifting
- Brake - Squeal
- Brake System - Bleeding
- Vehicle - Towing Procedures
- Body - Paint Chip Repair Procedure
- Oxygen Sensor - Contamination