Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Noise
- Lubrication of Engine Oil Seals Prior to Installation
- Pump Relay - Remains Energized With Ignition Off
- Battery - Discharged
- Central Hydraulic System - Fluid Seepage
- Hydraulic System - Oil Loss
- Hydraulic Pump - Noise
- Engine Performance- Poor Driveability
- Engine - Long Cranking Time In Hot Weather
- Fuel Pump - Buzz or Humming Noise
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Hydraulic Valve Lifter - Abnormal Noise
- Hydraulic Valve Lifters - Noisy
- Water Pump - Leaks and Noisy
- Rear Crankshaft Seal - Leaks Oil
- Exhaust - Noise Under the Vehicle
- A/C - Operates In Defrost Mode Only
- A/C - Insufficient Cooling
- Goodyear Tires - Howling or Rumbling Noise
- Body - Door Locks Binding, Difficult to Operate
- Lock Tumblers - Binding, Difficult to Operate
- Locks - Binding/Difficult to Operate
- Power Locking System - Inoperative
- Door Lock Key - Binding
- Clutch Pedal - Noisy When Depressed
- A/T - Delayed/Erratic Upshifts
- A/T - Buzzing Noise
- Engine - Excessive Cranking Time
- Engine Performance - Excessive Cranking Time
- Engine - Poor Driveability DTC 2132 Set
- ABS Pump - Noise and Slight Brake Pedal Vibration
- Ignition Lock - Binding
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Turbo Intercooler - Vehicle Will Not Start
- Engine - Slight Deviations In Fuel Economy
- Catalytic Converter - Odor At Exhaust Pipe
- Interior Light - Stays On/Inoperative
- Interior Light - Stays On/Inoperative
- Front Seat Belt - Binding
- Seat Belt - Squeaks Over Bumps and With Slight Movement
- Seat Belts - Too Short
- Steering Wheel - Shimmy When Braking
- Horn - Prevent Premature Failure
- Brake Lights - Not Functioning
- Radiator Fan - Stays On
- MIL ON - Vehicle Loses Power
- Rear Side Window Molding - Deformed
- Interior Mirror Assembly - Loose
- Front Bumper Chrome Plating - Peeling Off
- C Pillar Exterior Molding - Cracking
- Roof Molding - Defective, Malformed
- Interior - Clicking Noise Inside Vehicle
- Radiator Fan - Continues to Run w/Ignition OFF
- Engine - Intermittent Stalling On Deceleration
- Engine - Will Not Start, Poor Performance
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance, No Start
- Engine - Poor Performance/Will Not Start
- A/T - Noise Transmitted Through the Shift Cable
- Engine - Long Cranking, Intermittent Stumble, Misfire
- Rear Defogger Switch - Problems
- Power Window/Sunroof - Non Functional
- Instrument Panel - Lights Do Not Work With Headlights
- Trunk Light - Stays On/Inoperative
- Engine - Excessive Cranking Time, Rough Idle
- Chemicals,Additives
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Brakes - Brake Pulsation Diagnostic Information
- Electrical - Electrical Malfunctions After Window Tint
- Warranty - Repurchased Vehicle Information
- Bosch Component - Manufacturing Date Codes
- Special Tool Minimum Requirements - Revised
- Part Identifier - Additions/Revisions/Deletions
- Equipment - New Prices
- Limited Warranty - With Powertrain Plus Protection
- Vehicle - Fluid Capacity Chart
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Noise
- Plastilube Moly 3 - Proper Procedures Obtaining
- A/C - Freon Recycling System
- A/C - System Discharging and Environmental Laws
- A/C System - Retrofitting R-12 to R-134a
- Transmissions - Oil Leakage After Installation
- Transmission Oil Seals/Lubricate Prior to Installation
- Engine/Transmission - Tightening Torques Revised
- Engine Oil Seals - Leakage After Replacement
- Lubrication of Engine Oil Seals Prior to Installation
- Special Tool - Engine Tester
- Pump Relay - Remains Energized With Ignition Off
- Battery - Discharged
- Central Hydraulic System - Fluid Seepage
- Hydraulic Pump Banjo Bolt - Replacement
- Hydraulic Pump Piston Cap Seals - Leaking/Replacing
- Hydraulic Pump - Replacement
- Central Hydraulic Pump - Resealing
- Hydraulic System - Oil Loss
- Hydraulic Pump - Noise
- Engine Performance- Poor Driveability
- Fuel Pump - Hot Start/Noise
- Engine - Long Cranking Time In Hot Weather
- Fuel Pump - Replacing
- Fuel Pump - Buzz or Humming Noise
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Front Wheel Bearing - Housing
- Front Wheel Bearing Housing - Outer Clip Omitted
- Wheel Bearing - New Housing
- Steering Gear - Repairing
- Hydraulic Reservoir - Flushing Procedure
- Engine - Journal Sizes and Connecting Rod Bearing
- Hydraulic Valve Lifter - Abnormal Noise
- Hydraulic Valve Lifters - Noisy
- Water Pump - Leaks and Noisy
- Coolant Circulation Pump - Leakage Troubleshooting
- Radiator Fan Bearings - Noisy
- Radiator Expansion Tank - Broken Return Line
- Radiator Neck - Repair Procedure
- Rear Crankshaft Seal - Leaks Oil
- Exhaust - Noise Under the Vehicle
- A/C - Operates In Defrost Mode Only
- Windshield and Windows - Fogging
- A/C - Insufficient Cooling
- Tire/Wheels - Eliminating Vibrations
- Tires - Aerosol Tire Inflator Hazard
- Tires - Revised Rotation Procedure
- Goodyear Tires - Howling or Rumbling Noise
- Gas Strut - Replacement
- Body - Door Locks Binding, Difficult to Operate
- Key Code - Location
- Key Code Location
- Key Code - Locations
- Lock Tumblers - Binding, Difficult to Operate
- Locks - Binding/Difficult to Operate
- Power Locking System - Inoperative
- Door Lock Key - Binding
- Clutch Pedal - Noisy When Depressed
- A/T - Delayed/Erratic Upshifts
- A/T - Buzzing Noise
- Fuel Injection - Quantity, Comparative Measurement
- Engine - Excessive Cranking Time
- Special Tool - Fuel Injection Cleaner Adapter Kit
- Fuel System - Injection Cleaner Adapter Kit
- Engine Performance - Excessive Cranking Time
- ECU - Precautions
- Engine - Poor Driveability DTC 2132 Set
- ABS Pump - Noise and Slight Brake Pedal Vibration
- ABS - Wheel Speed Sensor Testing
- Hydraulic Brake Servo - New Installation Procedures
- Ignition Lock - Binding
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Distributor Caps - Driveability
- Fuel Tank - Capacity Insufficient
- Fuel Tanks - Flushing/Neutralization
- Throttle Body Dashpot - Adjusting
- Turbo Intercooler - Vehicle Will Not Start
- Engine - Slight Deviations In Fuel Economy
- Catalytic Converter - Poor Acceleration, Lack of Power
- Catalytic Converter - Odor At Exhaust Pipe
- Manual Antenna - Installation Procedure
- Checking Window Regulator Current Draw and Stall Current
- Interior Light - Stays On/Inoperative
- Interior Light - Stays On/Inoperative
- Radio -Displaying 'Safe' (Theft Protection Coding)
- Front Seat Belt - Binding
- Seat Belt - Squeaks Over Bumps and With Slight Movement
- Seat Belts - Too Short
- Airbag - Computer Memory Saver Tool Use
- Illuminated Vanity Mirrors - Repairing
- Steering Wheel - Shimmy When Braking
- Brake - Insufficient Ventilation
- Horn - Prevent Premature Failure
- Dynamic Oil Pressure System - Troubleshooting Tips
- Odometer - Disclosure Requirements
- Adaptor Usage - For Aiming Aerodynamic Headlights
- Brake Lights - Not Functioning
- Radiator Fan - Stays On
- Front Crankshaft - Oil Seal Removal Revision
- ABS - Checking With VAG1710
- Brake Pedal Clevis - Adjustment Specifications
- Air Bag Equipped Vehicle - Accident Investigation
- Word List - Uniform Terms for Components/Systems
- IM 240 Emissions Testing - 2 Wheel Drive Dynamometers
- Recall 87V157000: Fuel Vapors Escape Charcoal Filter
- VAG 1551 - Fault Read Out Device Exchange Program
- MIL ON - Vehicle Loses Power
- Engine Controls - VAG 1598 Adapter Harnesses
- Special Tool - Computer Memory Saver
- Interior - Door Panel Speaker Grille Replacing
- Seat Belt Stop Button - Broken
- Rear Child Restraint Anchorages - Tethering Updates
- Sunroof Motor Cover - Removing and Installing
- Windshield Wiper Arm Angle - Adjusting
- Rear Side Window Molding - Deformed
- Interior Mirror Assembly - Loose
- Front Bumper Chrome Plating - Peeling Off
- C Pillar Exterior Molding - Cracking
- Roof Molding - Defective, Malformed
- VAG 1558 Temperature Tester
- Antifreeze Testers - Accuracy
- Central Hydraulic High Pressure Hose - Replacing
- Interior - Clicking Noise Inside Vehicle
- Identification/Automatic Transmission
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - 010, 003 Bind In Reverse/2nd Gear Starts
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs1
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Special Tool - Required to Repair AWD Transmissions
- Generator V Belt Pulley - Tool For R and R
- A/C - Blower Motor Squirrel Cage Rubbing
- A/T - Final Drive Oil
- A/T - Synthetic Oil for Final Drive
- Radiator Fan - Continues to Run w/Ignition OFF
- Engine - Intermittent Stalling On Deceleration
- Engine - Will Not Start, Poor Performance
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance, No Start
- Engine - Poor Performance/Will Not Start
- A/T - Noise Transmitted Through the Shift Cable
- Speedometer - Gov't Regulations for Replacement
- VAG 1367 Engine Tester - Change
- Engine - Long Cranking, Intermittent Stumble, Misfire
- Rear Defogger Switch - Problems
- Stabilant 22A - Electrical Contact Enhancer
- Engine Performance - Fuel Quality and Carbon Deposits
- Fuel System - Chemical Cleaning Procedures
- Gasoline - Fuel Containing Detergents Recommended
- Campaign - Fuel System Modification/Leaks
- Paint - Acid Rain Spots
- Paint - Industrial Fallout
- Paint - Industrial Fallout Removal (Revised)
- Paint - Color Code Charts
- Brake Fluid - New Super DOT 4
- Brake Fluid - Chaning or Topping Off
- Brakes - Adjusting the Pressure Regulator
- Brake Pressure Regulator - New Adapter for Adjustment
- Power Window/Sunroof - Non Functional
- Instrument Panel - Lights Do Not Work With Headlights
- Trunk Light - Stays On/Inoperative
- Loctite 325 - Proper Procedures For Obtaining
- Recall 89V006000: Fuel Injection Seal Leak
- Engine - Excessive Cranking Time, Rough Idle
- Recall - A/T, Differential Oil Replacement
- Recall - Differential Oil Change, A/T 087 and 089
- Recall 93V006000: Automatic Transaxle Gear Oil Loss
- Sagging Sunvisors
- Differential Gear Oil Level - Maintenance Requirements
- Brake - Squeal
- Brake System - Bleeding
- Body - Paint Chip Repair Procedure
- Restraint System - 'LATCH' System Installation/Retrofit
- Oxygen Sensor - Contamination
- Airbag - Replacement Interval Change