Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Chassis Frame - Whistling Noise At 35 to 50 MPH
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Noise
- Lubrication of Engine Oil Seals Prior to Installation
- Central Hydraulic System - Fluid Seepage
- Engine Performance- Poor Driveability
- Engine - Long Cranking Time In Hot Weather
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Power Steering Gear - Leaking
- Hydraulic Valve Lifters - Noisy
- Valve Lifters - Noisy
- Engine - Oil Leaks From the Front
- Water Pump - Leaks and Noisy
- Rear Crankshaft Seal - Leaks Oil
- Alternator - V Belt Noisy/Loose Adjustment
- Exhaust - Noise Under the Vehicle
- Goodyear Tires - Howling or Rumbling Noise
- Body - Door Locks Binding, Difficult to Operate
- Front Door - Cannot Be Locked/Unlocked With Key
- Lock Tumblers - Binding, Difficult to Operate
- Power Locking System - Inoperative
- Door Lock Key - Binding
- Seat/Backrest Leather Cover - Poor Appearance
- Clutch Pedal - Noisy When Depressed
- Engine Performance - Excessive Cranking Time
- ABS Pump - Noise and Slight Brake Pedal Vibration
- A/T - No Start In Neutral/Backup Lights Inoperative
- Ignition Lock - Binding
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Catalytic Converter - Odor At Exhaust Pipe
- Front Seat Belt - Binding
- Seat Belt - Squeaks Over Bumps and With Slight Movement
- Speedometer - Intermittent/Inoperative
- Radiator Fan - Stays On
- MIL ON - Vehicle Loses Power
- Body - Rear Lid Lock Inoperative
- Rear LId - Gas Filled Struts
- Body - Front Door Difficult to Open From Inside
- Interior - Door Panel Trim Separating
- Interior - Door Panel Trim Separating At Top Moulding
- Interior Mirror Assembly - Loose
- Power Mirror Glass - Spotted, Scratched
- Side Panel - Corrosion/Paint Damage
- Coin Box Door - Does Not Stay Closed
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- Rear Defogger Switch - Problems
- Engine - Excessive Cranking Time, Rough Idle
- Power Door Lock System - Inoperative
- Trip Computer - Miles to Empty Reads Low While Driving
- Woodtrim - Milky Appearance, Cracks
- Sunvisor - Improper Operation, Poor Appearance
- Vanity Mirror - Loose, Falls Out
- Radio - Poor AM Reception/Interference
- Trunk Lid - Buzzing Noise When Closing
- Gearshift Mechanism - Squeaks/Rattles
- Board Computer MPG - Miles to Empty Incorrect
- Chemicals,Additives
- Factory Modifications
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Chassis Frame - Whistling Noise At 35 to 50 MPH
- Brakes - Brake Pulsation Diagnostic Information
- Electrical - Electrical Malfunctions After Window Tint
- Recall 91V050000: Jacking Instruction Label Incorrect
- Warranty - Repurchased Vehicle Information
- Warranty Claims - Revised
- Bosch Component - Manufacturing Date Codes
- Special Tool Minimum Requirements - Revised
- Part Identifier - Additions/Revisions/Deletions
- Limited Warranty - With Powertrain Plus Protection
- Vehicle - Fluid Capacity Chart
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Noise
- Plastilube Moly 3 - Proper Procedures Obtaining
- A/C - Freon Recycling System
- A/C - System Discharging and Environmental Laws
- A/C System - Retrofitting R-12 to R-134a
- Transmissions - Oil Leakage After Installation
- Transmission Oil Seals/Lubricate Prior to Installation
- Engine/Transmission - Tightening Torques Revised
- Engine Oil Seals - Leakage After Replacement
- Lubrication of Engine Oil Seals Prior to Installation
- Central Hydraulic System - Fluid Seepage
- Engine Performance- Poor Driveability
- Engine - Long Cranking Time In Hot Weather
- Fuel Pump - Replacing
- Disc Brake - Squeal
- Brake System - Noise and Chatter/Pulsation
- Power Steering Gear - Leaking
- Hydraulic Valve Lifters - Noisy
- Valve Lifters - Noisy
- Tools - Crankshaft Seal Remover
- Engine - Oil Leaks From the Front
- Water Pump - Leaks and Noisy
- Coolant Circulation Pump - Leakage Troubleshooting
- Rear Crankshaft Seal - Leaks Oil
- Alternator - V Belt Noisy/Loose Adjustment
- Exhaust - Noise Under the Vehicle
- Tire/Wheels - Eliminating Vibrations
- Tires - Aerosol Tire Inflator Hazard
- Goodyear Tires - Howling or Rumbling Noise
- Gas Strut - Replacement
- Body - Door Locks Binding, Difficult to Operate
- Front Door - Cannot Be Locked/Unlocked With Key
- Key Code - Locations
- Lock Tumblers - Binding, Difficult to Operate
- Power Locking System - Inoperative
- Door Lock Key - Binding
- Seat/Backrest Leather Cover - Poor Appearance
- Clutch Pedal - Noisy When Depressed
- Fuel System - Injection Cleaner Adapter Kit
- Engine Performance - Excessive Cranking Time
- ECU - Precautions
- ABS Pump - Noise and Slight Brake Pedal Vibration
- ABS - Wheel Speed Sensor Testing
- Brake Master Cylinder/Reservoir Rubber Plug Leaking
- A/T - No Start In Neutral/Backup Lights Inoperative
- Ignition Lock - Binding
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Distributor Caps - Driveability
- Fuel Tank - Capacity Insufficient
- Fuel Tanks - Flushing/Neutralization
- Catalytic Converter - Poor Acceleration, Lack of Power
- Catalytic Converter - Odor At Exhaust Pipe
- Checking Window Regulator Current Draw and Stall Current
- Pro Training Booklet - Radio Reception
- Radio Adaptor Harness - Installing
- Radio Codes - On Line Retrieval
- Front Seat Belt - Binding
- Seat Belt - Squeaks Over Bumps and With Slight Movement
- Recall 97V172000: Air Bag Deployment Without Warning
- Airbag - Computer Memory Saver Tool Use
- Campaign - Air Bag Module Replacement
- Illuminated Vanity Mirrors - Repairing
- Brake - Insufficient Ventilation
- Fault Code 2132
- Fuel and Ignition System - Electrical Testing
- Dynamic Oil Pressure System - Troubleshooting Tips
- Odometer - Disclosure Requirements
- Instrument Bulb - Replacement
- Speedometer - Intermittent/Inoperative
- Radiator Fan - Stays On
- Front Crankshaft - Oil Seal Removal Revision
- ABS - Checking With VAG1710
- Brake Pedal Clevis - Adjustment Specifications
- Rear Control Arm Support - Replacing Rubber Bushing
- Air Bag Equipped Vehicle - Accident Investigation
- Word List - Uniform Terms for Components/Systems
- IM 240 Emissions Testing - 2 Wheel Drive Dynamometers
- VAG 1551 - Fault Read Out Device Exchange Program
- Engine Performance - Service Recommendations
- MIL ON - Vehicle Loses Power
- Body - Rear Lid Lock Inoperative
- Rear LId - Gas Filled Struts
- Body - Front Door Difficult to Open From Inside
- Interior - Door Panel Speaker Grille Replacing
- Interior - Door Panel Speaker Grille Replacement
- Interior - Door Panel Trim Separating
- Interior - Door Panel Trim Separating At Top Moulding
- Rear Child Restraint Anchorages - Tethering Updates
- Sunroof Motor Cover - Removing and Installing
- Sunroof Motor - Changes
- Windshield Wiper Arm Angle - Adjusting
- Interior Mirror Assembly - Loose
- Power Mirror Glass - Spotted, Scratched
- Door Protective Molding - Loose, Sagging
- Side Panel - Corrosion/Paint Damage
- VAG 1558 Temperature Tester
- Antifreeze Testers - Accuracy
- Coin Box Door - Does Not Stay Closed
- Identification/Automatic Transmission
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - ATF Leaking From Differential Pinion Seal Vent
- A/T - 010/087/089/090 Bind In Low and Reverse
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - ATF Entering The Differential
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs1
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Modifications
- Special Tool - Required to Repair AWD Transmissions
- Engine - Installing Drive Plate to Avoid Cracking
- Generator V Belt Pulley - Tool For R and R
- A/T - Final Drive Oil
- A/T - Synthetic Oil for Final Drive
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- Speedometer - Gov't Regulations for Replacement
- VAG 1367 Engine Tester - Change
- Rear Defogger Switch - Problems
- Stabilant 22A - Electrical Contact Enhancer
- Gasoline - Fuel Containing Detergents Recommended
- Paint - Acid Rain Spots
- Paint - Industrial Fallout
- Paint - Industrial Fallout Removal (Revised)
- Paint - Color Code Charts
- Brake Fluid - New Super DOT 4
- Brake Fluid - Chaning or Topping Off
- Shift Lock Sticker - Bubbling
- Brake Pressure Regulator - New Adapter for Adjustment
- Loctite 325 - Proper Procedures For Obtaining
- Recall 89V006000: Fuel Injection Seal Leak
- Engine - Excessive Cranking Time, Rough Idle
- Recall - A/T, Differential Oil Replacement
- Recall - Differential Oil Change, A/T 087 and 089
- Recall 93V006000: Automatic Transaxle Gear Oil Loss
- Power Door Lock System - Inoperative
- Trip Computer - Miles to Empty Reads Low While Driving
- Woodtrim - Milky Appearance, Cracks
- Sagging Sunvisors
- Sunvisor - Improper Operation, Poor Appearance
- Vanity Mirror - Loose, Falls Out
- Radio - Poor AM Reception/Interference
- Trunk Lid - Buzzing Noise When Closing
- Gearshift Mechanism - Squeaks/Rattles
- Board Computer MPG - Miles to Empty Incorrect
- Brake - Squeal
- Brake System - Bleeding
- Wheel Alignment - Data For Front and Rear Axles
- Body - Paint Chip Repair Procedure
- Restraint System - 'LATCH' System Installation/Retrofit
- Oxygen Sensor - Contamination
- Airbag - Replacement Interval Change
- Restraints - Air Bag/Pyrotechnic Deployment Inquiries