Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Chemicals,Additives
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Brakes - Brake Pulsation Diagnostic Information
- Electrical - Electrical Malfunctions After Window Tint
- 209002 - 05/31/90
- 209003 - 06/15/90 Updates TSB 209002 Dated 05/31/90
- Recall 91V050000: Jacking Instruction Label Incorrect
- Warranty - Repurchased Vehicle Information
- Special Tool Package - Automatic Supply Program
- Special Tool Minimum Requirements - Revised
- Part Identifier - Additions/Revisions/Deletions
- Warranty - Covering Fire or Accident Damage
- Limited Warranty - With Powertrain Plus Protection
- Vehicle - Fluid Capacity Chart
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Brakes - Insufficient Ventilation
- Temperature Sensor - False Engine Overheating Signal
- A/C - Freon Recycling System
- A/C - System Discharging and Environmental Laws
- A/C System - Retrofitting R-12 to R-134a
- Climate Control - Inoperative, Fuse S17 Blows
- Transmissions - Oil Leakage After Installation
- Transmission Oil Seals/Lubricate Prior to Installation
- Engine Oil Seals - Leakage After Replacement
- Lubrication of Engine Oil Seals Prior to Installation
- Fuel Pump - Replacing
- Disc Brake - Squeal
- Front End - Knocking Noise During Turns
- Power Steering Gear - Leaking
- Toothed Belt - Adjustment
- Engine Valve Covers - Leaking
- Tools - Crankshaft Seal Remover
- Water Pump - Coolant Leakage
- Coolant Circulation Pump - Leakage Troubleshooting
- Viscous Cooling Fan - Removing/Installing
- Exhaust - Noise Under the Vehicle
- Tire/Wheels - Eliminating Vibrations
- Directional Tires - Rotate at 7,500 Miles
- Tires - Aerosol Tire Inflator Hazard
- Wheels - Diagonally Rotate at 7,500 Miles
- Gas Strut - Replacement
- Body - Door Locks Binding, Difficult to Operate
- Front Door - Cannot Be Locked/Unlocked With Key
- Front Door - Will Not Lock/Unlock With Key
- Key Code - Locations
- Lock Tumblers - Binding, Difficult to Operate
- Door Lock Key - Binding
- Front Power Seats - Insufficient Headroom
- Adjustable Arm Rest - Inoperable
- Front Door - Air or Water Leaks, Noisy
- Clutch Pedal - Noisy When Depressed
- Injectors - Leak Causing Hydro Lock No Start
- ECU - Precautions
- ABS Pump - Noise and Slight Brake Pedal Vibration
- ABS - Wheel Speed Sensor Testing
- Ignition Lock - Binding
- MIL ON - DTC 2141, 2142 or 2143, Knock Sensor
- Distributor Caps - Driveability
- Fuel Tank - Capacity Insufficient
- Fuel Tanks - Flushing/Neutralization
- Recall 96V084000: Throttle Not Returning to Full Idle
- Catalytic Converter - Housing Corrosion
- Catalytic Converter - Odor At Exhaust Pipe
- A/T - Harsh Shift Points (1-2)
- A/T - New Shifting Performance In Manual Mode
- Checking Window Regulator Current Draw and Stall Current
- Power Mirror Switch - Malfunction
- Campaign - Cruise Control Rod Bushing Replacement
- Fixed Coded Radios, Coding Description
- Radio - RPM Dependent Whine
- Pro Training Booklet - Radio Reception
- Radio Codes - On Line Retrieval
- Cell Phone - Eliminating Feedback In Hands Free Mode
- Armrest W/Telephone - Repairing Ratchet Mechanism
- Telephone - Assembly, Repairing, Troubleshooting
- Seat Belt Fastening Bolts - Changed
- Active Airbag Unit - Disposal
- Airbag Date Sticker - Replacing
- Recall 97V172000: Air Bag Deployment Without Warning
- Airbag - Computer Memory Saver Tool Use
- Campaign - Air Bag Module Replacement
- Illuminated Vanity Mirrors - Repairing
- Steering Wheel - Shimmy When Braking
- Brake Rotors - Shimmy
- Brake - Insufficient Ventilation
- Service Manual - Repair Groups Renamed to Group 01
- Engine Performance - Recommendation/Background Info
- Fuel Gauge - Intermittent Loss of Fuel Level Display
- Oil Pressure Light - Intermittent Flashing
- Odometer - Disclosure Requirements
- Instrument Bulb - Replacement
- ABS - Checking With VAG1710
- Rear Control Arm Support - Replacing Rubber Bushing
- Recall 90V070000: Steering Lock Improperly Manufactured
- Protective Transportation Coating - Removal
- Air Bag Equipped Vehicle - Accident Investigation
- Airbag/Pyrotechnic Seatbelt - Deployment Inquiries
- California Clean Air Requirements - US Only
- Word List - Uniform Terms for Components/Systems
- IM 240 Emissions Testing - 2 Wheel Drive Dynamometers
- VAG 1551 - Fault Read Out Device Exchange Program
- Engine Controls - VAG 1598 Adapter Harnesses
- Trunk Lock Cover - Loose
- Rear LId - Gas Filled Struts
- Interior - Door Panel Speaker Grille Replacing
- Interior - Door Panel Speaker Grille Replacement
- Interior - Door Panel Speaker Grille Broken
- Front Hood - Corrosion Protection
- Front Hood - Hard to Open, Stiff Hinges
- Rear Child Restraint Anchorages - Tethering Updates
- Sunroof Motor Cover - Removing and Installing
- Sunroof Motor - Changes
- Windshield Wiper Arm Angle - Adjusting
- Interior Mirror Assembly - Loose
- Body - R/H Rear Bumper Cover Cracked
- C Pillar Exterior Molding - Cracking
- Door Protective Moldings - Loose
- Door Sills - Road Dirt and Grime
- Armrest Cover Plastic Hinge - Broken
- Engine Oil - Capacity
- VAG 1558 Temperature Tester
- Antifreeze Testers - Accuracy
- Identification Label - Relocated
- A/T - Service Manual Revisions
- Identification/Automatic Transmission
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - Failsafe Modes
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs1
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Special Tool - Required to Repair AWD Transmissions
- Flywheel - Removal and Installation
- Generator V Belt Pulley - Tool For R and R
- A/C - Blower Motor Squirrel Cage Rubbing
- A/T - Final Drive Oil
- A/T - Checking Fluid Temperature/Level
- A/T - Synthetic Oil for Final Drive
- Headlight Wiper Motor Connector - Modifying
- Rear Cigarette Lighter - Shorts, Blows Fuse Number 4
- Speakers - Pop, Erratic A/C Display, Engine Misfires
- Engine - Hard Starting, Misfire and Poor Mileage
- Engine - Poor Performance/Will Not Start
- A/T - Speed Sensor Specification Change
- Lighting - Fuse # 14 Lights Inoperative
- Speedometer - Gov't Regulations for Replacement
- VAG 1367 Engine Tester - Change
- Stabilant 22A - Electrical Contact Enhancer
- Gasoline - Fuel Containing Detergents Recommended
- Driveshaft/Rear Final Drive Flange - Balancing
- A/T - Shift Points Too Early or Too Late
- Paint - Acid Rain Spots
- Paint - Acrylic Transit Protective Coating
- Paint - Industrial Fallout
- Paint - Stained At Windshield Washer Nozzles
- Paint - Protective Transportation Coating Removal
- Paint - Industrial Fallout Removal (Revised)
- Paint - Color Code Charts
- Brake Fluid - New Super DOT 4
- Brake Fluid - Chaning or Topping Off
- Sound Damping Pan - Loose/Noisy
- Brake Pressure Regulator - New Adapter for Adjustment
- Engine - Excessive Cranking Time, Rough Idle
- Heated Lock - Possible Damage During Installation
- Sunroof Wind Deflector - Corrosion On Springs and Hinges
- A/C - Water from Air Vents/Moisture in Front Footwell
- Recall - A/T, Differential Oil Replacement
- Recall - Differential Oil Change, A/T 087 and 089
- Dashboard Cover - Loosening of Material
- Woodtrim - Milky Appearance, Cracks
- Sagging Sunvisors
- Sunvisor - Improper Operation, Poor Appearance
- Hydraulic System - New Fluid
- Brake - Squeal
- Brake System - Bleeding
- A/T - Engine Stalling/Transmission Leaking
- A/T - Engine Stalling
- Recall 90V069000: Front Seat Back Hinge Separation
- Body - Paint Chip Repair Procedure
- Oxygen Sensor - Contamination
- Audio System - Radio, Code Retrieval
- Airbag - Replacement Interval Change
- CD Player - Jams or Will Not Eject
- Restraints - Air Bag/Pyrotechnic Deployment Inquiries