Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 99V248000: Tie Rod End Seal Failure
- Recall 99V131001: Brake Booster Vacuum Valve Failure
- Recall 04V495000: Throttle Body Freezing
- Recall 00V137000: Fuel Gauge Incorrect
- Recall 01V157000: Fuel Gauge Inaccurate
- Recall 04V133000: Knee Bolster Cover Installation
- Recall 99V058000: Fuel Tank Spray During Fill
- Recall 06V198000: Potential Under Dash Electrical Fire
- Customer Interest
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Disc Brake - Squeal
- Engine - Cranks But Won't Start
- Front Suspension - Noise When Driving Over Rough Roads
- Seat Memory Positions - Erratic Operation
- Underbody Plugs - Wind Noise
- Rear Window - Creaking/Popping Noise
- Exterior Rear View Mirrors - Heating Conditions
- Exterior Mirror - Inoperative
- Rear Cup Holder - Damaged
- A/C - Fresh Air Control Lever Light Inoperative
- Remote Transmitter - Intermittently Inoperative
- Steering - Power Steering System Noises
- Body - Front Door Windows Stiff or Inoperative
- Fuel System - MIL ON/Multiple Fuel Trim DTC's Set
- Instruments - Drivers Information Display Fades
- Engine - Coolant Leak at Oil Cooler Hoses
- Brakes - ABS Activates Upon Light Braking
- Fuel System - Idle Fluctuates or is Too Low
- Lighting - Hazard Switch Binds After Replacement
- MIL ON, DTCs P0300/301/302/303/304/305/306 Misfire
- Wipers/Washers - Windshield Wipers Streak/Smear/Noisy
- Audio System - CD Error (ERR) Message Displayed
- Steering - Power Steering System Is Noisy
- Engine - Oil Loss From The Oil Cooler
- Electrical - Cigarette Lighter Won't Heat Up
- Recommended Repairs
- Superceded Bulletins
- 170912 - 06/24/09
- 460001 - 01/05/00
- 940302 - 06/24/03
- 690503 - 03/11/05
- Electrical - DTCs, Sporadic - Contact Check
- 480501 - 02/03/05
- 200601 - 02/03/06
- 910406 - 04/16/04
- 8599-02 - 12/09/99
- 679704 - 08/31/98
- 4698-01 - 04/21/98
- 46-97-01 - 11/25/97
- 469901 - 11/02/99
- 640803 - 07/10/08
- Wipers/Washers - Wipers Do Not Clean Windshield
- Wipers/Washers - Windshield Wipers Streak/Smear/Noisy
- Wipers/Washers - Windshield Wipers Streak or Smear
- Wipers - Smear or Streak Windshield
- Front Door Windows - Bind or Do Not Operate
- Front Window - Binds or Does Not Operate
- Lighting - Exterior Light Moisture Accumulation
- Lighting - Headlamp Aiming Information
- Lighting - Moisture Accumulation in Headlamps
- Headlight - Moisture Accumulation
- Headlights - Moisture Accumulation
- Headlight - Aiming Using Hella Universal Beamsetter IV
- Lighting - Hazard Switch Binds After Replacement
- Lighting - Condensation in Exterior Lamps
- Lighting - Moisture Accumulation In Exterior Lamps
- 940801 - 01/09/08
- 940715 - 11/07/07
- Lighting - Exterior Lamp Moisture Accumulation
- Lights - Condensation Visible Inside Exterior Lamps
- Lights -Condensation Visible Inside Exterior Lamps
- Lights - Condensation Visible Inside Exterior Lamps
- Lighting - Condensation in Exterior Lamp(s)
- Instrument Cluster - Driver Information Display Fades
- Instrument Cluster - Driver's Information Display Fades
- Electrical - Cigarette Lighter Does Not Work
- Electrical - Cigarette Lighter Does Not Work
- Interior - Cleaning Tips for Fabrics, Vinyls, Plastics
- Light Colored Metallic Paint - Appearance
- Exterior Rear View Mirror Heating - Inoperative
- Leather Upholstery - Cleaning Procedures
- Interior - Cleaning Tips
- Leather Upholstery - Cleaning Tips
- Interior - Fabrics, Vinyls and Plastics, Cleaning Tips
- Floor Mat - Fastener Installation Variations
- Body - Rear License Plate Fastener Replacement
- Rear License Plate - Damaged Fastener Replacement
- Instruments - Drivers Information Display Fades
- Audio System - Radio Antitheft Code Entering/Retrieval
- Audio System - Radio, Code Retrieval
- Audio System - Radio Code Retrieval
- Audio System - CD Player Information
- Audio System - CD Playback Problem Information
- 910862 - 11/07/08
- Audio System - CD Playback Problems
- Audio System - CD Error (ERR) Message Displayed
- Central Locking System Functions and Options
- Central Locking System - Functions and Options
- Central Locking System - Functions and Options
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Child Restraint - Anchor Installation/Retrofitting
- Restraints - LATCH(R) System Retrofitting
- Restraints - Airbag/Safety Belt Deployment, Inquiries
- Airbag - Replacement Interval Change
- Restraints - Air Bag Replacement Interval Change
- A/C - Musty Odors From Vents
- Steering - Power Steering Noise
- Brakes - Brake Pulsation Diagnostic Information
- Brakes - Squealing Condition
- Brakes - Brakes Squeal
- 460902 - 12/06/09
- Brakes - Squealing Noise
- Brakes - Pulsation Diagnostic Information
- 460808 - 09/10/08
- Brakes - Squealing Noise
- 460801 - 01/14/08
- Brakes - Squealing Noises
- 460904 - 08/17/09
- Brakes - Brake Squeal Service Procedure Information
- 450801 - 10/07/08
- Brakes - ABS Activates Upon Light Braking
- Fuel System - Throttle Body Icing
- 240803 - 02/05/08
- Recall - Throttle Body Freezing/Sticking
- Recall - Throttle Body Freezing
- Fuel System - Idle Fluctuates or is Too Low
- Fuel System - Fuel Neutralization Procedure
- TCS/ABS ESP Lamp ON/DTC Stored In ECM
- ABS/TCS - ESP Lamp ON/DTC Stored In ECM Information
- Fuel System - MIL ON/Multiple Fuel Trim DTC's Set
- Fuel System - MIL ON/DTC's P1123/P1125/P1137/P1139
- Engine - Hesitation/Lack of Power On Take Off
- Engine - Idle Fluctuation or Idle Speed Too Low
- Engine - Inspect for Debris When Replacing Engine
- Engine - Cold Start Rattle/Knocking Noise Explanation
- Engine - Rattle/Knock On Cold Start-Up (Normal)
- Engine - Oil Loss From Oil Cooler
- Engine - Valve Cover Gasket Oil Leak Diagnosis
- Engine - Rattling Noise On Start Up
- Brakes - Pulsation Diagnostic Guidelines
- Brakes - Pulsation
- Oil Cooler Hoses - Coolant Leak
- Engine - Coolant Leak at Oil Cooler Hoses
- Alloy Wheel - Cleaning
- Alloy Wheels - Cleaning Without Causing Damage
- Brakes - Brake Pulsation Diagnostic Information
- Engine Oil - Capacities
- Engine Oil - Capacity Update
- Engine - Oils Meeting Standards VW502 00/VW505 01
- Engine - Approved Engine Oils
- Engine - Oils Meeting Specifications VW 502 00/VW 505 01
- Steering - Power Steering Noisy
- Engine - Oils Meeting Audi Standards 502 00, 505 01
- Engine - Oils Meeting VW Standards VW 502 00/505 01
- Steering - Power Steering Is Noisy
- 480913 - 12/11/09
- Engine - Oil Meeting Audi Quality Standards
- Cooling System - Coolant ID/Filling/Mixing Information
- Engine - Oil Meeting Audi Quality Standards
- Fuel System - Engine Cranks, No Start
- Engine - Cranks But Will Not Start
- MIL ON, DTCs P0300/301/302/303/304/305/306 Misfire
- Engine - Debris Inspection When Replacing Engine
- All Technical Service Bulletins
- Lighting - Moisture Accumulation In Exterior Lamps
- Wheels - Wheel Bolt Torque Precautions
- Engine - Oil Meeting Audi Quality Standards
- Brakes - Brake Pulsation Diagnostic Information
- Electrical - Electrical Malfunctions After Window Tint
- Audio System - Nonstandard CD Playback Problems
- Fuel System - Throttle Body Replacement Kit Installation
- TCS/ABS - ESP Lamp ON/DTC Stored In ECM
- VIN Plate/Certification Label - Ordering Procedure
- Warranty Claims - Conditions Requiring OTS Contact
- Wiring Harness - Repairing
- Brakes/Suspension - Pedal Pulsation/Steering Shimmy
- Disc Brake - Squeal
- Engine - Cranks But Won't Start
- Front Suspension - Noise When Driving Over Rough Roads
- Recall 99V248000: Tie Rod End Seal Failure
- Recall 00V414000: Excessive Tie Rod Wear
- Alloy Wheels - Cleaning
- Plastic Lug Bolt Cover - Removal Tool
- Sidewinder Key and Lock - Replacement
- Floor Mats - Missing Logo
- Seat Memory Positions - Erratic Operation
- Oxygen Sensor - Verifying Connections After Repairs
- Recall 99V131001: Brake Booster Vacuum Valve Failure
- Battery - Correct Din Specification Necessity
- Fuel Tanks - Flushing/Neutralization
- Recall 04V495000: Throttle Body Freezing
- Cellular Phone - Installation Instructions
- Cellular Phone - Installation
- Cell Phone - Serial Number Recording
- Cellular Phone - Technical Support Helpline
- Deployed Air Bag - Repair Warning
- Recall 00V137000: Fuel Gauge Incorrect
- Recall 01V157000: Fuel Gauge Inaccurate
- Headlights - Aiming Using Hella Universal Beamsetter IV
- Lighting - Exterior Lighting Moisture Accumulation
- Steering Wheel - Does Not Heat Or Stay Warm
- Underbody Plugs - Wind Noise
- Side Airbags - On Board Diagnostics
- Airbag/Pyrotechnic Seatbelt - Deployment Inquiries
- Repair Manual - Updates/Revisions
- Rear Window - Creaking/Popping Noise
- Wiper Blades - Skip
- Exterior Rear View Mirrors - Heating Conditions
- Exterior Mirror - Inoperative
- Rear Cup Holder - Damaged
- Vehicle - Fluid Capacity Chart
- M/T - Remanufactured Units Pre-Filled with Oil
- A/C - Fresh Air Control Lever Light Inoperative
- Recall 04V133000: Knee Bolster Cover Installation
- Radio - Connector Replacement
- Remote Transmitter - Intermittently Inoperative
- Steering - Power Steering System Noises
- Daytime Running Lights - Function Change
- Maintenance Schedule - Update
- Maintenance - Schedule
- Vehicle - Fluid Capacities
- Alignment - Requirements After Component R and I
- Recall 99V058000: Fuel Tank Spray During Fill
- Recall 06V198000: Potential Under Dash Electrical Fire
- Body - Paint Chip Repair Procedure
- Restraint System - 'LATCH' System Installation/Retrofit
- Body - Front Door Windows Stiff or Inoperative
- Fuel System - MIL ON/Multiple Fuel Trim DTC's Set
- Instruments - Drivers Information Display Fades
- Engine - Rattle/Knock On Cold Start-Up (Normal)
- Engine - Coolant Leak at Oil Cooler Hoses
- Brakes - ABS Activates Upon Light Braking
- Fuel System - Fuel Neutralization Procedure
- Fuel System - Idle Fluctuates or is Too Low
- Audio System - Radio, Code Retrieval
- Airbag - Replacement Interval Change
- Lighting - Headlamp Aiming Information
- Lighting - Hazard Switch Binds After Replacement
- Interior - Cleaning Tips For Fabrics, Vinyls, Plastics
- MIL ON, DTCs P0300/301/302/303/304/305/306 Misfire
- Restraints - LATCH(R) System Retrofitting
- Wipers/Washers - Windshield Wipers Streak/Smear/Noisy
- Engine - Oils Meeting VW Standards VW 502 00/505 01
- Audio System - CD Error (ERR) Message Displayed
- Audio System - Radio Antitheft Code Information
- Light Colored Metallic Paint - Appearance
- Floor Mat - Fastener Installation Variations
- Body - Rear License Plate Fastener Replacement
- Steering - Power Steering System Is Noisy
- Locks - Remote/Central Locking Function Activation
- Engine - Oil Loss From The Oil Cooler
- Engine - Inspect For Debris In Transferred Assemblies
- Restraints - Air Bag/Pyrotechnic Deployment Inquiries
- Electrical - Cigarette Lighter Won't Heat Up
- Cooling System - Coolant ID/Filling/Mixing Information