Attachment Bulletin # 910513
Group: 91Number: 05-13
Date: Sept. 8, 2005
Subject:
Door Speakers, Intermittently Inoperative
Model(s):
See Table 2002 > 2004
Condition
Sound from door speakers in one door intermittently stops operating.
This condition may occur while driving (especially on rough road) or in cold weather when opening/closing the doors.
This condition may be corrected by increasing radio volume.
May be caused by intermittent electrical contact of door speaker wiring harness terminals due to grease in electrical connector at A-Pillar.
Production
Grease eliminated from wiring harness door electrical connector as of the VINs shown.
Service
- Disconnect door electrical connector. Clean door connector using one of the following methods.
- Wipe away grease with towel.
- Remove grease using suitable solvent
- Blow out connector with air pressure.
- Connect door connector and assure proper wiring and harness end connection.
If cleaning door electrical connector does not correct condition:
- Contact Audi Dealer Technician Helpline.
When procedure applies to vehicles within the New Vehicle Limited Warranty, use the table.