Air Distributor Housing
Air Distributor Housing
• Levers and cam disks are provided with code numbers. In case of doubt about assignment of one of these components, observe assignment
• Apply a small amount of Grease (G 000 150) to the curved washer guides and the pins on the door levers.
1 Seal
2 Air guide
• With shut-off doors
• Air guide to right chest vent and to indirect ventilation of right instrument panel
• Do not dismantle
3 Self-tapping screw
4 Lever
• Not to be removed risk of interchange
• Heed assignment code number "862"
5 Lever
• Not to be removed risk of interchange
• Heed assignment code number "861"
6 Cam disk
• Mark before removing risk of interchange
• Heed assignment code number "154")
7 Bracket
• Mark before removing risk of interchange
• Heed assignment no code number
8 Self-tapping screw
9 Right Front Defrost/Upper Body Shut-off Door Motor (V199)
• With Right Center Vent Motor Position Sensor (G317)
• Removing and installing, refer to => [ Right Front Defrost/Upper Body Shut Off Door ]
10 Self-tapping screw
11 Seal
12 Seal
13 Air guide
• With shut-off doors
• Air guide to left chest vent and to indirect ventilation of left instrument panel
• Do not dismantle
14 Lever
• Not to be removed risk of interchange
• Heed assignment code number "863")
15 Cam disk
• Mark before removing risk of interchange
• Heed assignment code number "155")
16 Bracket
• Mark before removing risk of interchange
• Heed assignment no code number
17 Left Front Defrost/Upper Body Shut-off Door Motor (V200)
• With Right Center Vent Motor Position Sensor (G318)
• Removing and installing, refer to => [ Left Front Defrost/Upper Body Shut Off Door ]
18 Defroster Door Motor (V107)
• With Right Center Vent Motor Position Sensor (G135)
• Removing and installing, refer to => [ Defroster Door Motor ]
19 Lever
• Mark before removing risk of interchange
• Heed assignment (code number "837")
• Lever at door is marked "838" remains with coupling rod at defroster door in air distributor housing
20 Self-tapping screw
21 Left Vent Temperature Sensor (G150)
• Removing and installing, refer to => [ Left Vent ] Service and Repair.
22 Air guide
• With shut-off doors
• Air duct to left footwell vents
• Do not dismantle
23 Lever
• Not to be removed risk of interchange
• Heed assignment (code number "842")
24 Cam disk
• Mark before removing risk of interchange
• Heed assignment (code number "157")
25 Bracket
• Mark before removing risk of interchange
• Heed assignment (no code number)
26 Left Footwell Door Motor (V108)
• With Right Center Vent Motor Position Sensor (G139)
• Removing and installing, refer to => [ Left Footwell Door ]
27 Lever
• Mark before removing risk of interchange
• Heed assignment (code number "835")
• Lever at door is marked "836" remains at cold-air door in air distributor housing
28 Center Vent Adjustment Motor (V102)
• With Right Center Vent Motor Position Sensor (G138)
• This actuator operates cold-air door. refer to => [ A/C Unit Components in Passenger Compartment ] A/C Unit Components in Passenger Compartment
• Removing and installing, refer to=> [ Center Vent Adjustment ]
29 Air distribution housing
• Do not dismantle
• Different versions,
• On vehicles with Rear A/C Control Head (Climatronic) (E265), doors are installed in rear air guides and connection to rear cold-air duct is open.
• On vehicles without Rear A/C Control Head (Climatronic) (E265), there are no doors installed in rear air guides and connection to rear cold-air duct is sealed.
30 - Seal
31 - Right Vent Temperature Sensor (G151)
• Removing and installing, refer to=> [ Right Vent ]
32 - Lever
• Mark before removing risk of interchange
• Heed assignment (code number "833")
• Lever at door is marked "834" remains at warm-air door in air distributor housing
33 - Temperature Regulator Door Motor (V68)
• With Right Center Vent Motor Position Sensor (G92)
• This actuator operates warm-air door. Refer to => [ A/C Unit Components in Passenger Compartment ]
• Removing and installing, refer to => [ Temperature Regulator Door ]
34 - Air guide
• With shut-off doors
• Air duct to right footwell vents
• Do not dismantle
35 - Lever
• Not to be removed risk of interchange
• Heed assignment (code number "840")
36 - Cam disk
• Mark before removing risk of interchange
• Heed assignment (code number "156")
37 - Bracket
• Mark before removing risk of interchange
• Heed assignment (no code number)
38 - Right Footwell Door Motor (V109) 2)
• With Right Center Vent Motor Position Sensor (G140)
• Removing and installing, refer to => [ Right Footwell Door ]
39 - Right Rear Air Outlet Motor (V219)
• With Right Center Vent Motor Position Sensor (G350)
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
• Removing and installing, refer to => [ Left/Right Rear Air Outlet ]
40 - Left Rear Air Outlet Motor (V218)
• With Right Center Vent Motor Position Sensor (G349)
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
• Removing and installing, refer to=> [ Left/Right Rear Air Outlet ]
41 - Bracket
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
42 - Cam disk to Right Rear Air Outlet Motor (V219)
• Mark before removing risk of interchange
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
• Heed assignment (code number "158")
43 - Lever (to Right Rear Air Outlet Motor (V219))
• Not to be removed risk of interchange
• To warm-air door
• Heed assignment (code number "845")
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
44 - Lever (to Right Rear Air Outlet Motor (V219))
• Not to be removed risk of interchange
• To cold-air door
• Heed assignment (code number "844")
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
45 - Lever (to Left Rear Air Outlet Motor (V218))
• Not to be removed risk of interchange
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).
• Heed assignment (code number "863")
46 - Cam disk (to Left Rear Air Outlet Motor (V218))
• Mark before removing risk of interchange
• Heed assignment (code number "159")
• installed only on vehicles with Rear A/C Control Head (Climatronic) (E265).