Body - Rattling Noise From The Sunroof Area
60 08 202013934/3
December 1, 2008.
Supersedes Technical Service Bulletin Group 60 number 07-18 dated December 17, 2007 for reasons listed below.
60 Rattle noise from roof area with roof panel closed
Condition
Customer hears rattling noise from the sliding roof area.
Technical Background
While driving with the sliding roof panel closed, the wind deflector may vibrate against the sunroof frame.
Production Solution
Continuous improvement at the supplier.
Service
1. Stick a self-adhesive foam strip (701 867 225 D) in the middle area of the sunroof frame.
Figure 1:
2. Open sunroof cover. Inside the deflector on the center of the sunroof frame are two raised dimples (Figure 1).
Figure 2:
3. Apply the foam strip such that the area indicated in the yellow rectangle (Figure 2) is covered.
The approximate length of the foam strip will be 7 cm long.
4. Thoroughly test drive the vehicle with the customer to ensure the noise concern is addressed to their satisfaction.
Warranty
When procedure applies to vehicles under warranty, use the following:
WIN
SAGA
Required Parts and Tools
Additional Information
All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information.