Operation CHARM: Car repair manuals for everyone.

Bolted Windows






Bolted Windows

=> [ Front Door Window ]

=> [ Rear Door Window ]

Front Door Window

Window Frame Installed

- Door trim removed.

- Drive down window with approximately 10 cm in distance - a -.





- Remove the window regulator motor.

- Remove plastic covers - 2 - from assembly carrier - 1 -.





- Remove bolts - 4 -.





- Slide driver - 3 - of window regulator downward by hand.

For alternative operation of window regulator, the manual window regulator drives (left or right side) of rear doors of Audi A4 from 2001 with window crank may also be used.

These drives fit onto threaded pins of window regulator.

- Slide down front section of door window as shown.





- Pull window trim diagonally upward out of window frame.

- To install, perform the steps used in removal in reverse order.

Assembly Carrier Cover





- When removing assembly carrier - 2 - or door window, cover - 1 - must be pulled out.

Front Driver





- When removing door window or assembly carrier - 1 -, remove mount - 2 - of door window driver - 3 -.

- Tighten bolt - 4 - to 4 Nm when installing.

- When installing, make sure window mount - 2 - lies on upper edge of drive - 3 -.

Rear Driver





- When removing door window or assembly carrier - 1 -, unscrew mount - 2 - of door window driver - 3 -.

- Tighten bolt - 4 - to 4 Nm when installing.

- When installing, make sure window mount - 2 - lies on upper edge of drive - 3 -.

Window Frame Installed

With window frame removed, proceed as described in the following

- Slide door window into guides on window frame from bottom to top.





- Secure window at a distance of approximately 10 cm from top of window frame - 1 - with adhesive tape - 2 - as shown.





When inserting window frame, window recess seal must not be pinched.

- Insert window frame with door window into door from above.





- Loosely screw in Bolt - 2 - first.

- Window frame height is already adjusted by Bolts - 2 -.

- Loosely thread in the remaining bolts as well.

Follow bolt tightening sequence

- Tighten bolts - 2 - to 32 Nm first at front, then at rear.





- Then tighten bolts - 3 - to 32 Nm first at front, then at rear.

- Finally, tighten bolts - 4 - to 10 Nm from front toward rear.

Rear Door Window

- Door trim removed.

- Drive down window to distance - a - is approximately 10 cm and secure against falling off with adhesive tape.





- Remove window regulator motor.

- Remove plastic covers - 2 - from assembly carrier - 1 -.





- Remove bolts - 4 -.





- Remove window regulator motor.

- Slide driver - 3 - of window regulator downward by hand.

- Disconnect all electrical harness connectors.

- Remove assembly carrier. Refer to => [ Rear Door Assembly Carrier ] Rear Door Assembly Carrier.

- Remove window frame. Refer to => [ Rear Door Window Frame and Window Regulator ] Rear Door Window Frame and Window Regulator.

- Pull door window downward out of guides.

- To install, perform the steps used in removal in reverse order.

Window Regulator Motor, Removing

- Door trim removed.

The power window motor can be removed or installed with the motor or side window in any position.

Before removing motor, disconnect electrical harness connectors.

- Remove bolts - 2 - (T30) and remove motor.





Installation

- When installing, make sure that threaded pins - arrows - are engaged in inner door plate.

- Slide on window regulator motor - 3 - and secure with bolts - 2 -.

- Tightening specification 3.5 Nm

Only switch ignition on and off after installing motor and connecting wires.

Then move door window upward to stop and keep pressing switch for window regulator for approximately 2 seconds longer.

This position is the base position and the high- and low-running function is activated.