Operation CHARM: Car repair manuals for everyone.

2.0L BPY







Component Locations: Engine Management System

2.0L BPY


Components A - I are not shown in the overview





A - Mass Air Flow (MAF) Sensor -G70- => [ Mass Air Flow (MAF) Sensor ] See Image Below.
Located in upper section of the air filter

B - Brake Light Switch -F- and Brake Pedal Switch -F63-
Located at the brake pedal assembly

C - Clutch Position Sensor -G476- => [ Clutch Position Sensor ] See Image Below.
Only for vehicles with manual transmission

D - Fuel Injectors => [ Fuel Rail Assembly Overview ] See Image Below.

E - Knock Sensor 1 -G61- => [ Component locations beneath intake manifold ] See Image Below.
3 pin harness connector for knock sensor (KS) 1-G61- => [ Component locations and electrical harness connectors ] See Image Below.

F - Knock Sensor 2 -G66- => [ Component locations beneath intake manifold ] See Image Below.
3 pin harness connector for knock sensor (KS) 2 -G66- => [ Component locations beneath intake manifold ] See Image Below.

G - Oil Pressure Switch -F1- => [ Component locations and electrical harness connectors ] See Image Below.

H - Oil Level Thermal Sensor -G266- => [ Oil Pan Assembly Overview ] See Image Below.
Located at the bottom of oil pan

I - Leak Detection Pump (LDP) -V144- => [ EVAP Canister System/Leak Detection System ] See Image Below.
Located under the wheel housing liner in right rear wheel housing

1 - Wastegate Bypass Regulator Valve -N75- => [ Turbo Charger Components ] See Image Below.
Installed directly on turbocharger

2 - Turbocharger Recirculating Valve -N249- => [ Turbo Charger Components ] See Image Below.
Installed directly on turbocharger

3 - Engine Control Module (ECM) -J623-

2.0L BPY continued





4 - Ignition Coils with power output stages => [ Ignition Coils ] See Image Below.

5 - Heated Oxygen Sensor (HO2S) -G39- => [ Exhaust System ] Locations

6 - Low Fuel Pressure Sensor -G410- => [ Fuel Rail Assembly Overview ] See Image Below.

7 - Fuel Pressure Regulator Valve -N276- => [ Fuel Rail Assembly Overview ] See Image Below.

8 - Camshaft Adjustment Valve 1 -N205- => [ Cylinder Head Assembly Overview ] See Image Below.

9 - Engine Coolant Temperature (ECT) Sensor -G62- => [ Engine Coolant Temperature (ECT) Sensor ] See Image Below.

10 - 6-pin Harness Connector
For Heated Oxygen Sensor (HO2S) -G39- and Oxygen Sensor (O2S) Heater -Z19- (black)

11 - Single piston high pressure pump => [ Fuel Rail Assembly Overview ] See Image Below.

13 - Intake Flap Motor -V157- with Intake Manifold Runner Position Sensor -G336- => [ Intake Manifold Assembly Overview ] See Image Below.

14 - Evaporative Emission (EVAP) Canister Purge Regulator Valve 1 -N80- => [ Fuel Rail Assembly Overview ] See Image Below.

15 - Connector => [ Component locations beneath intake manifold ] See Image Below.
For Camshaft Position (CMP) Sensor -G40- and Fuel Pressure Sensor -G247-

16 - Charge Air Pressure Sensor -G31- => [ Charge Air Pressure Sensor ] See Image Below.

17 - Engine Speed (RPM) Sensor -G28- => [ Component locations and electrical harness connectors ] See Image Below.

18 - 8-pin harness connector for fuel injectors => [ Component locations beneath intake manifold ] See Image Below.

19 - Throttle Valve Control Module -J338- => [ Intake Manifold Assembly Overview ] See Image Below.
Integrated with Throttle Drive (for Electronic Power Control (EPC)) -G186- , Throttle Drive Angle Sensor 1 (for Electronic Power Control (EPC) -G187- and Throttle Drive Angle Sensor 2 (for Electronic Power Control (EPC) -G188-

20 - Intake Air Temperature (IAT) Sensor -G42- => [ Intake Manifold Assembly Overview ] See Image Below.

21 - Fuel Pressure Sensor -G247- => [ Fuel Rail Assembly Overview ] See Image Below.

22 - Camshaft Position (CMP) Sensor -G40- => [ Cylinder Head Assembly Overview ] See Image Below.


Turbo Charger Components






1 - Turbocharger
2 - Wastegate Bypass Regulator Valve -N75-
3 - Turbocharger Recirculating Valve -N249-

Ignition Coils






- - Ignition Coils with power output stages
Ignition Coil 1 with Power Output Stage -N70-

Ignition Coil 2 with Power Output Stage -N127-

Ignition Coil 3 with Power Output Stage -N291-

Ignition Coil 4 with Power Output Stage -N292-


Fuel Rail Assembly Overview






2 - Fuel Injector
Cylinder 1 Fuel Injector -N30-

Cylinder 2 Fuel Injector -N31-

Cylinder 3 Fuel Injector -N32-

Cylinder 4 Fuel Injector -N33-

4 - Fuel Rail
5 - Fuel Pressure Sensor -G247-
6 - Low Fuel Pressure Sensor -G410-
7 - Fuel Pressure Regulator Valve -N276-
8 - Mechanical single-piston high-pressure pump
- With Fuel Pressure Regulator Valve -N276- and Low Fuel Pressure Sensor -G410-
9 - Evaporative Emission (EVAP) Canister Purge Regulator Valve 1 -N80-
10 - Throttle Valve Control Module -J338- with Throttle Drive (for Electronic Power Control (EPC)) -G186- , Throttle Drive Angle Sensor 1 (for Electronic Power Control (EPC) -G187- and Throttle Drive Angle Sensor 2 (for Electronic Power Control (EPC) -G188-
11 - Intake Air Temperature (IAT) Sensor -G42-
13 - Intake manifold

Cylinder Head Assembly Overview






11 - Camshaft Adjustment Valve 1 -N205-
25 - Camshaft Position (CMP) Sensor -G40-

Engine Coolant Temperature (ECT)
Sensor







1 - Engine Coolant Temperature (ECT) Sensor -G62-

Intake Manifold Assembly Overview






2 - Intake Air Temperature (IAT) Sensor -G42-
3 - Intake manifold
4 - Evaporative Emission (EVAP) Canister Purge Regulator Valve 1 -N80-
6 - Fuel Pressure Regulator Valve -N276-
7 - Mechanical single-piston high-pressure pump
- With Fuel Pressure Regulator Valve -N276- and Low Fuel Pressure Sensor -G410-
10 - Intake Flap Motor -V157- with Intake Manifold Runner Position Sensor -G336-
14 - Throttle Valve Control Module -J338- with Throttle Drive (for Electronic Power Control (EPC)) -G186- , Throttle Drive Angle Sensor 1 (for Electronic Power Control (EPC) -G187- and Throttle Drive Angle Sensor 2 (for Electronic Power Control (EPC) -G188-
19 - Fuel Pressure Sensor -G247-

Component locations beneath intake
manifold







1 - Knock Sensor 1 -G61-
2 - Knock Sensor 2 -G66-
3 - Oil Pressure Sensor -G10-
4 - 3-pin harness connector (brown) for Knock Sensor (KS) 2 -G66-
5 - 3-pin connector (gray) for Engine Speed (RPM) Sensor -G28-
6 - Electrical connector for Camshaft Position (CMP) Sensor -G40- and Fuel Pressure Sensor -G247-
7 - 8-pin harness connector for fuel injectors

Charge Air Pressure Sensor






1 - Charge Air Pressure Sensor -G31-

Component locations and electrical
harness connectors







1 - 3-pin harness connector (green) for Knock Sensor (KS) 1 -G61-
2 - 3-pin harness connector (brown) for Knock Sensor (KS) 2 -G66-
3 - Oil Pressure Switch -F1-
4 - Engine Speed (RPM) Sensor -G28-
5 - 3-pin connector (gray) for Engine Speed (RPM) Sensor -G28-

Mass Air Flow (MAF) Sensor






1 - Mass Air Flow (MAF) Sensor -G70-

Clutch Position Sensor






4 - Clutch Position Sensor -G476- connector

Oil Pan Assembly Overview






16 - Oil Level Thermal Sensor -G266-

EVAP Canister System/Leak Detection
System







4 - EVAP canister
14 - Leak Detection Pump (LDP) -V144-