Body - Sunroof Wind Noise/Operating Noises
60 08 282018898/2
December 1, 2008.
Supersedes Technical Service Bulletin Group 60 number 08-07 dated October 13, 2008 for reasons listed below.
61 Panorama sunroof noisy
Condition
Wind noises from the sunroof or noises when opening or closing panorama sunroof.
Technical Background
Adjustment of sunroof cover may be necessary. The following detailed adjustment instructions are in addition to the repair manual.
Production Solution
Changed production process to ensure correct adjustment.
Service
1. Clear the sunroof area of any debris before opening or adjusting panels. This will prevent any debris from falling onto the rails.
Figure 1:
2. Measure the dimensions at several points on each of the three sunroof panels (front panel, middle panel, and rear panel).
Adjust the panels if necessary.
The gaps, labeled in Figure 1, should measure as listed below (in mm):
A = -1.2 ± 0.5
B = 0 ± 0.5
C = -0.6 ± 0.5
D = 0.4 ± 0.5
E = 10
F = 1.5
G = 1.5
H = 11
Figure 2:
The gap labeled A in Figure 2 should measure 11 mm.
Warranty
When procedure applies to vehicles under warranty, use the following:
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures Manual. Claims are subject to review or audit by Audi Warranty.
Additional Information
All parts and service references provided in this TSB are subject to change and/or removal. Always check with your Parts Department and service manuals for the latest information.