Recall - Distributor Rotor Replacement
89bmw02GROUP 11 Engine
Bulletin Number 11 01 89 (1794) Page 1 of 4
Woodcliff Lake, NJ March 1989 Technical Dept.
SUBJECT: Voluntary Exhaust Emissions Recall Campaign No. 89E-A02
MODELS: 1988/1989 750iL (Produced 9/87 thru 9/88)
BMW of North America, Inc. will initiate a voluntary emission-related recall campaign to correct vehicles that may be in non-compliance with Federal and California Emissions Standards.
The campaign consists of the installation of a new set of improved distributor rotor adaptors.
This Service Information Bulletin outlines specifics for implementation of this campaign. A copy of the customer letter is attached for your information.
Vehicles Affected:
Model Chassis No. Range
750iL 276 5001 276 9116
Parts Required:
Description Part Number Quantity
Rotor adaptor 11 31 1 718 733 2
Adaptor bolt 07 11 9 919 735 2
Note:
The above parts are contained in the 750iL Service Action Update Kit under P/N 12 51 9 061 688.
Corrective Procedure:
Inspect the underhood area for the emissions recall label No. 89E-A02 as shown on page 2. If this label is present, do not proceed further.
If not present, proceed as follows:
1) Remove both ignition distributor caps and rotors (Refer to Group 12, E32 Repair Manual).
2) Remove both rotor adaptors by removing adaptor M8 x 25 retaining bolts using Special Tool P/N 88 88 6 002 180.
Caution: Failure to use the above special Hex Tool may result in "stripping" the adaptor bolt.
3) Install improved rotor adaptors on camshaft noting the engagement of the locating dowel pin.
4) Install new M8 x 25 adaptor bolts and tighten with special Hex Tool.
Tightening Torque: 24 N-m/17 ft.lbs.
5) Reinstall distributor rotors.
Tightening torque: 6 N-m/4 ft.lbs.
6) Reinstall distributor caps and hoods.
7) With a ball point pen print your dealer code (5 digits) on the Recall Completion Label (see Illustration). Peel label from its backing and affix it to the right inner fender vertical panel.
Note: Emission Recall Labels (SD 89-02) will be sent to each dealer under separate cover. Additional labels may be obtained from your Regional Technical Manager.
Warranty Status:
Dealers will be reimbursed for this recall through Warranty Claim Entry.
Special defect code: 00 11 01 01 00
Labor operation: 00 50 765
Labor allowance: 7 FRU
March 1989
Dear BMW Owner:
BMW has determined that your 1988/1989 BMW 750iL may, under some circumstances, be releasing air pollutants that exceed Federal and California emission standards and is in need of corrective action. Therefore, BMW has initiated two voluntary exhaust emissions recall campaigns, numbers 89E-A01 and 89E-A02.
These corrective measures consist of modifications to the ignition and fuel management system and replacement of the distributor rotor adapters. Your authorized BMW dealer will determine whether one or both modifications apply to your vehicle
These modifications require approximately 4 hours and will be performed at no charge to you. These measures will assure your car maintains its low emissions and durability.
In case this free repair is not performed, your vehicle may fail the inspection and maintenance (smog check) as required in your state.
We are sorry to inconvenience you, but we are sure you join with us in our desire to reduce air pollution. We ask that you contact an Authorized BMW Dealer as soon as possible for an appointment to have these free services performed.
If you are no longer the owner of this vehicle, we would appreciate your furnishing us with the name and address of the new owner, using the enclosed return postagepaid card.
We appreciate your confidence in our product and wish to do everything we can to retain that confidence. Should you have any questions about this installation that cannot be answered by your Authorized BMW Dealer, please contact one of our Regional Consumer Services Departments at:
BMW OF NORTH AMERICA, INC. BMW OF NORTH AMERICA, INC.
BMW Plaza 12541 Beatrice Street
Montvale, NJ 07645 Los Angeles, CA 90066
Telephone: (201) 573-2100 Telephone: (213) 305-2913
BMW OF NORTH AMERICA, INC. BMW OF NORTH AMERICA, INC.
1002 E. Algonquin Road 1730 Briercroft Court
Schaumburg, IL 60195 Carrollton, TX 75006
Telephone: (312) 397-5713 Telephone: (214) 323-7700
BMW OF NORTH AMERICA, INC. BMW OF NORTH AMERICA, INC.
1280 Hightower Trail 6606 Owens Drive
Dunwoody, GA 30350 Pleasanton, CA 94566
Telephone: (404) 552-3800 Telephone: (415) 463-0690
BMW OF NORTH AMERICA, INC.
21545 Ridge Top Circle
Sterling, VA 22170
Telephone: (703) 450-7600