Replacing Front Sunroof Lid

Switch off ignition.

Remove front sun roof frame - refer to Sunroof/Moonroof Interior Trim Panel.

Remove front sun roof lid - refer Removing and Installing Sun Roof Lid.

(Remove front rain channel, not installed.)

Installation





Note: A "V" is stamped in the face of the front lid, which has seal (1) at the rear.





Clean the cement surface and cement insulation sheet (1). Refer to Replacing Cemented Seals for information about repairing cemented seals on the dual lid sun roof.





Clean the cement surface.

A: Cement seal (1) level to the lid's upper edge (2).

B: Seal (1) must slightly protrude on lid (2) at left outside and right top.









1. Sun roof cassette without embossments (1...4) on cross members and welded nuts (5 and 6) on both lids:

- Install four shaped washers on cross members.

a) Sun roof cassette without embossments (1...4) on cross members and welded studs (5 and 6) on both lids:

- Cannot be installed. Exchange the cassette.









2. Sun roof cassette with embossments (1...4) on cross members and one welded stud on rear lid (5) through cross member (4):

- Install three washers (1...3) cemented, cement one pot washer (7) on cross member (4). Install M 6 nut for welded stud (5) with Loctite No.270*.

a) Sun roof cassette with embossments (1...4) on cross members and welded nuts (5 and 6) on both lids:

- Remove old washers (cemented) and use four shaped washers (7) on cross members.

Install front sun roof lid and front sun roof frame.

Adjust front sun roof lid - refer to Front Lid Adjustment.