Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Electrical - 90AH Absorbed Glass Matt Battery Replacement
- A/T - ZF A/T Oil Leaks, Diagnosis, and Repair Information
- Wipers/Washers - Windshield Washer Malfunctions
- Audio/Battery - Failures Caused By Aftermarket USB Cable
- Electrical System - Parasitic Draw Measurement
- Engine - Head Bolt Threads Pull Out of Engine Block
- M/T - Repairs To Clutch Pedal Assembly
- Instruments - Maximum Permissible Speedometer Deviations
- Electrical - Updated Battery Registration Procedure
- Engine - CPO Engine Inspection Information
- Computers, Controls - Programming VS Veh. Data Status
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Engine - E Series Engine Oil Capacities
- Body - Windshield Urethane Sealant Information
- A/T - Failures Due To Incorrect Installation
- Engine - Removal/Installation Tips
- Instruments - Odometer Reading Can't Be Recovered
- Body - Test Plans For Panoramic Roof
- Emissions System - Evaporative System Leak Testing
- SRS - Warning Light ON/Multiple Fault Codes Set
- Compuetrs/Controls - Recommended Diagnostic Procedures
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Alcohol Fuel Blend Usage
- Computers - ISTA Diagnosis On Vehicles Prior To E46
- Cooling System - Information on Coolant Refilling
- Fuel System - High Alcohol Fuel Detection
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- Engine - Crankshaft Seal/Bedplate Sealing Information
- Automatic Headlamps - Operating Characteristics
- New Self Adjusting Clutch Clamping Fixture
- Service Action/Recall Campaign 181- 200 - Labels
- Label for Service Action or Recall Campaign (#201-220)
- Tools - New Special Tool CD
- Campaign/Recall - Codes Index
- MoDic III(R) - System Description/Operation
- MoDic III(R) - Questions and Answers
- New Model General Information
- New Systems Overview
- Updated MoDic(R) Software - ZCS Coding
- TIS Software Update - 07/97
- TIS - Software Update
- Microfiche Update - All Models
- Flat Rate Manual - 8th Edition
- Certified Pre-Owned BMW Vehicle Program
- Service/Warranty - Information Statement
- New Environmentally Safe Parts Washer
- TIS - Software Updated
- Engine Repair Manual - Microfiche Update
- Technical Data - Updated Microfiche
- Warranty Defect Code Microfiche - Revision
- Microfiche - Service Information Bulletins List
- TIS Software Update
- DIS Maintenance and Operation
- Modified Vehicles - Warranty Exclusion
- Diagnostic Time - Warranty Reimbursement
- Control Modules - Coding Not Possible After Replacement
- Special Tools - E36 Compact
- Service Information - Updated TIS Software
- Repair Manual - Microfiche Update
- Tools - Infrared Transmission Device (IR)
- Dealer Communications System - Enhancements
- Service Information - Microfiche/Diskette Bulletins
- New Special Tool For Recall 94V-151
- Service Manual - Updated CD for TIS
- A/C Systems - New HFC-134A Description
- A/C - Oil Charge Procedure for R12 and R134a
- AIr Distribution Knob - Creaking or Scrapping Noises
- A/C System - Warranty Claim Noise Questionnaire
- A/C - Integrated Regulation
- A/C System - Musty Odors
- Instruments - Impaired Diagnostics/Implausible Faults
- A/C - Temperature Control Function Change
- A/C - Fault Codes 34/61 Mixing Control Wheel Mixing Flap
- A/C - Musty Odors From Heater and A/C Systems
- Campaign - Standardization of Equipment Levels
- P/S - Identification and Diagnosis
- TIS - Software Update 12/96
- Updated MoDic(R) Software - P9.0 Programming
- Updated MoDic(R) Software - C9.0 ZCS Coding
- Engine - M42 production Changes
- Special Tools - New Torque Angle Indicator
- Engine - High Pressure Steam Cleaning Warning
- New BMW Special Tools.
- Ignition - Spark Plug Application Chart
- Spark Plug/Engine Oil Capacity Reference Chart
- A/C Compressors, R-12 - Spare Parts Discontinued
- A/C - Reduced Air Output or White Mist
- Steering Gear/Rack - Warranty Return Policy Information
- Steering Gear - Replacement Due to Accident Damage
- Special Tools - Engine Valve Guide Reamer Set
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- Campaign - Radiator Leak
- A/C - Replacement of Receiver Dryers: R12/R134a
- A/C - Blows Hot
- Suspension - Replacement of Shock Absorbers
- Wheels/Tires - New Wheel Weight Tools
- Wheels - Approved Wheels and Tires
- Winter Tires - Recommendations Brochure
- Winter Tire - Recommendations Brochure
- Tires - Application Chart
- Tires - Nitrogen Usage Recommendations
- Tools - New Frame Anchoring Adapters (Celette)
- Body Lifting Pads - Wind Noise
- Door Lock Plate Cover - Removal Tool
- Sunroof Cassette - Installation Instructions
- Sunroof Lid - Revised Mounting Method
- Recall - Occupant Crash Protection
- Tools - New Special Tools
- SRS - Collision Repair Guidelines
- Special Tool - Clutch Disc Wear Gauge
- Rear Axle - List of Ratios Updated
- A/T - Fault 111 (Component Slippage/Speed Monitoring)
- EWS II and DME Control Module - Alignment Not Possible
- ECM - Reprogramming W/P16.0 Version Software
- Engine Controls - Hard Start Hot, Start-Stall, Code 41
- ECM - EPROM Replacement/Application Chart
- Engine Controls - Acceleration Jolt in 2nd and 3rd Gear
- EPROM - Replacement/Application Chart Order Form
- Special Tools - Simulator Tool For Bosch Oxygen Sensors
- Campaign - O2 Sensor Harness Modification
- ABS/ASC - Warning Lights On During Dynamometer Test
- ABS System - MIL ON DTC 145 Set
- Battery - Maintenance System
- Illuminated Key - EWS ll Equipped Vehicles
- Starting - Ignition Key Cutting Services Caution
- Recall - Fuel Feed Hose Hardens/Leaks
- Recall - Throttle Body Freezing
- Recall - Cruise Control/Throttle Cable Breakage
- A/T - Erroneous Fault Code 40, Pressure Regulator
- A/T - EGS/AGS Control Module EPROM Replacement
- A/T - Shudders From Stop/Vibration
- Central Locking System - Multiple Malfunctions
- Driveaway Protection Modules - Coding After Replacing
- Alarm System - False Alarms Due To Glass Breakage Sensor
- EWS II Control Modules - Coding of Replacement
- CD43DIN/C43DIN Radio - Security Code Information
- Portable Telephone - Special Tool
- Cellular Phone - CMT 2000VR Number Memory
- Cellular Phone Antenna - Installation
- Phone Tray - Availability of New Style
- Motorola Mobile Phones - Replacement Parts
- Safety Belts - Child Restraint Feature
- SRS - Warning Lamp ON For 2 Minutes After Startup
- Restraint System - Transportation of Infants/Children
- Tools - Air Bag Triggering Adapter Cable
- SRS - Warning Lamp ON/Fault Code 1 Set
- SRS Control Module (ZAE II) - Coding
- Instruments - New Fuel Level Sensor Testing Caution
- Fuel Gauge - Incorrect Reading
- Speedometer - Maximum Permissible Error
- Check Control - 'Brake Light Circuit' Message Erroneous
- Valve Cover Gasket - New Design
- Brakes - ABS Warning Light Glows
- Starting - Ignition Lock Spins Freely
- Ignition Lock - Sticks
- Recall 95V071000: Vehicle Load Capacity Overstated
- Body - Structural Adhesives
- Aluminum Components - Painting Procedure
- Body - Structural Repair Requirements
- ZAE Airbag Systems - Servicing
- Recall - Restraint System Labels/Warnings
- Airbag Systems - Wiring Repair Procedure
- Electronic Immobilization System - Description/Operation
- Electronic Immobilization System - Parts Information
- Electronic Immobilizer (EWS ll) - Malfunctions
- Central Locking System - FC 5 and 13
- Service Information Ruling for OBD
- New Special Tool - MoDic(R) Replacement Cable
- Updated MoDic(R) Software - P8.0 Programming
- Undefined MoDic(R) Software
- Special Tools - Breakout Box Adapter Lead
- Special Tools - Electrical Connector Release Tools
- ELO Diagnostic Cable - New Special Tool
- Updated MoDic(R) Software - P11.0 Programming
- Updated MoDic(R) Diagnostic Software - D12.0
- Computers/Controls - Custom Configuration
- Central Locking System - Locks by Itself
- Trunk Lock Actuator - Linkage Comes Loose
- Audio - Faulty Gong Causes Sound Like Alternator Noise
- Windshield - Bonding Adhesive Cutter
- Windshield - Replacement Tools
- Engine - Will Not Start In Cold Weather
- Recall - Radiator Cap Replacement
- Warranty - Technical Liaison for ZF Products
- A/T - Gasket/Plug Leaks
- A/T - Pendulum Shifts, Delay Gear Engagement, Case Leak
- A/T - Does Not Upshift When Cold
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Difficult to Shift, Diagnostic Tips
- M/T - Jumps Out of 1st and 2nd Gear Under Load
- CD Player Malfunctions - Skips on Rough Road Surface
- A/C - Compressor Noise
- Recall - Airbag Contact Ring
- Instrument Cluster - Transfer of Odometer Reading
- Instrument Clusters - Transferring Odometer readings
- Instrument Cluster Software - Revision
- Instrument Cluster - Revised Design
- IC Conversion - Km/h to Mph or Mph to Km/h
- MoDiC(R) - Diagnostic Software Update
- MoDic(R) - Software Update V12.0
- DIS Schematic Information
- Updated MoDic(R) Software - C11.0 ZCS Coding
- DIS tester Software - Update
- MoDic(R) - Updated Software V5.1
- MoDic - Software Errors Coding Version 12.0
- Engine Oil Capacities - All Current Models
- Electrical Connnectors - Stabilant 22A Contact Enhancer
- ETM Manual Supplement
- Electrical Troubleshooting Manual - Supplement #2
- Electrical Trouble Shooting Manual - Additions
- Electrical Trouble Shooting Manuals - Available on CD
- Electrical Troubleshooting Manual - Preliminary Edition
- Electrical Repair Kit IV - Additional Connectors
- Electrical Connector Kit Supplement
- Electrical Connector Kit 4 - Supplement
- Electrical Connector Kit - Repair Listing
- Wheel - Size/Configuration
- Turn Signal/Hazard Flasher System - Erratic Operation
- Windows/Glass - New Adhesive Kit
- Paint - Approved Materials
- Paint and Paint Repairs - Warranty Coverage
- Electrical - 2 and 3 Pin Plug Connector Seal Information
- SRS - MIL ON, Codes 16/17 or 24/25 Set
- Differential - Final Drive Synthetic Oils
- Engine Control - BC V Fault Codes 6 and 15
- Dash - Warping Above Center Vent
- Dash - Warped Above Center Vent
- Sun Visor - Pops Out of Retaining Clip
- General Module - Sporadic Accessory/Lighting Operation
- A/T - A4S270/310R (GM4), Piston Cover Fluid Leaks
- Safety Belt Pretensioner Arming Cable - New Style
- New BMW Special Tools..
- Alpine Alarm System - Siren Inoperative
- Central Locking System - General Information
- Audio - 6-Disc Alpine CD Changer Troubleshooting Guide
- CD Player - Operational Whining Noise
- Airbags - Deactivation
- Child Seat Tether Anchor - Installation
- Cellular Phone - Cannot Be Programmed
- A/T, M/T - Repair Precautions to Prevent Damage
- Fuel System - Damage Caused By Fuel Contaminants
- A/C Replacement Compressor Information Insert
- SRS - Air Bag Lamp ON/Multiple Fault Codes Set
- Audio System - Erratic/Inoperative CD Player
- Instruments - Clock Symbol Displayed On Cluster
- Battery - Charging Voltage Change
- Battery - Discharges With Key Left In Ignition Switch
- Restraints - Passenger Air Bag Status Lamp Information
- Body - Glass Repair Recommendations/Service Kit
- Electrical - Wiring Harness Repair Information
- Fuel System - TOP TIER Gasoline Usage Recommendations
- Fuel System - Fuel Quality and Additive Information
- Antitheft System - EWS Coding and Alignment
- Emissions - Evaporative Emissions System Testing
- Body/Frame - Structural Repair Requirements
- Antitheft System - Alarm Triggers Unexpectedly
- Drivetrain - Differential Cover Sealant
- Progman(R) - Programming/Coding/Individualization
- Audio System - Retrieving Radio Security Codes
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Steering/Suspension - Wheel Alignment Information
- Suspension - Rear Coil Spring Replacement Precautions
- A/C - Control Assembly Damage Information
- Body - Windshield Damage Analysis
- Electrical - Battery Charging And Testing Procedure
- Brakes - Brake Rotor Removal Procedures/Precautions
- Computers/Controls - ISTA/D DTC S0001 After Quick Delete
- Lighting - Headlamp Condensation Diagnosis
- Computers/Controls - ISTA Test Plan Priority Error Info.
- Cooling System - Proper Cooling System Service Procedure
- A/C - Compressor Noise Troubleshooting
- Computers/Control - Loading/Activation Of Enabling Codes
- A/C - Revised Refrigerant/Compressor Oil Reuse Statement
- Cell Phone - Bluetooth Compatibility Information
- Restraint System - Passenger Airbag Status Lamp Info.
- Fuel System - BMW Group Fuel System Cleaner Plus Info.
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Interior - Proper Installation Of Carpet Floor Mats
- Wheel/Tires - New Style Tire Valves
- M/T - Dual Mass Flywheel Diagnostic Criteria
- Computer/Controls - Replacement DME Programming
- Electrical - Battery Maintenance Requirement Information
- Audio System - Interference Noise From Speakers
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Wipers/Washers - Maintenance Program Wiper Inserts