Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Wipers/Washers - Windshield Washer Malfunctions
- Engine - Head Bolt Threads Pull Out of Engine Block
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- A/C System - Musty Odors
- A/C - Loss of Recirculation Control Settings
- A/C - Musty Odors From Heater and A/C Systems
- ECM - EPROM Programming Update/Very Rough Idle
- Check Control - Trans Program Message Displayed
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- ECM - EPROM Programming Updated
- Seat Backrest Pivot - Excessive Movement and Noise
- DME - MIL ON/DTC's 201/203/Driveability Concerns
- Oxygen Sensor - Replacement
- Instrument Cluster/EKM - Coding Problems
- Check Control Message - Brake Lights
- Secondary Air System - One Way Valve May Not Seal
- A/T - EGS Transmission Control Module EPROM
- Antitheft System - Sporadic False Alarms
- Central Locking System - Multiple Malfunctions
- SRS - Warning Lamp ON For 2 Minutes After Startup
- SRS - Warning Lamp ON/Fault Code 1 Set
- Engine - Irregular Clicking Noise
- Oil Pressure Warning Light - Comes ON
- Engine - Upper Timing Case Cover Oil Leaks
- Lights - 10-Watt Rear Bulb Failure
- Trunk Lock Actuator - Linkage Comes Loose
- A/T - Harsh Shifts Eased by New Control Module EPROM
- A/T - Pendulum Shifts, Delay Gear Engagement, Case Leak
- M/T - 3rd/4th Gear Difficult to Disengage/Engage
- CD Player Malfunctions - Skips on Rough Road Surface
- Instruments - Oil Level Sensor Updated
- Turn Signal/Hazard Flasher System - Erratic Operation
- SRS - Warning Lamp ON/Code 25 Set
- Fuel System - Damage Caused By Fuel Contaminants
- Audio System - Erratic/Inoperative CD Player
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Wipers/Washers - Maintenance Program Wiper Inserts
- Seals, Gaskets
- Superceded Bulletins
- 010498 - 06/01/98
- 540111 - 02/01/11
- 652403 - 11/01/09
- 410104 - 04/01/05
- 642105 - 12/01/05
- 610788 - 12/01/05
- 640402 - 12/01/02
- 111190 - 10/01/03
- 610800 - 06/01/04
- IDC1011 - 02/01/95
- IDC1010 - 02/01/95
- IDC025957 - 03/01/95
- IDC002 - 10/01/94
- 640993 - 10/01/93
- 6404954324 - 12/01/95
- 540197 - 01/01/97
- 5108944129 - 03/01/94
- 640403 - 12/01/03
- 3301923667 - 09/01/93
- 240398 - 08/01/98
- 240198 - 10/01/98
- 2401933748 - 03/01/93
- 240193 - 08/01/97
- 122299 - 09/01/99
- 1209944132 - 03/01/95
- 1203851085 - 11/01/94
- 1113954319 - 11/01/95
- 1112954307 - 11/01/95
- 1111903149 - 11/01/94
- 1108944139 - 01/01/95
- 110697 - 08/01/97
- 110297 - 03/01/97
- 100396 - 07/01/96
- 100396 - 12/01/96
- 100396 - 05/01/97
- 100396 - 07/01/97
- 100296 - 01/01/96
- 080496 - 06/01/96
- 080496 - 01/01/97
- 080496 - 07/01/97
- 080396 - 06/01/97
- 080396 - 09/01/97
- 080296 - 02/01/96
- 080198 - 04/01/98
- 080196 - 01/01/96
- 070296 - 06/01/96
- 070296 - 01/01/97
- 070296 - 05/01/98
- 070296 - 05/01/99
- 070296 - 12/01/99
- 070196 - 02/01/96
- 0202954164 - 02/01/95
- 010396 - 10/01/96
- 010290 - 02/01/95
- 010290 - 02/01/96
- 0101943986 - 04/01/94
- 0040891999 - 02/01/95
- 0040891999 - 02/01/96
- 004089 - 05/01/96
- 004089 - 07/01/96
- 0026903100 - 01/01/95
- 0026903100 - 11/01/95
- 002292 - 03/01/99
- 001396 - 05/01/97
- 000194 - 11/01/99
- Updated DIS Software CD 21
- Updated DIS Software CD 14.0
- Service/Warranty - Information Statement Version 2
- Service and Warranty Information Statement
- Repair Manuals - Updated Microfiche
- Wipers/Washers - Windshield Washer Malfunctions
- Body - Windshield Urethane Sealant Information
- Windshield Wipers - Noisy or Do Not Clean Properly
- Odometer/Coding Plug/Instrument Cluster - Replacement
- 410104 - 01/01/2004
- 650599 - 01/01/08
- Audio System - Radio Security Code Access
- Audio System - Interference/Noise From Door Speakers
- Radio - Security Codes in The DCS
- CD Player - CD Skips When Road Surface is Rough
- Electronic Immobilization System - Revised
- Radio - Reception Problems, Antenna Diagnosis
- SRS - (ZAE) Warning Lamp ON/Fault Code 1 Set
- A/C - Compressor Noise Diagnosis
- A/C - Compressor Noise Troubleshooting
- Electrical - Closed Circuit Current Information
- Electrical - Measurement of Closed Circuit Current
- Electrical - Closed-Circuit Current Measurement Info.
- Electrical - Closed Circuit Current Measurements
- Electrical - Closed-Circuit Current Measurement
- Audio System - CD Artist/Song Titles Not Displayed
- Plug Connector Seals - 2 and 3 Pin Connectors
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Electrical System - Parasitic Draw Measurement
- Electrical System Parasitic Draw Measurement
- Battery - Maintenance Requirement Information
- Electrical - Battery Maintenance Requirement
- Electrical - Battery Maintenance Requirements
- Battery - Maintenance Requirement
- Battery - Maintenance Requirements
- Differential - Synthetic Oils for Final Drives
- A/T - Repair and Replacement Information
- A/T - Technical Liaison for GM Transmission
- A/T - Delayed Gear Engagement or Adapter Case Leak
- DIS Software Update
- Updated DIS Software CD 8.0
- A/T - Transmission Control Module Fault Code 40
- A/T - Transmission Control Module EPROM Update
- Fuel System BMW Group Fuel System Cleaner Plus Info.
- Instruments - Fuel Level Sensor Testing Caution
- Fuel System - Alcohol Fuel Blend Usage Precautions
- Fuel System - High Alcohol Fuel Detection
- Fuel System - 'Top Tier' Gasoline Usage Recommendations
- Fuel system - Alcohol Fuel Blend Usage
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Emissions -Pressure Cont. Crankcase Ventilation Info.
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Emissions Pressure Cont. Crankcase Ventilation Info.
- Emissions - Crankcase Ventilation Vacuum Specifications
- Emissions Crankcase Ventilation Vacuum Specifications
- Emissions - Crankcase Ventilation System Information
- Crankcase Ventilation System - Diagnostic Information
- Fuel/Emissions System - Evaporative System Leak Testing
- 160107 - 08/01/07
- Computers, Controls- Programming VS Veh. Data Status
- Computers, Controls - Programming VS Veh. Data Status
- Computers/Controls- ISTA/P Programming/Coding Info.
- Computers/Control- Programming Vers. Vehicle Data Status
- Computers/Control Programming Vers. Vehicle Data Status
- Computer/Controls - Programming Version Veh. Data Status
- Computer/Controls Programming Version Veh. Data Status
- 090409 - 04/01/10
- Computer/Control - Programming Version/Veh. Data Status
- Computer/Controls - Loading/Activation Of Enabling Codes
- Computers/Controls - Programming/Coding Explanations
- Computers/Controls - ISTA/P Programming/Coding Info.
- Computers/Controls - Programming/Vehicle Data Status
- Electrical - Measurement of Closed - Circuit C
- SRS Control Module (ZAE) - Lamp ON/Code 1 Set
- SRS Control Module - Warning Lamp ON/Code 1 Set
- Updated DIS Software
- MoDic(R) - Undefined Software
- Updated MoDic(R) Diagnostic Software
- MoDic(R) - Diagnostic Software Update
- Updated MoDic(R) Diagnostic Software - D8.0
- Updated DIS Software CD 9.0
- Updated MoDic(R) Diagnostic Software - D9.0
- Computers, Controls - Programming VS Veh. Data Status
- ECM - EPROM Programming Update
- ECM - EPROM Programming Updates
- Updated DIS Software CD 18.0
- Computers/Control-Programming Vers. Vehicle Data Status
- Computers/Controls - ISTA/P Programming/Coding Info.
- Electrical - Battery Maint. Requirement Information
- Engine - CPO Engine Inspection Information
- Engine - Removal and Installation Tips
- Engine - Removal/Installation Tips
- Engine - No Start Condition When Cold
- Engine - Upper Timing Case Cover Gasket Leaks
- Engine - Crankshaft Main Bearing Cap Bolt Change
- Engine - Clicking/Tapping Noise
- Electrical - Battery Maintenance Requirement Information
- Electrical- Battery Maintenance Requirement Information
- Electrical Battery Maintenance Requirement Information
- Electrical - Battery Maintenance Requirement Info.
- Electrical - Requirements For Battery Maintenance
- Electrical Battery Maintenance Information
- Electrical Closed Circuit Current Diagnosis Info.
- Electrical - Closed Circuit Current Diagnosis Info.
- Engine -E Series Engine Oil Capacities
- Engine - E Series Engine Oil Capacities
- A/C System - Retrofitting R-12 to R-134a
- Engine, Oil Capacities
- Gasoline/Diesel Engine - Oil Capacities
- A/T - Fluid Level Checking and Application Chart
- M/T - Exchanged Transmission Oil Specification
- Cooling System - Coolant Refilling Information
- Engine - Oil Capacities (With Filter Change)
- Cooling System - Information on Coolant Refilling
- Engine Oil Capacity Information
- Engine - CPO Engine Inspection Info.
- Engine - Oil Capacity Information
- Engine - Oil Capacity Updated Information
- Engine - CPO Engine Inspection Information
- All Technical Service Bulletins
- Electrical - 90AH Absorbed Glass Matt Battery Replacement
- A/T - ZF A/T Oil Leaks, Diagnosis, and Repair Information
- Wipers/Washers - Windshield Washer Malfunctions
- Audio/Battery - Failures Caused By Aftermarket USB Cable
- Electrical System - Parasitic Draw Measurement
- Engine - Head Bolt Threads Pull Out of Engine Block
- M/T - Repairs To Clutch Pedal Assembly
- Instruments - Maximum Permissible Speedometer Deviations
- Electrical - Updated Battery Registration Procedure
- Engine - CPO Engine Inspection Information
- Computers, Controls - Programming VS Veh. Data Status
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Engine - E Series Engine Oil Capacities
- Body - Windshield Urethane Sealant Information
- A/T - Failures Due To Incorrect Installation
- Engine - Removal/Installation Tips
- Instruments - Odometer Reading Can't Be Recovered
- Body - Test Plans For Panoramic Roof
- Emissions System - Evaporative System Leak Testing
- Compuetrs/Controls - Recommended Diagnostic Procedures
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Alcohol Fuel Blend Usage
- Computers - ISTA Diagnosis On Vehicles Prior To E46
- Cooling System - Information on Coolant Refilling
- Fuel System - High Alcohol Fuel Detection
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- Engine - Crankshaft Seal/Bedplate Sealing Information
- Automatic Headlamps - Operating Characteristics
- New Self Adjusting Clutch Clamping Fixture
- Service Action/Recall Campaign 181- 200 - Labels
- Label for Service Action or Recall Campaign (#201-220)
- Tools - New Special Tool CD
- Campaign/Recall - Codes Index
- MoDic III(R) - System Description/Operation
- MoDic III(R) - Questions and Answers
- New Systems Overview
- Updated MoDic(R) Software - ZCS Coding
- TIS Software Update - 07/97
- TIS - Software Update
- Microfiche Update - All Models
- Certified Pre-Owned BMW Vehicle Program
- Service/Warranty - Information Statement
- New Environmentally Safe Parts Washer
- TIS - Software Updated
- Engine Repair Manual - Microfiche Update
- Warranty Defect Code Microfiche - Revision
- Microfiche - Service Information Bulletins List
- TIS Software Update
- DIS Maintenance and Operation
- Modified Vehicles - Warranty Exclusion
- Diagnostic Time - Warranty Reimbursement
- Service Information - Updated TIS Software
- Tools - Infrared Transmission Device (IR)
- Dealer Communications System - Enhancements
- Service Information - Microfiche/Diskette Bulletins
- Service Manual - Updated CD for TIS
- A/C - Oil Charge Procedure for R12 and R134a
- A/C System - Warranty Claim Noise Questionnaire
- A/C System - Musty Odors
- A/C - Loss of Recirculation Control Settings
- A/C - Musty Odors From Heater and A/C Systems
- P/S - Identification and Diagnosis
- TIS - Software Update 12/96
- Updated MoDic(R) Software - P9.0 Programming
- Updated MoDic(R) Software - C9.0 ZCS Coding
- Special Tools - New Torque Angle Indicator
- Engine - High Pressure Steam Cleaning Warning
- M60 Engine Test - Access in DIS
- ECM - EPROM Programming Update/Very Rough Idle
- New BMW Special Tools.
- Check Control - Trans Program Message Displayed
- Ignition - Spark Plug Application Chart
- Spark Plug/Engine Oil Capacity Reference Chart
- A/C Compressors, R-12 - Spare Parts Discontinued
- Steering Gear/Rack - Warranty Return Policy Information
- Steering Gear - Replacement Due to Accident Damage
- Special Tools - Engine Valve Guide Reamer Set
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- Cylinder Block - Identification
- Engine - Degradation of Idle Quality By High Sulfur Fuel
- ECM - EPROM Programming Updated
- A/C - Replacement of Receiver Dryers: R12/R134a
- Suspension - Replacement of Shock Absorbers
- Wheels/Tires - New Wheel Weight Tools
- Winter Tires - Recommendations Brochure
- Winter Tire - Recommendations Brochure
- Tires - Application Chart
- A/T - Transmission Will Not Shift Out of 3rd Gear
- Tires - Nitrogen Usage Recommendations
- Door Lock Plate Cover - Removal Tool
- Seat Backrest Pivot - Excessive Movement and Noise
- Tools - New Special Tools
- SRS - Collision Repair Guidelines
- Special Tool - Clutch Disc Wear Gauge
- Rear Axle - List of Ratios Updated
- ECM and EPROM - Replacement/Programming
- ECM - EPROM Replacement
- DME - MIL ON/DTC's 201/203/Driveability Concerns
- ECM - Reprogramming W/P16.0 Version Software
- Recall - Incorrectly Manufactured EPROMS
- ECM - EPROM Replacement/Application Chart
- EPROM - Replacement/Application Chart Order Form
- Special Tools - Simulator Tool For Bosch Oxygen Sensors
- Oxygen Sensor - Replacement
- Recall - Emissions in Excess of Allowable Standards
- Engine Controls - Replacement O2 Sensors Wired Wrong
- Instrument Cluster/EKM - Coding Problems
- ABS/ASC - Warning Lights On During Dynamometer Test
- Check Control Message - Brake Lights
- Battery - Maintenance System
- Illuminated Key - EWS ll Equipped Vehicles
- Starting - Ignition Key Cutting Services Caution
- Recall - Cruise Control/Throttle Cable Breakage
- Secondary Air System - One Way Valve May Not Seal
- A/T - EGS/AGS Control Module EPROM Replacement
- A/T - EGS Transmission Control Module EPROM
- Antitheft System - Sporadic False Alarms
- Central Locking System - Multiple Malfunctions
- Driveaway Protection Modules - Coding After Replacing
- EWS II Control Modules - Coding of Replacement
- Portable Telephone - Special Tool
- Cellular Phone - CMT 2000VR Number Memory
- Cellular Phone - Data Cable Connector
- Cellular Phone Antenna - Installation
- Motorola Mobile Phones - Replacement Parts
- Safety Belts - Child Restraint Feature
- SRS - Warning Lamp ON For 2 Minutes After Startup
- Restraint System - Transportation of Infants/Children
- Tools - Air Bag Triggering Adapter Cable
- SRS - Warning Lamp ON/Fault Code 1 Set
- SRS Control Module (ZAE II) - Coding
- Engine - Irregular Clicking Noise
- Main Cap Bolt - Torque Angle Change
- Instruments - New Fuel Level Sensor Testing Caution
- Oil Pressure Warning Light - Comes ON
- Speedometer - Maximum Permissible Error
- Engine - Upper Timing Case Cover Oil Leaks
- Engine Oil Pan Gasket - Revised Design
- Body - Structural Adhesives
- Body - Structural Repair Requirements
- Lights - 10-Watt Rear Bulb Failure
- ZAE Airbag Systems - Servicing
- Recall - Restraint System Labels/Warnings
- Airbag Systems - Wiring Repair Procedure
- Electronic Immobilization System - Description/Operation
- Electronic Immobilization System - Parts Information
- Electronic Immobilizer (EWS ll) - Malfunctions
- Service Information Ruling for OBD
- New Special Tool - MoDic(R) Replacement Cable
- Updated MoDic(R) Software - P8.0 Programming
- Undefined MoDic(R) Software
- Special Tools - Electrical Connector Release Tools
- ELO Diagnostic Cable - New Special Tool
- Updated MoDic(R) Software - P11.0 Programming
- Updated MoDic(R) Diagnostic Software - D12.0
- Computers/Controls - Custom Configuration
- Trunk Lock Actuator - Linkage Comes Loose
- Windshield - Bonding Adhesive Cutter
- Windshield - Replacement Tools
- Engine - Will Not Start In Cold Weather
- Engine - Oil/Coolant Leak Diagnostic Tip
- Recall 98V178000: Coolant Cap/Overflow
- Recall - Radiator Cap Replacement
- A/T - ATF Leakage From Electrical Connector O Rings
- New Automatic Transmission Special Tools
- Warranty - Technical Liaison for ZF Products
- A/T - Harsh Shifts Eased by New Control Module EPROM
- A/T - Gasket/Plug Leaks
- A/T - Pendulum Shifts, Delay Gear Engagement, Case Leak
- A/T - Does Not Upshift When Cold
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - 3rd/4th Gear Difficult to Disengage/Engage
- M/T - Difficult to Shift, Diagnostic Tips
- CD Player Malfunctions - Skips on Rough Road Surface
- Recall - Airbag Contact Ring
- Instruments - Oil Level Sensor Updated
- MoDiC(R) - Diagnostic Software Update
- MoDic(R) - Software Update V12.0
- DIS Schematic Information
- Updated MoDic(R) Software - C11.0 ZCS Coding
- DIS tester Software - Update
- MoDic(R) - Updated Software V5.1
- Engine - Oil Leaks After Short Block Replacement
- Engine Oil Capacities - All Current Models
- Electrical Connnectors - Stabilant 22A Contact Enhancer
- ETM Manual Supplement
- Electrical Trouble Shooting Manuals - Available on CD
- Electrical Repair Kit IV - Additional Connectors
- Electrical Connector Kit Supplement
- Electrical Connector Kit 4 - Supplement
- Electrical Connector Kit - Repair Listing
- Wheel - Size/Configuration
- Turn Signal/Hazard Flasher System - Erratic Operation
- Windows/Glass - New Adhesive Kit
- Paint - Approved Materials
- Paint and Paint Repairs - Warranty Coverage
- Electrical - 2 and 3 Pin Plug Connector Seal Information
- Differential - Final Drive Synthetic Oils
- New BMW Special Tools..
- Campaign - Corrosion Protection Inside Front Axle Member
- Audio - 6-Disc Alpine CD Changer Troubleshooting Guide
- Airbags - Deactivation
- Child Seat Tether Anchor - Installation
- SRS - Warning Lamp ON/Code 25 Set
- A/T, M/T - Repair Precautions to Prevent Damage
- Fuel System - Damage Caused By Fuel Contaminants
- A/C Replacement Compressor Information Insert
- Audio System - Erratic/Inoperative CD Player
- Battery - Charging Voltage Change
- Restraints - Passenger Air Bag Status Lamp Information
- Body - Glass Repair Recommendations/Service Kit
- Electrical - Wiring Harness Repair Information
- Fuel System - TOP TIER Gasoline Usage Recommendations
- Fuel System - Fuel Quality and Additive Information
- Emissions - Evaporative Emissions System Testing
- Body/Frame - Structural Repair Requirements
- Antitheft System - Alarm Triggers Unexpectedly
- Drivetrain - Differential Cover Sealant
- Progman(R) - Programming/Coding/Individualization
- Audio System - Retrieving Radio Security Codes
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Steering/Suspension - Wheel Alignment Information
- A/C - Control Assembly Damage Information
- Body - Windshield Damage Analysis
- Electrical - Battery Charging And Testing Procedure
- Brakes - Brake Rotor Removal Procedures/Precautions
- Computers/Controls - ISTA/D DTC S0001 After Quick Delete
- Lighting - Headlamp Condensation Diagnosis
- Computers/Controls - ISTA Test Plan Priority Error Info.
- Cooling System - Proper Cooling System Service Procedure
- A/C - Compressor Noise Troubleshooting
- Emissions - MIL ON, Multiple DTC's Stored
- Computers/Control - Loading/Activation Of Enabling Codes
- A/C - Revised Refrigerant/Compressor Oil Reuse Statement
- Cell Phone - Bluetooth Compatibility Information
- Restraint System - Passenger Airbag Status Lamp Info.
- Fuel System - BMW Group Fuel System Cleaner Plus Info.
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Interior - Proper Installation Of Carpet Floor Mats
- Wheel/Tires - New Style Tire Valves
- M/T - Dual Mass Flywheel Diagnostic Criteria
- Electrical - Battery Maintenance Requirement Information
- Audio System - Interference Noise From Speakers
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Wipers/Washers - Maintenance Program Wiper Inserts