Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Wipers/Washers - Windshield Washer Malfunctions
- Engine - Head Bolt Threads Pull Out of Engine Block
- Keyless Sys. - Remote Control And Comfort Access Inop.
- SRS - Warning Light ON/Multiple Fault Codes Set
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- ABS, ASC/DSC, DME Faults, and LDP Activation
- Trip Odometer - Resets to Zero After Approx. 600 Miles
- A/C - Insufficient Cooling Capacity
- A/C System - Musty Odors
- A/C System - Footwell Temperatures Too Hot
- A/C Vents - Clicking Noises
- A/C - Musty Odors From Heater and A/C Systems
- P/S - Tilt Wheel Fails To Operate, Driver's Door Open
- Multi Information Display - Flickers Intermittently
- A/C/Heater - Gurgling Noise From Dash Area
- Steering - Noise from Center Tie Rod
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- ECM - EPROM Programming Updated
- Body Lifting Pads - Wind Noise
- Drivers Seat - Moves Without Request
- Electric Seat - Adjustment Inoperative
- Glass Sunroof - Wind Noise
- Sunroof - Inoperative, or Lost Initialization
- Steering - Squealing/Groaning/Grinding Noise
- DME - MIL ON/DTC's 201/203/Driveability Concerns
- Oxygen Sensor - Replacement
- Brakes - Brake Pad Warning light ON After Pads Replaced
- Battery - Goes Dead After Vehicle Sits for Two Days
- Cell Phone, CPT 7000 - Discharged Vehicle Battery
- Ignition Switch - Faulty
- A/C - Condenser Refrigerant Leakage
- A/T - Instrument Cluster Reads Transmission Program
- A/T - Modifications of the AGS Transmission Program
- Antitheft System - Sporadic False Alarms
- Navigation System - Numerous Failures/Malfunctions
- Navigation System - Multiple Malfunctions
- Navigation System - MK3, Difficulty Coding
- Radio - Sporadically Cuts Out
- Radio - C23 MID Poor Sound Quality on AM Band
- Radio - Clicking Noise ON AM Band
- Audio System - Delayed Sound/No Audio Display
- Cellular Phone - Dim Handset Display
- Cellular Phone - Volume Fluctuation
- Telephone - Handset Occasionally Does Not Power Up
- Cell Phone - Hands-Free Function Inoperative
- Portable Phone - Ringer Volume Too Loud
- SRS - Warning Lamp ON For 2 Minutes After Startup
- SRS - Warning Lamp ON/Fault Code 1 Set
- Engine - Irregular Clicking Noise
- Oil Pressure Warning Light - Comes ON
- Cruise Control - Intermittently Inoperative
- Windshield Wiper - Inoperative, One or Both Sides
- Windshield Wipers - Various Malfunctions
- Engine - Upper Timing Case Cover Oil Leaks
- Interior - Parking Brake Cable Rattle Or Squeak
- Instrument Cluster - ABS Lamp ON
- Antitheft (DWA) System - Malfunction/False Confirmation
- Antitheft - False Alarms due to Interior Sensor
- Antitheft - False Alarms Due To Interior Sensor
- Alarm Siren - Triggers False Alarm
- Audio - Faulty Gong Causes Sound Like Alternator Noise
- Clock - Inaccurate
- Front/Rear Door - Will Not Open
- Audio - AM/FM Rear Window Antenna Wires Reversed
- CD Player Malfunctions - Skips on Rough Road Surface
- Keyless Entry - Selective Unlocking Malfunctions
- Alarm System - Horn Makes Buzzing Noise
- Trip Odometer - Resets to Zero After Recording 600 Miles
- Instrument Cluster - Dim Dot Matrix Display
- Instrument Cluster - Mileage Increases While Encoding
- Electrical System - Various System Faults
- Oil Level Sensor - Indicates Incorrect Level
- IHKA Control Module - Display Function Failure
- Seat Belts - Click/Rattle From Upper Mount
- MID - No Radio Display
- Brake Lamps - Inoperative/Warning Lamp ON
- Daytime Running Lights and Parking lights - ON
- SRS - MIL ON, Codes 16/17 or 24/25 Set
- Inner Door Handle - Does Not Operate Correctly
- DSP Amplifier - Mutes After Vehicle is Started
- Amplifier - DSP Switches ON/OFF By Itself
- DSP Amplifier - Switches ON/OFF By Itself
- Remote Transmitter - Failure to Lock or Unlock Vehicle
- Front Door, RIght - Sporadically Does Not Lock
- Safety Belt Tensioner Harness - Fault Code 5 or 6
- Brakes - Momentarily Don't Release
- Window - Clunking Noise When lowered
- Side Airbag - Replacement
- Fuel System - Damage Caused By Fuel Contaminants
- SRS - Air Bag Lamp ON/Multiple Fault Codes Set
- Audio System - Erratic/Inoperative CD Player
- Body - Windows Drop 2 Inches When Unlocking Car
- A/C - Musty Odors From Vents
- Battery - Discharges With Key Left In Ignition Switch
- Alarm System - Sounds After General Module Replacement
- Instruments - Outside Temperature Display Incorrect
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Wipers/Washers - Maintenance Program Wiper Inserts
- Seals, Gaskets
- Superceded Bulletins
- All Technical Service Bulletins
- Electrical - 90AH Absorbed Glass Matt Battery Replacement
- A/T - ZF A/T Oil Leaks, Diagnosis, and Repair Information
- Wipers/Washers - Windshield Washer Malfunctions
- Audio/Battery - Failures Caused By Aftermarket USB Cable
- Electrical System - Parasitic Draw Measurement
- Engine - Head Bolt Threads Pull Out of Engine Block
- M/T - Repairs To Clutch Pedal Assembly
- Instruments - Maximum Permissible Speedometer Deviations
- Electrical - Updated Battery Registration Procedure
- Engine - CPO Engine Inspection Information
- Computers, Controls - Programming VS Veh. Data Status
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Engine - E Series Engine Oil Capacities
- Body - Windshield Urethane Sealant Information
- A/T - Failures Due To Incorrect Installation
- Engine - Removal/Installation Tips
- Instruments - Odometer Reading Can't Be Recovered
- Body - Test Plans For Panoramic Roof
- Emissions System - Evaporative System Leak Testing
- SRS - Warning Light ON/Multiple Fault Codes Set
- Compuetrs/Controls - Recommended Diagnostic Procedures
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Alcohol Fuel Blend Usage
- Computers - ISTA Diagnosis On Vehicles Prior To E46
- Cooling System - Information on Coolant Refilling
- Fuel System - High Alcohol Fuel Detection
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- Engine - Crankshaft Seal/Bedplate Sealing Information
- Automatic Headlamps - Operating Characteristics
- New Self Adjusting Clutch Clamping Fixture
- Service Action/Recall Campaign 181- 200 - Labels
- Label for Service Action or Recall Campaign (#201-220)
- Tools - New Special Tool CD
- Campaign/Recall - Codes Index
- Vehicle Convenience Feature - Operation/Information
- MoDic III(R) - System Description/Operation
- MoDic III(R) - Questions and Answers
- New Systems Overview
- Updated MoDic(R) Software - ZCS Coding
- TIS Software Update - 07/97
- TIS - Software Update
- Microfiche Update - All Models
- Certified Pre-Owned BMW Vehicle Program
- Service/Warranty - Information Statement
- New Environmentally Safe Parts Washer
- TIS - Software Updated
- Engine Repair Manual - Microfiche Update
- Technical Data - Updated Microfiche
- Warranty Defect Code Microfiche - Revision
- Microfiche - Service Information Bulletins List
- TIS Software Update
- DIS Maintenance and Operation
- Modified Vehicles - Warranty Exclusion
- Diagnostic Time - Warranty Reimbursement
- Diag. of IKE and Other Control Modules Not Possible
- General Model Information
- Service Information - Updated TIS Software
- Tools - Infrared Transmission Device (IR)
- Dealer Communications System - Enhancements
- Service Information - Microfiche/Diskette Bulletins
- Special Tools - For The E38
- Service Manual - Updated CD for TIS
- Warranty Poilicy/Procedures Manual - Update
- ABS, ASC/DSC, DME Faults, and LDP Activation
- Trip Odometer - Resets to Zero After Approx. 600 Miles
- A/C - Oil Charge Procedure for R12 and R134a
- A/C System - Warranty Claim Noise Questionnaire
- A/C - Insufficient Cooling Capacity
- A/C System - Diagnostic Hints
- Windshield - Fogging/Condensation Avoidance Tips
- A/C System - Musty Odors
- A/C System - Footwell Temperatures Too Hot
- A/C - Temperature Control Function Change
- A/C Vents - Clicking Noises
- A/C - Musty Odors From Heater and A/C Systems
- P/S - Identification and Diagnosis
- P/S - Tilt Wheel Fails To Operate, Driver's Door Open
- TIS - Software Update 12/96
- Updated MoDic(R) Software - P9.0 Programming
- Updated MoDic(R) Software - C9.0 ZCS Coding
- Special Tools - New Torque Angle Indicator
- Engine - High Pressure Steam Cleaning Warning
- M60 Engine Test - Access in DIS
- Special Tools - M73 Engine Tools
- New BMW Special Tools.
- Multi Information Display - Flickers Intermittently
- MID Display - Flashes Sporadically
- Ignition - Spark Plug Application Chart
- Spark Plug/Engine Oil Capacity Reference Chart
- A/C Compressors, R-12 - Spare Parts Discontinued
- Heater Core - Revised
- A/C/Heater - Gurgling Noise From Dash Area
- Steering - Noise from Center Tie Rod
- Steering Gear/Rack - Warranty Return Policy Information
- Steering Gear - Replacement Due to Accident Damage
- Special Tools - Engine Valve Guide Reamer Set
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- Cylinder Block - Identification
- Engine - Degradation of Idle Quality By High Sulfur Fuel
- ECM - EPROM Programming Updated
- Cooling System - Radiator Vent Hose Fitting Replacement
- A/C - Replacement of Receiver Dryers: R12/R134a
- Special Tool - New Coil Spring Compressor Jaws
- Recall 97V140000: Possible Breakage Of Coil Spring
- Recall - Coil Spring Breakage
- Recall 97V140000: Lower Front Spring Mount Cracking
- Suspension - Replacement of Shock Absorbers
- Wheels/Tires - New Wheel Weight Tools
- Winter Tires - Recommendations Brochure
- Winter Tire - Recommendations Brochure
- Tires - Application Chart
- A/T - Transmission Will Not Shift Out of 3rd Gear
- Tires - Nitrogen Usage Recommendations
- Body Lifting Pads - Wind Noise
- Door Lock Plate Cover - Removal Tool
- Drivers Seat - Moves Without Request
- Electric Seat - Adjustment Inoperative
- Sunroof Lid - Revised Mounting Method
- Glass Sunroof - Wind Noise
- Sunroof - Inoperative, or Lost Initialization
- Sunroof - Revised Initialization Procedures
- Tools - New Special Tools
- SRS - Collision Repair Guidelines
- Steering - Squealing/Groaning/Grinding Noise
- Special Tool - Clutch Disc Wear Gauge
- Rear Axle - List of Ratios Updated
- Recall 97V131000: Throttle Valve Actuator Lever Bushing
- ECM and EPROM - Replacement/Programming
- ECM - EPROM Replacement
- DME - MIL ON/DTC's 201/203/Driveability Concerns
- ECM - Reprogramming W/P16.0 Version Software
- Recall - Incorrectly Manufactured EPROMS
- ECM - EPROM Replacement/Application Chart
- EPROM - Replacement/Application Chart Order Form
- Special Tools - Simulator Tool For Bosch Oxygen Sensors
- Oxygen Sensor - Replacement
- Recall - Emissions in Excess of Allowable Standards
- Recall - Right Rear Hub Casting Flaw
- ABS/ASC - Warning Lights On During Dynamometer Test
- Brakes - Brake Pad Warning light ON After Pads Replaced
- Battery - Maintenance System
- Battery - Goes Dead After Vehicle Sits for Two Days
- Cell Phone, CPT 7000 - Discharged Vehicle Battery
- Illuminated Key - EWS ll Equipped Vehicles
- Ignition Switch - Faulty
- Starting - Ignition Key Cutting Services Caution
- A/C - Condenser Refrigerant Leakage
- Recall 95V238000: Fuel Hose Leakage
- Recall - Fuel Line/Hose Seepage
- Special Tools - Tank Ventilation Leak Couplers
- Recall - Cruise Control/Throttle Cable Breakage
- A/T - EGS/AGS Control Module EPROM Replacement
- A/T - Instrument Cluster Reads Transmission Program
- A/T - Modifications of the AGS Transmission Program
- Antitheft System - Sporadic False Alarms
- Driveaway Protection Modules - Coding After Replacing
- EWS II Control Modules - Coding of Replacement
- Navigation System - Numerous Failures/Malfunctions
- Navigation System - Multiple Malfunctions
- Navigation System - MK3, Difficulty Coding
- Radio - Sporadically Cuts Out
- Radio - Removal Tools
- Radio - C23 MID Poor Sound Quality on AM Band
- Radio - Clicking Noise ON AM Band
- Audio System - Delayed Sound/No Audio Display
- Portable Telephone - Special Tool
- Cellular Phone - CMT 2000VR Number Memory
- Cellular Phone - Dim Handset Display
- Cellular Phone - Antenna Cable
- Cellular Phone - Volume Fluctuation
- Telephone - Handset Occasionally Does Not Power Up
- Cellular Phone - Reversed Second Antenna Cable
- Cellular Phone Antenna - Installation
- Cellular Phone - CMT3000VR EPROM Change
- Cellular Phone - CMT3000VR Improved Software
- Identify Transfer Kit for CMT Phones
- Motorola Mobile Phones - Replacement Parts
- Cellular Phone - CMT5000VR Improved Software
- Cell Phone - Hands-Free Function Inoperative
- Portable Phone - Ringer Volume Too Loud
- Cellular Phone - Coax Mini-UHK Extension Cable
- Identity Transfer Kits for CMT/CPT Phones
- Cellular Phones - Identity Transfer Kit
- Cellular Telephone - Memory Upload Procedures
- Cellular Phone - Software Improvement
- Cellular Phone - CMT3000 Software Modification
- Safety Belts - Child Restraint Feature
- SRS - Warning Lamp ON For 2 Minutes After Startup
- Restraint System - Transportation of Infants/Children
- Tools - Air Bag Triggering Adapter Cable
- SRS - Warning Lamp ON/Fault Code 1 Set
- Engine - Irregular Clicking Noise
- Main Cap Bolt - Torque Angle Change
- Instruments - New Fuel Level Sensor Testing Caution
- Oil Pressure Warning Light - Comes ON
- Speedometer - Maximum Permissible Error
- Headlight - Aiming Procedure
- Cruise Control - Intermittently Inoperative
- Windshield Wiper - Inoperative, One or Both Sides
- Windshield Wipers - Various Malfunctions
- Engine - Upper Timing Case Cover Oil Leaks
- Engine Oil Pan Gasket - Revised Design
- Interior - Parking Brake Cable Rattle Or Squeak
- Instrument Cluster - ABS Lamp ON
- Starting - Ignition Lock Spins Freely
- Campaign - Towing/Tie-Down Damage to Suspension
- Body - Structural Adhesives
- Aluminum Components - Painting Procedure
- Body - Structural Repair Requirements
- Radio Frequency Remote Control - Range Information
- ZAE Airbag Systems - Servicing
- Recall - Restraint System Labels/Warnings
- SRS - MRS III Diagnosis
- Airbag Systems - Wiring Repair Procedure
- Electronic Immobilization System - Description/Operation
- Electronic Immobilization System - Parts Information
- Electronic Immobilizer (EWS ll) - Malfunctions
- Electronic Immobilization Systems (EWS II) - Information
- Antitheft (DWA) System - Malfunction/False Confirmation
- Antitheft System - Emergency Power Siren
- Antitheft - False Alarms due to Interior Sensor
- Antitheft - False Alarms Due To Interior Sensor
- Alarm Siren - Triggers False Alarm
- Car Memory/Key Memory - Frequently Asked Questions
- Antitheft - Programming/Coding Explanations
- Service Information Ruling for OBD
- New BMW Shop Equipment
- New Special Tool - MoDic(R) Replacement Cable
- Updated MoDic(R) Software - P8.0 Programming
- Undefined MoDic(R) Software
- Special Tools - ZAE/MRS Test Cable
- Special Tools - Electrical Connector Release Tools
- ELO Diagnostic Cable - New Special Tool
- Updated MoDic(R) Software - P11.0 Programming
- Updated MoDic(R) Diagnostic Software - D12.0
- Computers/Controls - Custom Configuration
- Audio - Faulty Gong Causes Sound Like Alternator Noise
- Clock - Inaccurate
- Front/Rear Door - Will Not Open
- Windshield - Bonding Adhesive Cutter
- Windshield - Replacement Tools
- Engine - Will Not Start In Cold Weather
- Engine - Oil/Coolant Leak Diagnostic Tip
- Recall 98V178000: Coolant Cap/Overflow
- Campaign - Brake Line Routing
- A/T - ATF Leakage From Electrical Connector O Rings
- New Automatic Transmission Special Tools
- Warranty - Technical Liaison for ZF Products
- A/T - Does Not Upshift When Cold
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T - Difficult to Shift, Diagnostic Tips
- Audio - AM/FM Rear Window Antenna Wires Reversed
- CD Player Malfunctions - Skips on Rough Road Surface
- Keyless Entry - Selective Unlocking Malfunctions
- A/T - Special ATF Requirements
- Alarm System - Horn Makes Buzzing Noise
- Recall 95V192000: Rear Axle Hub Carrier Casting Flawed
- Electrical - New Special Tool
- Trip Odometer - Resets to Zero After Recording 600 Miles
- Instrument Cluster - Dim Dot Matrix Display
- Instrument Cluster - Mileage Increases While Encoding
- IC Conversion - Km/h to Mph or Mph to Km/h
- Electrical System - Various System Faults
- Oil Level Sensor - Indicates Incorrect Level
- IHKA Control Module - Display Function Failure
- MoDiC(R) - Diagnostic Software Update
- MoDic(R) - Software Update V12.0
- DIS Schematic Information
- Updated MoDic(R) Software - C11.0 ZCS Coding
- DIS tester Software - Update
- MoDic(R) - Updated Software V5.1
- Engine - Oil Leaks After Short Block Replacement
- Engine Oil Capacities - All Current Models
- Electrical Connnectors - Stabilant 22A Contact Enhancer
- Campaign - Navigation System Failure
- Electrical Trouble Shooting Manuals - Available on CD
- Electrical - New Special Tools
- Electrical Repair Kit IV - Additional Connectors
- Electrical Connector Kit Supplement
- Special Tools - Electronic Contact Adapter Cables
- Electrical Connector Kit 4 - Supplement
- Electrical Connector Kit - Repair Listing
- Wheel - Size/Configuration
- Campaign - Corrosion Protection Inside Rear Axle Carrier
- Seat Belts - Click/Rattle From Upper Mount
- Windows/Glass - New Adhesive Kit
- MID - No Radio Display
- Navigation System - Diagnostics with DIS Version 12.0
- Navigation System - Operating Software Update
- Paint - Approved Materials
- Paint and Paint Repairs - Warranty Coverage
- Electrical - 2 and 3 Pin Plug Connector Seal Information
- Brake Lamps - Inoperative/Warning Lamp ON
- Daytime Running Lights and Parking lights - ON
- SRS - MIL ON, Codes 16/17 or 24/25 Set
- Inner Door Handle - Does Not Operate Correctly
- Differential - Final Drive Synthetic Oils
- DSP Amplifier - Mutes After Vehicle is Started
- Amplifier - DSP Switches ON/OFF By Itself
- DSP Amplifier - Switches ON/OFF By Itself
- Tools - Light Check Module Test Cable
- Remote Transmitter - Failure to Lock or Unlock Vehicle
- Front Door, RIght - Sporadically Does Not Lock
- Safety Belt Tensioner Harness - Fault Code 5 or 6
- New BMW Special Tools..
- Brakes - Momentarily Don't Release
- Jack - Causes Vehicle Body Damage
- Window - Clunking Noise When lowered
- Audio - 6-Disc Alpine CD Changer Troubleshooting Guide
- Airbags - Deactivation
- Child Seat Tether Anchor - Mounting Points
- Child Seat Tether Anchor - Installation
- Side Airbag - Replacement
- A/T, M/T - Repair Precautions to Prevent Damage
- Fuel System - Damage Caused By Fuel Contaminants
- A/C Replacement Compressor Information Insert
- SRS - Air Bag Lamp ON/Multiple Fault Codes Set
- Audio System - Erratic/Inoperative CD Player
- Body - Windows Drop 2 Inches When Unlocking Car
- A/C - Musty Odors From Vents
- Battery - Charging Voltage Change
- Battery - Discharges With Key Left In Ignition Switch
- Restraints - Passenger Air Bag Status Lamp Information
- Alarm System - Sounds After General Module Replacement
- Body - Glass Repair Recommendations/Service Kit
- Electrical - Wiring Harness Repair Information
- Fuel System - TOP TIER Gasoline Usage Recommendations
- Fuel System - Fuel Quality and Additive Information
- Navigation System - Missing or Incorrect Road Map Data
- Instruments - Outside Temperature Display Incorrect
- Antitheft System - EWS Coding and Alignment
- Emissions - Evaporative Emissions System Testing
- Body/Frame - Structural Repair Requirements
- Navigation System - Software Information
- Antitheft System - Alarm Triggers Unexpectedly
- Drivetrain - Differential Cover Sealant
- Progman(R) - Programming/Coding/Individualization
- Audio System - Retrieving Radio Security Codes
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Steering/Suspension - Wheel Alignment Information
- A/C - Control Assembly Damage Information
- Body - Windshield Damage Analysis
- Electrical - Battery Charging And Testing Procedure
- Brakes - Brake Rotor Removal Procedures/Precautions
- Computers/Controls - ISTA/D DTC S0001 After Quick Delete
- Lighting - Headlamp Condensation Diagnosis
- Computers/Controls - ISTA Test Plan Priority Error Info.
- Cooling System - Proper Cooling System Service Procedure
- A/C - Compressor Noise Troubleshooting
- Emissions - MIL ON, Multiple DTC's Stored
- Computers/Control - Loading/Activation Of Enabling Codes
- A/C - Revised Refrigerant/Compressor Oil Reuse Statement
- Navigation System - Software Version Information
- Cell Phone - Bluetooth Compatibility Information
- Restraint System - Passenger Airbag Status Lamp Info.
- Fuel System - BMW Group Fuel System Cleaner Plus Info.
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Interior - Proper Installation Of Carpet Floor Mats
- Wheel/Tires - New Style Tire Valves
- M/T - Dual Mass Flywheel Diagnostic Criteria
- Computer/Controls - Replacement DME Programming
- Electrical - Battery Maintenance Requirement Information
- Audio System - Interference Noise From Speakers
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Wipers/Washers - Maintenance Program Wiper Inserts