Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Wipers/Washers - Windshield Washer Malfunctions
- Engine - Head Bolt Threads Pull Out of Engine Block
- Keyless Sys. - Remote Control And Comfort Access Inop.
- SRS - Warning Light ON/Multiple Fault Codes Set
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- ABS, ASC/DSC, DME Faults, and LDP Activation
- Trip Odometer - Resets to Zero After Approx. 600 Miles
- A/C - Insufficient Cooling Capacity
- A/C System - Musty Odors
- A/C System - Footwell Temperatures Too Hot
- A/C Vents - Clicking Noises
- A/C - Musty Odors From Heater and A/C Systems
- P/S - Tilt Wheel Fails To Operate, Driver's Door Open
- Electrical - Engine Fuse Premature Failures
- Interior - High Pitched Noise From Fuel Tank
- Multi Information Display - Flickers Intermittently
- A/C/Heater - Gurgling Noise From Dash Area
- Steering - Noise from Center Tie Rod
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- Engine - Intermittent Rough Idle
- Thermostat - Possible MIL ON/Gauge Reads High
- Coolant Thermostat - Engine Overheats
- Body Lifting Pads - Wind Noise
- Drivers Seat - Moves Without Request
- Electric Seat - Adjustment Inoperative
- Glass Sunroof - Wind Noise
- Sunroof - Inoperative, or Lost Initialization
- Interior - Wind Buffeting
- Steering - Squealing/Groaning/Grinding Noise
- Engine Controls - Check Engine Lamp/Misfire Faults
- Brakes - Brake Pad Warning light ON After Pads Replaced
- Cell Phone, CPT 7000 - Discharged Vehicle Battery
- Ignition Switch - Faulty
- A/C - Condenser Refrigerant Leakage
- Brakes - ASC MIL ON No Codes Set
- A/T - Poor Shift Quality
- Fuel System - MIL ON, Tank Leakage Fault Codes
- Catalytic Converter - Rattling Noise
- A/T - Harsh Upshifts, Updated AGS Software
- A/T - Hangs in Gear At Times/Downshifts For No Reason
- A/T - Hard 5th to 4th/3rd to 2nd Gear Downshifts
- A/T - Harsh Upshifts, New Software For Control Module
- Antitheft System - Sporadic False Alarms
- Navigation System - Numerous Failures/Malfunctions
- Navigation System - Multiple Malfunctions
- Navigation System - MK3, Difficulty Coding
- Radio - Sporadically Cuts Out
- Radio - C23 MID Poor Sound Quality on AM Band
- Radio - Clicking Noise ON AM Band
- Audio System - Delayed Sound/No Audio Display
- Telephone - Handset Occasionally Does Not Power Up
- Cell Phone - Hands-Free Function Inoperative
- Portable Phone - Ringer Volume Too Loud
- Cellular Phone - No Volume Adjustment
- SRS - Warning Lamp ON For 2 Minutes After Startup
- Airbag Control Module - Warning Light ON/Codes Set
- Engine - Irregular Clicking Noise
- Cruise Control - Intermittently Inoperative
- Windshield Wiper - Inoperative, One or Both Sides
- Windshield Wipers - Various Malfunctions
- Cylinder Head - Bolt Retorque
- Interior - Parking Brake Cable Rattle Or Squeak
- Steering Wheel (MFL) Switches - Illumination, Flicker
- Antitheft - False Alarms due to Interior Sensor
- Antitheft - False Alarms Due To Interior Sensor
- Alarm Siren - Triggers False Alarm
- Evaporative Emission Control - MIL ON DTC's Stored
- Engine - Cranks, But Will Not Start, Fault Codes Set
- ECM - Increase Idle Speed by Reprogramming DME (M5.2)
- Audio - Faulty Gong Causes Sound Like Alternator Noise
- Clock - Inaccurate
- Front/Rear Door - Will Not Open
- Windshield Wiper Blades - Noisy/Not Cleaning Well
- A/T - A5S440Z, Torque Converter Area Fluid Leaks
- Audio - AM/FM Rear Window Antenna Wires Reversed
- CD Player Malfunctions - Skips on Rough Road Surface
- Keyless Entry - Selective Unlocking Malfunctions
- Trip Odometer - Resets to Zero After Recording 600 Miles
- Instrument Cluster - Dim Dot Matrix Display
- Instrument Cluster - Mileage Increases While Encoding
- Electrical System - Various System Faults
- Engine Controls - False Low Oil Level Lamp Illumination
- Engine Controls - Engine Low Oil Level Warning
- Seat Belts - Click/Rattle From Upper Mount
- MID - No Radio Display
- MK I Navigation System - Monitor Display Too Dark
- Power Windows, Rear - Inoperative
- Brake Lamps - Inoperative/Warning Lamp ON
- Daytime Running Lights and Parking lights - ON
- SRS - MIL ON, Codes 16/17 or 24/25 Set
- DSP Amplifier - Mutes After Vehicle is Started
- Amplifier - DSP Switches ON/OFF By Itself
- DSP Amplifier - Switches ON/OFF By Itself
- Power Consuming Systems - Temporarily Inoperative
- Remote Transmitter - Failure to Lock or Unlock Vehicle
- Front Door, RIght - Sporadically Does Not Lock
- Safety Belt Tensioner Harness - Fault Code 5 or 6
- Radio - Inadequate Reception
- Brakes - Momentarily Don't Release
- Window - Clunking Noise When lowered
- Evaporative System - Canister Purge Line Restricted
- Side Airbag - Replacement
- Fuel System - Damage Caused By Fuel Contaminants
- SRS - Air Bag Lamp ON/Multiple Fault Codes Set
- Audio System - Erratic/Inoperative CD Player
- Body - Windows Drop 2 Inches When Unlocking Car
- A/C - Musty Odors From Vents
- Battery - Discharges With Key Left In Ignition Switch
- Instruments - Outside Temperature Display Incorrect
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Wipers/Washers - Maintenance Program Wiper Inserts
- Recommended Repairs
- Superceded Bulletins
- All Technical Service Bulletins
- Fuel System - Evaporative System Vacuum Leak Diagnosis
- Electrical - 90AH Absorbed Glass Matt Battery Replacement
- CCC(R) - Enabling Code Info.
- A/T - ZF A/T Oil Leaks, Diagnosis, and Repair Information
- Wipers/Washers - Windshield Washer Malfunctions
- Audio/Battery - Failures Caused By Aftermarket USB Cable
- Electrical System - Parasitic Draw Measurement
- Engine - Head Bolt Threads Pull Out of Engine Block
- M/T - Repairs To Clutch Pedal Assembly
- Instruments - Maximum Permissible Speedometer Deviations
- Electrical - Updated Battery Registration Procedure
- Engine - CPO Engine Inspection Information
- Computers, Controls - Programming VS Veh. Data Status
- Keyless Sys. - Remote Control And Comfort Access Inop.
- Engine - E Series Engine Oil Capacities
- Body - Windshield Urethane Sealant Information
- A/T - Failures Due To Incorrect Installation
- Engine - Removal/Installation Tips
- Instruments - Odometer Reading Can't Be Recovered
- Entertainment Sys. - Audio Has Dropouts Or Distortions
- Body - Test Plans For Panoramic Roof
- Emissions System - Evaporative System Leak Testing
- SRS - Warning Light ON/Multiple Fault Codes Set
- Compuetrs/Controls - Recommended Diagnostic Procedures
- Steering - Steering Wheel Leather Peeling From The Rear
- Fuel System - Alcohol Fuel Blend Usage
- Computers - ISTA Diagnosis On Vehicles Prior To E46
- Cooling System - Information on Coolant Refilling
- Fuel System - High Alcohol Fuel Detection
- Fuel System - Fuel Cap Tether Is Broken Or Lost
- Engine - Crankshaft Seal/Bedplate Sealing Information
- Automatic Headlamps - Operating Characteristics
- New Self Adjusting Clutch Clamping Fixture
- Service Action/Recall Campaign 181- 200 - Labels
- Label for Service Action or Recall Campaign (#201-220)
- Tools - New Special Tool CD
- Campaign/Recall - Codes Index
- Vehicle Convenience Feature - Operation/Information
- MoDic III(R) - System Description/Operation
- MoDic III(R) - Questions and Answers
- Updated MoDic(R) Software - ZCS Coding
- TIS Software Update - 07/97
- TIS - Software Update
- Microfiche Update - All Models
- Certified Pre-Owned BMW Vehicle Program
- Service/Warranty - Information Statement
- New Environmentally Safe Parts Washer
- TIS - Software Updated
- Engine Repair Manual - Microfiche Update
- Warranty Defect Code Microfiche - Revision
- Microfiche - Service Information Bulletins List
- DIS Maintenance and Operation
- Modified Vehicles - Warranty Exclusion
- Diagnostic Time - Warranty Reimbursement
- ABS, ASC/DSC, DME Faults, and LDP Activation
- Trip Odometer - Resets to Zero After Approx. 600 Miles
- A/C System - Warranty Claim Noise Questionnaire
- A/C - Insufficient Cooling Capacity
- A/C System - Diagnostic Hints
- Windshield - Fogging/Condensation Avoidance Tips
- A/C System - Musty Odors
- A/C System - Footwell Temperatures Too Hot
- A/C - Temperature Control Function Change
- A/C Vents - Clicking Noises
- A/C - Changes to Automatic Climate Control (IHKA) Panels
- A/C - Musty Odors From Heater and A/C Systems
- P/S - Tilt Wheel Fails To Operate, Driver's Door Open
- TIS - Software Update 12/96
- Updated MoDic(R) Software - P9.0 Programming
- Updated MoDic(R) Software - C9.0 ZCS Coding
- Electrical - Engine Fuse Premature Failures
- Special Tools - New Torque Angle Indicator
- Engine - High Pressure Steam Cleaning Warning
- New BMW Special Tools.
- Interior - High Pitched Noise From Fuel Tank
- Multi Information Display - Flickers Intermittently
- MID Display - Flashes Sporadically
- Spark Plug/Engine Oil Capacity Reference Chart
- Heater Core - Revised
- A/C/Heater - Gurgling Noise From Dash Area
- Steering - Noise from Center Tie Rod
- Steering Gear - Replacement Due to Accident Damage
- Engine - M62 New Special Tools
- Engine - MIL ON/Codes Set/Tapping/Rattling Noise
- Cylinder Block - Identification
- Engine - Intermittent Rough Idle
- Thermostat - Possible MIL ON/Gauge Reads High
- Coolant Thermostat - Engine Overheats
- Cooling System - Radiator Vent Hose Fitting Replacement
- A/C - Replacement of Receiver Dryers: R12/R134a
- Special Tool - New Coil Spring Compressor Jaws
- Recall 97V140000: Possible Breakage Of Coil Spring
- Recall - Coil Spring Breakage
- Recall 97V140000: Lower Front Spring Mount Cracking
- Wheels/Tires - New Wheel Weight Tools
- Tires - Applications/Recommendations
- A/T - Transmission Will Not Shift Out of 3rd Gear
- Tires - Nitrogen Usage Recommendations
- Body Lifting Pads - Wind Noise
- Drivers Seat - Moves Without Request
- Electric Seat - Adjustment Inoperative
- Door Sound/Vapor Barrier - Water Leaks
- Glass Sunroof - Wind Noise
- Sunroof - Inoperative, or Lost Initialization
- Interior - Wind Buffeting
- Sunroof - Revised Initialization Procedures
- Tools - New Special Tools
- Steering - Squealing/Groaning/Grinding Noise
- Special Tool - Clutch Disc Wear Gauge
- Tools - Final Drive Seal Installer
- Recall 97V131000: Throttle Valve Actuator Lever Bushing
- Warranty - Quality Monitoring Camshaft Sensor
- Engine Control Modules - Programming Hints
- ECM - Programming Not Possible With CD 18
- Campaign - Multiple DTC's Due to ECM Software Error
- ECM - Reprogramming W/P16.0 Version Software
- Engine Control Module - MS 43 Removal Precautions
- Engine Controls - Check Engine Lamp/Misfire Faults
- Campaign - Reprogramming ECM, O2 Sensor Trouble Codes
- Engine Controls - Idle Speed Too Low, Update ECM
- ECM - EPROM Replacement/Application Chart
- EPROM - Replacement/Application Chart Order Form
- ABS/ASC - Warning Lights On During Dynamometer Test
- Brakes - Brake Pad Warning light ON After Pads Replaced
- Battery - Maintenance System
- Battery - Maintenance
- Cell Phone, CPT 7000 - Discharged Vehicle Battery
- Engine Controls - Unable to Diagnose Using DIS Tester
- Ignition Switch - Faulty
- Starting - Ignition Key Cutting Services Caution
- A/C - Condenser Refrigerant Leakage
- Brakes - ASC MIL ON No Codes Set
- ECM - Programming/Replacing FLASH Control Modules
- A/T - Poor Shift Quality
- Special Tools - Tank Ventilation Leak Couplers
- Fuel System - MIL ON, Tank Leakage Fault Codes
- Recall - Cruise Control/Throttle Cable Breakage
- Catalytic Converter - Rattling Noise
- Catalytic Converter - Unnecessary Replacements
- Check Engine Lamp ON/DTC's Stored
- A/T - Harsh Upshifts, Updated AGS Software
- A/T - Hangs in Gear At Times/Downshifts For No Reason
- A/T - Hard 5th to 4th/3rd to 2nd Gear Downshifts
- A/T - Harsh Upshifts, New Software For Control Module
- Antitheft System - Sporadic False Alarms
- Navigation System - Numerous Failures/Malfunctions
- Navigation System - Multiple Malfunctions
- Navigation System - MK3, Difficulty Coding
- Radio - Sporadically Cuts Out
- Radio - Removal Tools
- Radio - C23 MID Poor Sound Quality on AM Band
- Radio - Clicking Noise ON AM Band
- Audio System - Delayed Sound/No Audio Display
- Telephone - Handset Occasionally Does Not Power Up
- Cellular Phone - Reversed Second Antenna Cable
- Cellular Phone Antenna - Installation
- Cellular Phone - CMT3000VR EPROM Change
- Cellular Phone - CMT3000VR Improved Software
- Identify Transfer Kit for CMT Phones
- Cellular Phone - Mounting Brackets
- Motorola Mobile Phones - Replacement Parts
- Cellular Phone - CMT5000VR Improved Software
- Cell Phone - Hands-Free Function Inoperative
- Portable Phone - Ringer Volume Too Loud
- Cellular Phone - Coax Mini-UHK Extension Cable
- Identity Transfer Kits for CMT/CPT Phones
- Cellular Phones - Identity Transfer Kit
- Cellular Telephone - Memory Upload Procedures
- Digital Cellular Phone - Adapter Harness
- Cellular Phone - No Volume Adjustment
- Digital Cellular Phone - Training/Troubleshooting Manual
- Cellular Phone - Voice Input Adapter Harness
- Safety Belts - Child Restraint Feature
- SRS - Warning Lamp ON For 2 Minutes After Startup
- Restraint System - Transportation of Infants/Children
- Tools - Air Bag Triggering Adapter Cable
- Head Protection System - Airbag Replacement
- Airbag Control Module - Warning Light ON/Codes Set
- Engine - New Oil Filter Element
- Engine - Irregular Clicking Noise
- Instruments - New Fuel Level Sensor Testing Caution
- Speedometer - Maximum Permissible Error
- Xenon Lamp Bulb - Color Change After Operation
- Cruise Control - Intermittently Inoperative
- Windshield Wiper - Inoperative, One or Both Sides
- Windshield Wipers - Various Malfunctions
- Cylinder Head - Bolt Retorque
- Engine Oil Pan Gasket - Revised Design
- Interior - Parking Brake Cable Rattle Or Squeak
- Steering Wheel (MFL) Switches - Illumination, Flicker
- Starting - Ignition Lock Spins Freely
- Campaign - Towing/Tie-Down Damage to Suspension
- Body - Structural Repair Requirements
- Recall - Restraint System Labels/Warnings
- Air Bag System - Child Warning Labels
- SRS - MRS III Diagnosis
- Airbag Systems - Wiring Repair Procedure
- Electronic Immobilizer (EWS ll) - Malfunctions
- Antitheft System - Emergency Power Siren
- Antitheft - False Alarms due to Interior Sensor
- Antitheft - False Alarms Due To Interior Sensor
- Alarm Siren - Triggers False Alarm
- Vehicle and Key - Memory Programming
- Car Memory/Key Memory - Frequently Asked Questions
- Antitheft - Programming/Coding Explanations
- Service Information Ruling for OBD
- Engine Controls/Emissions - OBD Readiness Code Setting
- Evap. Emission Control - Fuel Filler Cap/Door Labels
- Evaporative Emission Control - MIL ON DTC's Stored
- Exhaust System - Back Pressure Checking Tool
- Updated MoDic(R) Software - P8.0 Programming
- Undefined MoDic(R) Software
- Special Tools - ZAE/MRS Test Cable
- Intake Air System - DTC's 27 and 35 Set/MIL ON
- Engine - Cranks, But Will Not Start, Fault Codes Set
- Engine Cranks, But Does Not Start, Fault Codes Set
- ECM - Increase Idle Speed by Reprogramming DME (M5.2)
- Engine Controls - OBD II Training And Manual
- Special Tools - DSCIII Test Cable
- Special Tools - Electrical Connector Release Tools
- Special Tool - 134 Pin Break Out Box
- Updated MoDic(R) Software - P11.0 Programming
- Updated MoDic(R) Diagnostic Software - D12.0
- Computers/Controls - Custom Configuration
- Engine Controls - Progman(R) V21.0 Software Errors
- Audio - Faulty Gong Causes Sound Like Alternator Noise
- Clock - Inaccurate
- Front/Rear Door - Will Not Open
- Windshield - Bonding Adhesive Cutter
- Windshield - Replacement Tools
- Windshield Wiper Blades - Noisy/Not Cleaning Well
- Engine - Oil/Coolant Leak Diagnostic Tip
- Campaign - Brake Line Routing
- A/T - Does Not Upshift When Cold
- A/T - Overview and Performance Information
- M/T - Difficult to Shift, Diagnostic Tips
- A/T - A5S440Z, Torque Converter Area Fluid Leaks
- Audio - AM/FM Rear Window Antenna Wires Reversed
- CD Player Malfunctions - Skips on Rough Road Surface
- Keyless Entry - Selective Unlocking Malfunctions
- A/T - Special ATF Requirements
- A/T - Fluid Level Checking Procedure
- Vehicle - Various Electrical System Failure
- Trip Odometer - Resets to Zero After Recording 600 Miles
- Instrument Cluster - Dim Dot Matrix Display
- Instrument Cluster - Mileage Increases While Encoding
- IC Conversion - Km/h to Mph or Mph to Km/h
- Electrical System - Various System Faults
- Engine Controls - False Low Oil Level Lamp Illumination
- DIS Schematic Information
- Updated MoDic(R) Software - C11.0 ZCS Coding
- Engine Controls - Engine Low Oil Level Warning
- Electrical Connnectors - Stabilant 22A Contact Enhancer
- Campaign - Navigation System Failure
- Electrical Trouble Shooting Manuals - Available on CD
- Electrical Repair Kit IV - Additional Connectors
- Electrical Connector Kit 4 - Supplement
- Recall - Replacing the B+ Cable Attaching Clip
- Campaign - Corrosion Protection Inside Rear Axle Carrier
- Seat Belts - Click/Rattle From Upper Mount
- Windows/Glass - New Adhesive Kit
- MID - No Radio Display
- Audio System - Test CD/Tape
- Navigation System - Calibration
- Mark II Navigation System - Calibration Procedure
- Navigation System - Diagnostics with DIS Version 12.0
- Navigation System - Operating Software Update
- MK I Navigation System - Monitor Display Too Dark
- Navigation System - Software Ordering
- Paint - Approved Materials
- Paint and Paint Repairs - Warranty Coverage
- Electrical - 2 and 3 Pin Plug Connector Seal Information
- Power Windows, Rear - Inoperative
- Brake Lamps - Inoperative/Warning Lamp ON
- Daytime Running Lights and Parking lights - ON
- SRS - MIL ON, Codes 16/17 or 24/25 Set
- Differential - Final Drive Synthetic Oil Recommendations
- DSP Amplifier - Mutes After Vehicle is Started
- Amplifier - DSP Switches ON/OFF By Itself
- DSP Amplifier - Switches ON/OFF By Itself
- Tools - Light Check Module Test Cable
- Power Consuming Systems - Temporarily Inoperative
- Remote Transmitter - Failure to Lock or Unlock Vehicle
- Front Door, RIght - Sporadically Does Not Lock
- Safety Belt Tensioner Harness - Fault Code 5 or 6
- Radio - Inadequate Reception
- New BMW Special Tools..
- Brakes - Momentarily Don't Release
- M/T - Oil Fill/Drain Plugs Updated
- Window - Clunking Noise When lowered
- Universal Transmitter - Missing
- Evaporative System - Canister Purge Line Restricted
- Audio - 6-Disc Alpine CD Changer Troubleshooting Guide
- Airbags - Deactivation
- Child Seat Tether Anchor - Mounting Points
- Child Seat Tether Anchor - Installation
- Side Airbag - Replacement
- A/T, M/T - Repair Precautions to Prevent Damage
- Fuel System - Damage Caused By Fuel Contaminants
- A/C Replacement Compressor Information Insert
- Engine Controls - Progman(R) V21.01 and V21.02.01 Errors
- Computers/Controls - Progman(R) V22.0/V22.0.1 Errors
- SRS - Air Bag Lamp ON/Multiple Fault Codes Set
- Engine Controls - Progman(R) V22.1/V22.1.1 and V22.1.2
- Audio System - Erratic/Inoperative CD Player
- Body - Windows Drop 2 Inches When Unlocking Car
- A/C - Musty Odors From Vents
- Battery - Charging Voltage Change
- Battery - Discharges With Key Left In Ignition Switch
- Electrical - Battery Chager Causes Fault Codes to Set
- Computers/Controls - 'Retrofit' Update Programming
- Engine Controls - Various Driveability Complaints
- Restraints - Passenger Air Bag Status Lamp Information
- Engine Controls - Updated DISplus/GT1 Software
- Body - Glass Repair Recommendations/Service Kit
- Electrical - Wiring Harness Repair Information
- Fuel System - TOP TIER Gasoline Usage Recommendations
- Fuel System - Fuel Quality and Additive Information
- Navigation System - Missing or Incorrect Road Map Data
- Instruments - Outside Temperature Display Incorrect
- Antitheft System - EWS Coding and Alignment
- Emissions - Evaporative Emissions System Testing
- Body/Frame - Structural Repair Requirements
- Navigation System - Software Information
- Antitheft System - Alarm Triggers Unexpectedly
- Drivetrain - Differential Cover Sealant
- Progman(R) - Programming/Coding/Individualization
- Audio System - Retrieving Radio Security Codes
- Paint - Environmental/Industrial Fallout Repair
- Audio System - AM/FM Radio Reception Problems
- Steering/Suspension - Wheel Alignment Information
- A/C - Control Assembly Damage Information
- Body - Windshield Damage Analysis
- Electrical - Battery Charging And Testing Procedure
- Brakes - Brake Rotor Removal Procedures/Precautions
- Computers/Controls - ISTA/D DTC S0001 After Quick Delete
- Lighting - Headlamp Condensation Diagnosis
- Computers/Controls - ISTA Test Plan Priority Error Info.
- Cooling System - Proper Cooling System Service Procedure
- A/C - Compressor Noise Troubleshooting
- Computers/Control - Loading/Activation Of Enabling Codes
- A/C - Revised Refrigerant/Compressor Oil Reuse Statement
- Navigation System - Software Version Information
- Cell Phone - Bluetooth Compatibility Information
- Restraint System - Passenger Airbag Status Lamp Info.
- Light Bulb - Replacement Guidelines
- Fuel System - BMW Group Fuel System Cleaner Plus Info.
- Accessories - Integrated Univ. Remote Control Diag. Tips
- Interior - Proper Installation Of Carpet Floor Mats
- Wheel/Tires - New Style Tire Valves
- M/T - Dual Mass Flywheel Diagnostic Criteria
- Computer/Controls - Replacement DME Programming
- Electrical - Battery Maintenance Requirement Information
- Audio System - Interference Noise From Speakers
- Emissions - Pressure Cont. Crankcase Ventilation Info.
- Wipers/Washers - Maintenance Program Wiper Inserts