Powertrain Management: Technical Service Bulletins

• Recalls
  • Recall - Engine Thermostat Inspection/Replacement
    • Overview
    • Owner Letter
  • Recall - Crankcase Ventilation Hose Replacement
• Customer Interest
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Fuel System - MIL/Check Gas Cap Lamp ON
  • Engine Controls - Temp Gauge Goes To Red/No Overheat
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • A/T - Fault Code 48, TCC Solenoid
  • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Key in Ignition Warning Chime - Continues to Sound
  • A/T - Poor Shift Quality
  • Fuel System - MIL ON, Tank Leakage Fault Codes
  • Seat Heater - Headlights Dim/Idle Fluctuations
  • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • Fuel System - Damage Caused By Fuel Contaminants
  • Battery - Discharges With Key Left In Ignition Switch
• By Symptom
  • Abnormal wear/deterioration
    • Fuel System - Damage Caused By Fuel Contaminants
  • Customer Interest
    • Fuel System - Fuel Cap Tether Is Broken Or Lost
    • Fuel System - MIL/Check Gas Cap Lamp ON
    • Engine Controls - Temp Gauge Goes To Red/No Overheat
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
    • A/T - Fault Code 48, TCC Solenoid
    • A/T - Hard Shifts/Leak at Torque Converter Seal
    • Key in Ignition Warning Chime - Continues to Sound
    • A/T - Poor Shift Quality
    • Fuel System - MIL ON, Tank Leakage Fault Codes
    • Seat Heater - Headlights Dim/Idle Fluctuations
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
    • Fuel System - Damage Caused By Fuel Contaminants
    • Battery - Discharges With Key Left In Ignition Switch
  • Driveability
    • Seat Heater - Headlights Dim/Idle Fluctuations
  • Erratic Shifting
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • False instrument warning light/gauges
    • Engine Controls - Temp Gauge Goes To Red/No Overheat
    • MIL ON - Poor Driveability/Multiple Misfire DTC's Set
  • Hard Shifting
    • A/T - Hard Shifts/Leak at Torque Converter Seal
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
    • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • Leaks
    • Fuel System - Evaporative System Vacuum Leak Diagnosis
    • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Low, Dead battery
    • Battery - Discharges With Key Left In Ignition Switch
  • No shift/Incorrect gear engagement
    • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • Noise
    • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
    • Key in Ignition Warning Chime - Continues to Sound
  • Poor performance
    • Seat Heater - Headlights Dim/Idle Fluctuations
  • Recalls
    • Recall - Engine Thermostat Inspection/Replacement
      • Overview
      • Owner Letter
    • Recall - Crankcase Ventilation Hose Replacement
• All Technical Service Bulletins
  • Emissions - Pressure Cont. Crankcase Ventilation Info.
  • Computer/Controls - Replacement DME Programming
  • Fuel System - Evaporative System Vacuum Leak Diagnosis
  • Computers, Controls - Programming VS Veh. Data Status
  • Fuel System - Fuel Tank Lock Ring Torque Spec Missing
  • Emissions System - Evaporative System Leak Testing
  • Compuetrs/Controls - Recommended Diagnostic Procedures
  • Fuel System - Alcohol Fuel Blend Usage
  • Fuel System - High Alcohol Fuel Detection
  • Fuel System - Fuel Cap Tether Is Broken Or Lost
  • Fuel System - MIL/Check Gas Cap Lamp ON
  • Progman(R) - Programming/Coding/Individualization
    • Overview
    • General_Rules_For_Programming
    • Procedure_A_Module_Replacement
    • Procedure_B_Software_Update
    • Procedure_C_Troubleshooting
      • Index
      • Introduction
      • Section I: Preparing A Progman Session
      • Section II: Progman Session Initialization
      • Section III: Before Programming/Coding
      • Section IV: After Programming Coding
      • Illustrations and Table
    • Procedure_E_Coding
  • A/T - Fault Code 002 and 003 Diagnosis
  • Engine Controls - Updated DISplus/GT1 Software
  • Computers/Controls - 'Retrofit' Update Programming
  • Engine Controls - Various Driveability Complaints
  • Engine Controls - Temp Gauge Goes To Red/No Overheat
  • Engine Controls - Progman(R) V22.1/V22.1.1 and V22.1.2
  • Engine Controls - False Maintenance Interval in Progman
  • Engine Controls - Progman(R) V21.0 Software Errors
  • DIS Schematic Information
    • Overview
    • Document Abbreviations
    • Colored Frames and Colored Window Headers
    • Printed Documents
    • Moving About the Schematic
  • Fuel Level Sender - Spanner
  • Spark Plug/Engine Oil Capacity Reference Chart
  • Spark Plug (HP Platinum) - Application Chart
  • Engine - MIL ON/Codes Set/Tapping/Rattling Noise
  • Recall - Engine Thermostat Inspection/Replacement
    • Overview
    • Owner Letter
  • A/T - Fault Code 48, TCC Solenoid
  • A/T - Hard Shifts/Leak at Torque Converter Seal
  • Engine Control Module - MS 43 Removal Precautions
  • Key in Ignition Warning Chime - Continues to Sound
  • A/T - Poor Shift Quality
  • MIL ON - Poor Driveability/Multiple Misfire DTC's Set
  • Fuel System - MIL ON, Tank Leakage Fault Codes
  • Catalytic Converter - Unnecessary Replacements
  • Check Engine Lamp ON/DTC's Stored
  • Instruments - New Fuel Level Sensor Testing Caution
  • Seat Heater - Headlights Dim/Idle Fluctuations
  • Service Information Ruling for OBD
  • Engine Controls/Emissions - OBD Readiness Code Setting
  • Special Tools - DSCIII Test Cable
  • Computers/Controls - Custom Configuration
  • A/T - Hard/No Shift Condition/DTC's Stored in TCM
  • Recall - Crankcase Ventilation Hose Replacement
  • A/T - Erratic Shifting/Trans Light ON/FC 60 Set
  • Tools - Tank Ventilation Leak Coupler
  • Fuel System - Damage Caused By Fuel Contaminants
  • Ignition System - Platinum Spark Plug Application Chart
  • Engine Controls - Progman(R) V21.01 and V21.02.01 Errors
  • Computers/Controls - Progman(R) V22.0/V22.0.1 Errors
  • Battery - Discharges With Key Left In Ignition Switch
  • Fuel System - TOP TIER Gasoline Usage Recommendations
  • Fuel System - Fuel Quality and Additive Information
  • Emissions - Evaporative Emissions System Testing
  • Computers/Controls - ISTA/D DTC S0001 After Quick Delete
  • Computers/Controls - ISTA Test Plan Priority Error Info.
  • Computers/Control - Loading/Activation Of Enabling Codes
  • Fuel System - BMW Group Fuel System Cleaner Plus Info.