Overhaul Procedure Steps

NOTE: This article lists the sequential steps necessary to overhaul the transmission.
^ For the specific step listed below, refer to that step under Repair Instructions. Repair Instructions
^ For the complete list of procedures, refer to "Repair Instruction". Repair Instructions




Overhaul Procedure:



[ ] Torque Converter Removal
[ ] Rear Adapter Case, Vehicle Speed Sensor Removal
[ ] Transmission Range Switch Removal
[ ] Oil Pump and Torque Converter Housing Removal
[ ] Overdrive Clutch Drum and Overdrive Case Removal

[ ] Fluid Pan, Filter Screen and Fluid Pipes Removal
[ ] Valve Bdy, Accums, Solenoid Wiring Harness Rem
[ ] Forward and Direct Clutch Assembly Removal
[ ] Parking Pawl and Manual Shift Linkage Removal
[ ] Center Support and Planetary Sun Gear Removal

[ ] Planetary Gears and Output Shaft Removal
[ ] Reverse Brake Piston Removal
[ ] Case Assembly Cleaning and Inspection
[ ] Oil Pump Overhaul
[ ] Overdrive Overhaul (Planetary Gear Side)

[ ] Overdrive Overhaul (Case Side)
[ ] Forward Clutch Overhaul
[ ] Direct Clutch Overhaul
[ ] Center Support Reconditioning Repair
[ ] Planetary Gears and Output Shaft Overhaul

[ ] Valve Body Removal
[ ] Front Upper Valve Body Disassemble
[ ] Front Upper Valve Body Assemble
[ ] Rear Upper Valve Body Disassemble
[ ] Rear Upper Valve Body Assemble

[ ] Lower Valve Body Disassemble
[ ] Lower Valve Body Assemble
[ ] Valve Body Installation
[ ] Reverse Brake Piston Installation
[ ] Planetary Gears and Output Shaft Installation

[ ] Center Support and Planetary Sun Gear Installation
[ ] Parking Pawl and Manual Shaft Linkage Installation
[ ] Forward and Direct Clutch Assembly Installation
[ ] Overdrive Clutch Drum, Overdrive Case Installation
[ ] Oil Pump and Torque Converter Housing Installation

[ ] Valve Bdy, Accums, Solenoid Wiring Harness Inst
[ ] Fluid Pan, Filter Screen, Fluid Pipes Installation
[ ] Rear Adapter Case, Vehicle Speed Sensor Install
[ ] Transmission Range Switch Installation
[ ] Torque Converter Inspection
[ ] Torque Converter Installation