Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Recall - Fuel Pump Module Seal and Lock Nut
- Recall 99V216000: Leak at Fuel Pump Module Attachment
- Recall - Bench Seat Attaching Bolts
- Recall - Integrated Child Seat Mount Bolts
- Recall 00V268000: Fuel Rail Cracks/Leaks
- Recall - Potential Fuel Rail Seal Leakage
- Recall 95V236000: Fuel Tank Rollover Valve Defect
- Recall - Filler Tube/Rollover Valve
- Recall - Passenger Air Bag Safety
- Campaign - Integrated Child Seats
- Recall - Child Seat Belt Extension
- Recall 98V185000: Difficulty Unlatching Child Restraint
- Recall 96V136000: Child Seat Module Mounting Bolts Break
- Recall 02V293000: Clockspring Assembly Replacement
- Recall - Clockspring Inspection/Replacement
- Recall - Fuel Filler Tube Ground Strap
- Recall - Running Board Tire Jack Extension
- Recall 96V002000: Fuel Filler Tube Design Improvement
- Recall 95I004000: Child Seat Assembly Revision
- Recall 97I001000: Proper Operation of Child Safety Seats
- Customer Interest
- Blower Motor - Whine in LOW or 2nd Speeds
- Front Blower Motor - Inoperative/Operates Erratically
- Power Steering - Honk Or Squeal Noise at Low Speed
- Belt Tensioner - Momentary Loss of Power Assist
- Rear Shock Absorber - Rattles on Bumps
- Underbody - Squeak/Buzz/Rattle
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Front Suspension - Knock/Squawk Sound
- Driver's Seat Lumbar Support - Additional Support
- Front Seat Assist Handle - Loose Or Pulled Out
- Front Door - Squeak or Creak Noise
- Steering Wheel - Click/Rattle Sound
- A/T - Shudders During Upshift With No DTC's Present
- A/T - Intermittent Powertrain Shudder
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Internal Damage
- A/T - Ratcheting Sound When Coming To Stop
- Steering Column - Clunk /Popping Noise
- Serpentine Belt - Loss of Power Steering Assist
- Rear Brakes - Moan/Howl Noise
- ABS - Hydraulic Unit Rumbles on Low Speed Stops
- Rear Brakes - Cyclic Rubbing Noise
- Knock Sensor - One Time Miss or Buck
- Radio - Poor AM Reception/Ignition Noise
- PCM/Crank Position Sensor - Driveability Concerns
- PCM - Engine Miss/Buck/Jerk/MIL ON
- PCM - Intermittent OBDII Faults/Driveability Concerns
- PCM - Low Speed Miss/Gear Hunting During Cruise
- PCM - Erroneous Misfire DTC
- I/M Testing - OBDII CARB Readiness Monitor Information
- Fuel Tank - Rough Idle/Hesitation/Sags After Fillup
- Fuel Tank/Gauge - Low Fill Capacity
- Fuel Tank - Thud or Thump Noise
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Sliding Door Power Locks - Intermittent Operation
- Windshield Wipers - Don't Park or Wipe on INTERMITTENT
- Front Wipers - Self Activate Or Won't Turn Off
- Front Wipers - Activate While Driving/Will Not Turn Off
- Evaporator Housing - Water Leaks Onto The Floor
- Auxiliary Rear Heater Line - Coolant Seepage
- Rear Heater Hose Connections - Coolant Seepage
- A/C Suction/Discharge Line - Cracking
- A/C Suction Line - Moan/Whine Noise
- Park Brake Cable - Rattle/Click Noise on Bumps
- Front Suspension - Knocking/Creaking on Deceleration
- Body - Dust Gets into Rear Interior of Vehicle
- Black Plastic Body Components - Chalky Residue
- B-Pillar - Tick Type Noise While Driving
- Roof Panel - Wavy/Has Depressions
- Suspension/Body - Strut Tower Corrosion
- Exhaust - Drone at 2500 to 2800 RPM
- Power Door Lock Motor - Whirling Noise
- Sliding Door Power Lock Actuator - Chatter Sound
- Sliding Door and Liftgate Power Lock Motor - Inoperative
- Steering Column - Pop/Tick From Steering Wheel Area
- Side Door - Difficult To Open From The Outside or Inside
- Sliding Door Latch Area - Dents From Inside
- Sliding Door - Paint Chipping
- Front Door Glass- Windnoise
- Sliding Door - Rattle Noise At B-Post Area
- Child Seat Shoulder Harness - Will Not Pull Out
- Wipers/Washers - Wipers Smear or Streak Windshield
- Cowl Grille/Outside Rear View Mirrors - Discolored
- Roof Rack - Rattles at Highway Speeds
- Liftgate to Rear Fascia - Gap Too Small
- Power Steering Line - Honk Noise At Low Speed
- Wheel Cover - Separates From Wheel
- A/T - Shudder/Bumps/Slippage
- Theft Alarm - Unexplained Activation/Dead Battery
- A/C Control Buttons or Knobs - Stick/Hard to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- A/T - Transaxle Limp In Condition
- Air Bags - Warning Lamp ON Intermittently/Constantly
- Power Vent Window Actuator Ball and Socket - Separates
- A/T - 41TE Goes into Limp Mode/DTC's Set
- Door Glass - Suction Cup Marks
- Roof Panel - Wavy or has Depressions
- Power Seat Track Cover - J Hook Disengages
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Speed Control - Does Not Maintain Speed on Grades
- Cowl Cover Ends - Unsnapped at Front Fenders
- A/C Evaporator - Emits Odors
- Quad Seat Easy Entry Latch - Rattles
- Rear Bench Seats - High Unlatching Effort
- Quad Seat Floor Latch - Loose/Rattles
- Rear Bench Seat To Floor Attachment - Rattle
- B Post Area - Rattle Noise
- Rear Suspension - Thumping Noise
- Right Side Quarter Trim Panel - Warm To Touch
- Interior Trim Panel - White Stress Marks
- Generals
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240496A - 12/20/96
- 235995 - 09/22/95
- 235495 - 08/18/95
- 23-28-96 - 05/03/96
- 211395 - 09/01/95
- 211196 - 07/19/96
- 21-18-96 - 12/27/96
- 19-07-96 - 12/20/96
- 084095 - 09/15/95
- 081597 - 04/04/97
- 051195 - 09/08/95
- 05-06-96A - 12/06/96
- 02-09-97 - 10/17/97
- Windows/Glass - Suction Cup Marks
- Power Vent Window Actuator Ball and Socket - Separate
- Windshield Wipers - Self-Activate While Driving
- Cruise Control - Erratic During Initial Speed Set
- Roof Panel - Wavy or Has Depressions
- B-Pillar - Ticking Noise When Driving
- Rear Bench Seats - Difficult To Unlatch
- Outside Rearview Mirror Glass - Replacement
- Outside Mirror - Glass Replacement
- Sliding Door - Difficult To Open From Outside
- Radio Transmitting Equipment - Installation
- Radio - Poor AM Reception
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Evaporator Housing - Water Leaks To The Interior
- Evaporator Housing - Water Leaks To Interior
- A/C Compressor - Bump on Engagement
- Suspension Cradle - Knocking/Creaking Sound
- Steering Gear - Honk Noise During Parking Lot Maneuvers
- Steering Gear - Honk/Moan/Groan At Low Speed
- Steering Wheel - Popping/Ticking Sound
- Electrical - Wire Splice Procedure Revision
- Rear Brakes - Howling/Moaning Noise
- Brakes - Snow/Water Ingestion Into Rear Drum
- Rear Brakes - Moaning Noise on Light Application
- Brakes - Rear Drum Brake Freezing/Water/Snow Ingestion
- Brake Drums (Rear) - Snow/Water Ingestion
- Rear Brake Drums - Freezing/Rusting
- Rear Brake Drum - Rusted/Frozen
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - Poor Shifting Quality
- A/T Pan Gasket - Reusable Design
- A/T - Intermittent MIL ON/DTC's Set/Shift Concerns
- TCM - Limp In Mode Tendency Reduction
- Fuel Tank - Reduced Capacity
- Fuel Tank - Reduced Capacities
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- PCM - Flash Programming Failure Recovery
- Suspension - Underbody Buzz/Rattle/Thumping
- Steering - Momentary Loss Of Power Assist
- Engine - Camshaft/Bearing Service
- Tires and Wheels - Low Speed Wobble
- A/T - Vehicle Shudder During TC Lock-up
- Wipers - Self Activate While Driving/Won't Turn Off
- A/C Suction/Discharge Line - Cracks
- A/C Suction/Discharge Line - Service Precautions
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Service Manual - Revisions/Updates
- Service Manual - Updates
- Service Manual - Revision
- Service Manual - Update
- Brakes - Noise Explanation
- Heating, A/C - Poor Performance Diagnosis
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Engine - Oil Leak Prevention/Diagnosis
- Engine/Electrical - Service Manual Revisions
- Recall - Fuel Pump Module Seal and Lock Nut
- Recall 99V216000: Leak at Fuel Pump Module Attachment
- Fuel/Steering/Suspension - Service Manual Revisions
- Blower Motor - Whine in LOW or 2nd Speeds
- Front Blower Motor - Inoperative/Operates Erratically
- Tie Rod - Intermittent Popping in Front End
- Power Steering - Honk Or Squeal Noise at Low Speed
- Engine - Camshaft/Bearing Inspection/Service
- Aluminum Engine - Gasket Surface Preparation
- Belt Tensioner - Momentary Loss of Power Assist
- A/C - Mode Door Actuator Removal Revisions
- Ball Joint Grease Fitting - Broken Appearance
- Rear Shock Absorber - Rattles on Bumps
- Underbody - Squeak/Buzz/Rattle
- Tire and Wheel - Runout
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Wheels and Tires - Low Speed Wobble
- Front Suspension - Knock/Squawk Sound
- Body - Sliding Door Lock/Latch Procedures Revisions
- Driver's Seat Lumbar Support - Additional Support
- Recall - Bench Seat Attaching Bolts
- Recall - Integrated Child Seat Mount Bolts
- Recall - Child Safety Seat
- Front Seat Assist Handle - Loose Or Pulled Out
- Front Door - Squeak or Creak Noise
- Steering Wheel - Click/Rattle Sound
- A/T - 41TE/42LE Shudder During EMCC Shift
- A/T - Shudders During Upshift With No DTC's Present
- A/T - Intermittent Powertrain Shudder
- Converter Clutch - Vehicle Shudder on Lock Up
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- A/T - Burned Fluid/Internal Damage
- A/T Oil Cooler Line Hose Clamp - Revised
- A/T - Ratcheting Sound When Coming To Stop
- Engine Controls/Emissions - Manual Revisions
- Steering Column - Clunk /Popping Noise
- CV Boot - Grease Seepage Explanation
- Serpentine Belt - Loss of Power Steering Assist
- Rear Brakes - Moan/Howl Noise
- ABS - Hydraulic Unit Rumbles on Low Speed Stops
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Brakes - Caliper Guide Pin Torque Update
- Rear Brakes - Cyclic Rubbing Noise
- Brakes/Steering - Lead Chart/Backing Plate Revisions
- Ignition Switch - Housing Service
- Knock Sensor - One Time Miss or Buck
- Radio - Poor AM Reception/Ignition Noise
- PCM/Crank Position Sensor - Driveability Concerns
- PCM - Engine Miss/Buck/Jerk/MIL ON
- PCM - Intermittent OBDII Faults/Driveability Concerns
- PCM - Low Speed Miss/Gear Hunting During Cruise
- PCM - Erroneous Misfire DTC
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Recall 00V268000: Fuel Rail Cracks/Leaks
- Recall - Potential Fuel Rail Seal Leakage
- Fuel Tank - Rough Idle/Hesitation/Sags After Fillup
- Fuel Tank/Gauge - Low Fill Capacity
- Recall 95V236000: Fuel Tank Rollover Valve Defect
- Fuel Tank - Thud or Thump Noise
- Recall - Filler Tube/Rollover Valve
- A/T - Shudder on 1 - 2/2 - 3 Upshift
- A/T - MIL ON/DTC's Set
- Sliding Door Power Locks - Intermittent Operation
- Radio Communication Equipment - Recommendations
- Airbag/Clock Spring - Service
- Lighting - Courtesy Lamp Test Revisions
- Ignition System - Secondary Ignition Test Revision
- Lighting - Headlamp/Park Lamp Diagnostics Revisions
- Windshield Wipers - Don't Park or Wipe on INTERMITTENT
- Front Wipers - Self Activate Or Won't Turn Off
- Front Wipers - Activate While Driving/Will Not Turn Off
- Evaporator Housing - Water Leaks Onto The Floor
- Recall - Radiator fan Relay
- Recall - Radiator Fan relay
- Radiator Fan Motor - Relay Operation
- Auxiliary Rear Heater Line - Coolant Seepage
- Rear Heater Hose Connections - Coolant Seepage
- A/C Suction/Discharge Line - Cracking
- A/C Suction/Discharge Line - Service
- A/C Suction Line - Moan/Whine Noise
- Park Brake Cable - Rattle/Click Noise on Bumps
- Brakes - Bendix ABX 4 ABS System Test Revisions
- Brakes - Teves ABS Diagnostics Revisions
- Front Suspension - Knocking/Creaking on Deceleration
- Body - Dust Gets into Rear Interior of Vehicle
- Black Plastic Body Components - Chalky Residue
- B-Pillar - Tick Type Noise While Driving
- Roof Panel - Wavy/Has Depressions
- Suspension/Body - Strut Tower Corrosion
- Recall - Passenger Air Bag Safety
- Airbag - NHTSA Authorized Deactivation
- Air Bag System - Test Revisions
- Vehicle Theft Security System - Discussion
- Leak Detection Pump - Monitor Test
- Emissions/Engine Controls - Service Manual Revisions
- Exhaust - Drone at 2500 to 2800 RPM
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Power Door Lock Motor - Whirling Noise
- Sliding Door Power Lock Actuator - Chatter Sound
- Sliding Door and Liftgate Power Lock Motor - Inoperative
- Wipers/Washers - Wiper System Test Revisions
- Steering Column - Pop/Tick From Steering Wheel Area
- Side Door - Difficult To Open From The Outside or Inside
- Sliding Door Latch Area - Dents From Inside
- Sliding Door - Paint Chipping
- Front Door Glass- Windnoise
- Sliding Door - Rattle Noise At B-Post Area
- Memory Power Seat - Travel Range
- Campaign - Integrated Child Seats
- Recall - Child Seat Belt Extension
- Recall 98V185000: Difficulty Unlatching Child Restraint
- Child Seat Shoulder Harness - Will Not Pull Out
- Wipers/Washers - Wipers Smear or Streak Windshield
- Cowl Grille/Outside Rear View Mirrors - Discolored
- Outside Rearview Mirror - Glass Replacement
- Roof Rack - Rattles at Highway Speeds
- Liftgate to Rear Fascia - Gap Too Small
- Body Side Moldings and Cladding - Redesigned
- Engine - Coolant Recommendations
- Power Steering Line - Honk Noise At Low Speed
- Wheel Cover - Separates From Wheel
- A/T - Shudder/Bumps/Slippage
- A/T - Intermittent 2nd Gear and Reverse Only After Start
- A/T - (41TE/42LE) Service Information
- A/T - 41TE/42LE Cruise Control Interaction
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Theft Alarm - Unexplained Activation/Dead Battery
- Transmission Range Sensor - Production Change
- Transaxle Range Sensor - Service Information
- A/C Control Buttons or Knobs - Stick/Hard to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- A/T - Transaxle Limp In Condition
- Recall 96V136000: Child Seat Module Mounting Bolts Break
- Ignition Off Draw Fuse - Installation Precautions
- Air Bags - Warning Lamp ON Intermittently/Constantly
- Recall 02V293000: Clockspring Assembly Replacement
- Recall - Clockspring Inspection/Replacement
- PDC Cover - Installation Precautions
- Wiring - Revised Splicing Procedure
- Recall - Fuel Filler Tube Ground Strap
- Recall - Running Board Tire Jack Extension
- Keyless Entry - Test Procedure Revision
- Power Vent Window Actuator Ball and Socket - Separates
- A/T - 41TE Goes into Limp Mode/DTC's Set
- Door Glass - Suction Cup Marks
- Windows - Interior Film Build Up
- Roof Panel - Wavy or has Depressions
- RAS Radio Cassette - Auto Load Error
- Recall 96V002000: Fuel Filler Tube Design Improvement
- Power Seat Track Cover - J Hook Disengages
- Accumulator - Intermittent DTC's 36, 52, or 54 Set
- Speed Control - Does Not Maintain Speed on Grades
- Cowl Cover Ends - Unsnapped at Front Fenders
- A/C Evaporator - Emits Odors
- Steering - Power Steering Fluid Usage
- Quad Seat Easy Entry Latch - Rattles
- Rear Bench Seats - High Unlatching Effort
- Quad Seat Floor Latch - Loose/Rattles
- Rear Bench Seat To Floor Attachment - Rattle
- B Post Area - Rattle Noise
- Rear Suspension - Thumping Noise
- Engine - High Driveability Index Fuels
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Right Side Quarter Trim Panel - Warm To Touch
- Interior Trim Panel - White Stress Marks
- Recall 95I004000: Child Seat Assembly Revision
- Recall 97I001000: Proper Operation of Child Safety Seats
- A/T Pan Gasket - Reusable Design/Installation
- Brakes - Rear Brake Drum Freezing/Water/Snow Ingestion
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Recall - Replace Mopar(R) Value Line Catalytic Converter
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process