Operation CHARM: Car repair manuals for everyone.

A/C - Water Leaks Onto Passenger Front Floor

NUMBER: 23-010-04 REV. A

GROUP: Body

DATE: September 9, 2004

THIS BULLETIN SUPERSEDES TECHNICAL SERVICE BULLETIN 23-010-04, DATED APRIL 29, 2004, WHICH SHOULD BE REMOVED FROM YOUR FILES. ALL REVISIONS ARE HIGHLIGHTED WITH **ASTERISKS** AND INCLUDES ADDITIONAL MODELS AND REVISED LABOR OPERATIONS.

SUBJECT:
Passenger Compartment Floor Water Leak

OVERVIEW:
This bulletin involves sealing the opening for the evaporator hose/drain tube with RTV sealer.

MODELS:

2001-2004 (AN) Dakota

**2004 - 2005 (CS) Pacifica**

2001 - 2003 (DN) Durango

**2002 - 2005 (KJ) Cherokee (International Markets)**

2001 - 2004 (RS) Caravan, Voyager, Town & Country

NOTE:
**This bulletin applies to KJ vehicles that are Right Hand Drive (RHD).**

SYMPTOM/CONDITION:

Water may enter the passenger compartment between the HVAC housing and the bulkhead. A foam seal is used to seal the heater housing to the bulkhead. Condensation from the A/C evaporator can run along the evaporator drain tube and enter the passenger compartment if the seal between the HVAC housing and the bulkhead is not sealed properly. This will result in wet passenger compartment carpet when the air conditioning is operating.

DIAGNOSIS:

If the symptom exists, perform the Repair Procedure.





PARTS REQUIRED:

REPAIR PROCEDURE:

Locate the evaporator hose and drain tube opening in bulkhead at the rear of the engine compartment. Apply a bead of RTV sealer, p/n 04467708 or equivalent, to the perimeter of the opening to seal the joint between the bulkhead and the HVAC gasket and the joint between the drain tube and the HVAC gasket.





TIME ALLOWANCE:





FAILURE CODE:

Disclaimer:
This bulletin is supplied as technical information only and is not an authorization for repair.