Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Emissions
    • Recall - Reprogram PCM for Emissions
      • Overview
      • Service Procedure
        • A. Reprogram the PCM (DR, KJ PT, TJ, PL Models)
        • B. Reprogram the PCM (ND and Wk Models)
          • Information
          • Method I
          • Method II
        • C. Install the Authorized Modifications Label
        • D. Complete Proof of Correction Form For California Residents
      • Owner Letter
  • Safety
    • Canada - Recall - G01 Fixed Rear Quarter Glass
    • Recall - Power Steering Pressure Hose Replacement
      • Overview
      • Service Procedure
        • A. Inspect Power Steering Pressure Hose
        • B. Replace the Power Steering Pressure Hose
      • Owner Letter
    • Recall 07V149000: Possible Quarter Glass Separation
• Customer Interest
  • Body - Light To Moderate Paint Imperfections
  • Engine Controls - Idle Fluctuation/MIL ON/Misfire Codes
  • Electrical - Power Windows/Convertible Top Inop
  • Body/Interior - Headliner Loose From Backlite Frame
  • Engine Controls - MIL ON/DTC P0339 Stored
  • Lighting - Condensation in Headlamps
  • Body - Circular/Ring Marks on Glass
  • Body - Window Frozen to Beltline Weatherstrip
  • Body - Wind Noise/Whistle From Side Window Area
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • M/T - Gear Rattle at Idle
  • Audio System - Satellite Radio Static
  • A/C - Musty Odors When Hot/Humid
    • Overview
    • AB/CS/LX/RS/WK/XK Vehicle Procedure
    • AN/DN/DR/HB/JR/KJ/LH/ND/PL/PT/TJ/WG/WJ Vehicles Procedure
    • ST Vehicle Procedure
    • VA Vehicle Procedure
  • Engine Controls - Various Driveability Concerns
  • Engine Controls - MIL ON DTC P2074 Set/Driveability
  • Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
  • A/T - MIL ON, DTC P1776 Set
  • Engine Controls - MIL ON, DTC P0128 Stored in Memory
• Superceded Bulletins
  • 21-013-11 - 12/22/11
  • 09-001-05 - 03/25/05
  • Electrical - Power Windows/Convertible Top Inop.
  • Interior - Low Gloss Interior Trim Care
  • Cell Phone - Hands-Free Phone Inoperative
  • Steering - Revised Power Steering Bleeding Procedure
  • M/T - Diagnostic Tear Down Procedure
  • A/T - Diagnostic Teardown Procedures
  • A/T - Diagnostic Tear-Down Procedure
  • Automatic Transmission - Diagnostic Teardown Procedure
  • A/T - MIL ON/DTC P1776 Set
  • Engine Control - Generic PCM Programming Procedure
  • A/T - MIL ON/DTC P1776 (Solenoid Switch Valve)
  • Engine Controls - Generic PCM Programming
  • Engine Controls - Programming a Generic PCM
  • Engine Controls - PCM Initialization After Replacement
  • Engine Controls - PCM Initialization Procedure
  • Engine Controls - MIL ON/DTC P0128 Set
  • A/C - Musty Odors When Hot or Humid
  • Air Bag System Passenger Air Bag Deactivation
  • Maintenance - Fluid Flushing Recommendations
• All Technical Service Bulletins
  • Body - Replacement Underbody Coating Materials
  • Canada - Recall - G01 Fixed Rear Quarter Glass
  • Body/Frame - Welded Sheet Metal Repairs And Replacements
  • Body - Don't Apply Corrosion Protection On Plastic Panels
  • Body - Front Bumper Fascia Repair For License Bracket Holes
  • M/T - Diagnostic Teardown Procedure
  • Wheels/Tires - Chrome Clad Wheel Balancing Info.
  • Collision - Safety Cert./Tire Press. Label Replacement
  • Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
  • Body - Light To Moderate Paint Imperfections
  • Wheels - Reconditioned Wheel Usage
  • Restraints - Replacement Seat Covers/Seat Cover Repairs
  • Restraints - Use Of Salvaged Restraint System Components
  • Body/Frame - Structural Repair Components
  • Body/Frame - Usage Of Heat For Repair
  • Engine Controls - Idle Fluctuation/MIL ON/Misfire Codes
  • Engine - Cylinder Head Bolt Re-Torque Procedure
  • Wheels - Caring for Chrome Wheels
  • Electrical - Power Windows/Convertible Top Inop
  • Body/Interior - Headliner Loose From Backlite Frame
  • Recall - Reprogram PCM for Emissions
    • Overview
    • Service Procedure
      • A. Reprogram the PCM (DR, KJ PT, TJ, PL Models)
      • B. Reprogram the PCM (ND and Wk Models)
        • Information
        • Method I
        • Method II
      • C. Install the Authorized Modifications Label
      • D. Complete Proof of Correction Form For California Residents
    • Owner Letter
  • Engine Controls - MIL ON/DTC P0339 Stored
  • Engine Controls - Flash Programming Failure Recovery
    • Overview
    • Connected/Disconnected Flash Mode Using TechCONNECT
    • Pay Attention While Performing Flash Reprogram Procedures
    • Error Messages
    • Enhanced and Original Abort Recovery
    • Enhanced Abort Recovery Screens
    • Original Abort Recovery Screen
    • Programmable Modules
    • Powertrain Modules - Engine and Transmission
  • Audio System - Revised Antenna Mast Installation
  • Cell Phone - UConnect(R) Hands Free Phone Inoperative
  • Restraint System - Proper Seat Belt Routing And Twist
  • Lighting - Condensation in Headlamps
  • Safety Systems - Inadvertent Damage/Disabling
  • Electrical - Radio Equipment Installation Recommendation
  • Engine Controls - Co-Pilot Support/Correct Cable Usage
  • Body - Circular/Ring Marks on Glass
  • Body - Window Frozen to Beltline Weatherstrip
  • Body - Wind Noise/Whistle From Side Window Area
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • Engine - Oil Quality/Viscosity Requirements
  • Recall - Power Steering Pressure Hose Replacement
    • Overview
    • Service Procedure
      • A. Inspect Power Steering Pressure Hose
      • B. Replace the Power Steering Pressure Hose
    • Owner Letter
  • A/T - ATF+4 Fluid Usage/Applications
  • Accessories - MOPAR(R) Remote Starter Inoperative
  • M/T - Gear Rattle at Idle
  • Power Steering - Additive Prohibition
  • Body - Convertible Top Boot Has White Blotches
  • Steering - Revised Power Steering Bleeding
  • Audio System - Satellite Radio Static
  • A/C - Musty Odors When Hot/Humid
    • Overview
    • AB/CS/LX/RS/WK/XK Vehicle Procedure
    • AN/DN/DR/HB/JR/KJ/LH/ND/PL/PT/TJ/WG/WJ Vehicles Procedure
    • ST Vehicle Procedure
    • VA Vehicle Procedure
  • Engine Control - PCM Initialization Procedure
  • Engine Controls - Various Driveability Concerns
  • Engine Controls - Programming Generic PCMs
  • Air Bag System - Passenger Air Bag Deactivation
  • Recall 07V149000: Possible Quarter Glass Separation
  • A/T - ATF + 4 Fluid Usage
  • Interior - Low Gloss Interior Trim Care Information
  • Engine Controls - MIL ON DTC P2074 Set/Driveability
  • Brakes - Parking Brake Adjustment Service Intervals
  • A/T - Repair/Replacement Guidelines
    • Overview
    • Repair Procedure
      • Information
      • 40TE, 41TE/AE, 42LE/RLE and 62TE Transmissions
      • 30RH, 30TH, 31TH, 32RH, 36RH, 42RE/RH, 46RE/RH, 47RE and 48RE
      • 45RFE/545RFE and 68RFE Transmissions
      • NAG1 Transmissions
  • Maintenance - Fluid Flushing Information
  • Wheels/Tires - Chrome Clad Wheel Balancing Information
  • Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
  • Body - Paint Overspray Removal Procedures
  • A/T - MIL ON, DTC P1776 Set
  • Engine Controls - MIL ON, DTC P0128 Stored in Memory
  • Paint - Clearcoat Blending During Refinish Process