Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Body/Frame - Vehicle Vibration Or Shaking
- Body - Light To Moderate Paint Imperfections
- Engine - MIL ON/Misfire/Stumble
- Engine Controls - No Start or Hard Start Condition
- Brakes - Squeal/Squeak Driving in Reverse
- Suspension - Front Strut Squeaking/Squawking Sound
- Suspension - Front Suspension Rattling Noise
- Steering - In and Out Steering Column Movement
- Drivetrain - Power Transfer Unit (PTU) Pop/Click Sound
- A/T/Engine Controls - False Solenoid DTC's Set
- A/T - Delayed Gear Engagement/Possible DTC's
- Instruments - Erroneous Tire Pressure Warning Lamp
- Engine Controls - Premature A/T Overdrive Clutch Wear
- A/T - Harsh 4th to 3rd Gear Downshifts
- Engine Controls - Long Crank/No Start/MIL ON/DTC's
- Engine Control - MIL ON, P2097 and EVAP Monitor Defect
- Engine Controls - MIL ON/DTC P2066 Set
- Electrical - Driver's Door Switches Inoperative
- Entertainment Devices - Crackling Noise From Tweeters
- Interior - Front Seat Belts Emit Foul Odors
- Body/Frame - Water Leaks Into Passenger Compartment
- Steering - Steering Wheel Tilt Mechanism Inoperative
- Wipers/Washers - Wipers Smear or Streak Windshield
- Engine - Cold Start Ticking Noise
- Brakes - Brake Pedal Squeaking/Creaking Sound
- Engine - Accessory Drive Belt Chirping/Squeaking Noise
- Engine - Accessory Drive Belt Shield Missing
- Suspension - Low Speed Rattle/Clunk Noise
- A/C - Intermittent Loss of A/C/Heater Display
- Interior - Dip/Sag in Center of Instrument Panel
- A/C - Water Leaks Onto Passenger Front Floor
- Interior - Hole In Back of Seat Trim Panel
- Body - Door Belt Molding Misaligned
- Entertainment System - Crackling Noise From Headphones
- Instruments - Fuel Gauge Fluctuation
- Body - Front/Rear Rattle Sound at 45-70 MPH
- A/C - Musty Odors When Hot/Humid
- Engine - Rough Idle/MIL ON/P0300 DTC Set
- Drivetrain - Clicking/Popping From Front Hub/Half Shaft
- A/C - Water leaks Under Passenger Side Carpet
- Fuel System - Throttle Body Cleaning Procedure
- Body - Upper Applique Loose Above Left Front Door
- Interior - Rattle/Buzz From Doors With Audio ON
- Electrical - Right Front Door Switches Inoperative
- Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
- Steering - Steering Column Knocking Noises
- Body/Frame - Vibration/Shake While Driving
- A/T - MIL ON, DTC P1776 Set
- Superceded Bulletins
- 18-007-03B - 07/25/03
- 18-007-03A - 07/04/03
- 18-007-03 - 03/14/03
- Body - Rattle Noise From Front/Rear
- Interior - Power/Memory/Heated Seat Inoperative
- Interior - Seat Heater Control Module Availability
- Body - Fender/Splash Shield Rattles
- Electrical - Memory Seats/Pedals Erratic/Inoperative
- Electrical - Memory Seat/Seat Heater/Adj. Pedals Inop.
- Interior - Foul Odor From Front Seat Belts
- Steering/Susp./Frame - Vibration/Shake While Driving
- Suspension - Front Suspension Muffled Rattling Noise
- Steering - Revised Power Steering Bleeding Procedure
- Electrical - Memory/Heated Seats/Adjustable Pedals Inop.
- Drivetrain - Power Transfer Unit (PTU) Clicking/Popping
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T - MIL ON/DTC P1776 Set
- A/T - Delayed Engagement
- A/T - Delayed Gear Engagement
- A/T - Harsh 4th to 3rd Gear Downshift
- Engine Control - Generic PCM Programming Procedure
- A/T - MIL ON/DTC P1776 (Solenoid Switch Valve)
- Engine Controls - Generic PCM Programming
- Engine Controls - Generic PCM Programming Procedures
- Engine Controls - Generic PCM Programming Procedure
- A/T - Delayed Gear Engagement/DTC's Set
- Engine Controls - Co-Pilot Support/Cable Selection
- Engine Controls - PCM Initialization Procedure
- Engine Controls - PCM Initialization After Replacement
- Engine Controls - Programming a Generic PCM
- Engine Controls - Hard or No Start Condition
- Engine - Rough Idle/Multiple Cylinder Misfire
- Engine - Cold Start Short Duration Ticking Noise
- A/C - Musty Odors When Hot or Humid
- Engine - Drive Belt Squeaking/Chirping Noise
- Wheels - Chrome Wheel Care
- Drivetrain - Front Hub Snapping/Popping/Clicking
- Engine - Accessory Drive Belt Chirping Noise
- Drivetrain - Font Hub/Half Shaft Pop/Click Noise
- A/T - ATF Usage List
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Body/Frame - Vehicle Vibration Or Shaking
- Wheels/Tires - Chrome Clad Wheel Balancing Info.
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Body - Light To Moderate Paint Imperfections
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- A/C - System Sealer Usage Prohibition
- Engine - MIL ON/Misfire/Stumble
- Engine Controls - No Start or Hard Start Condition
- Brakes - Squeal/Squeak Driving in Reverse
- Suspension - Front Strut Squeaking/Squawking Sound
- Wheels - Caring for Chrome Wheels
- Tires - Vibration/Shake at Highway Speeds
- Suspension - Front Suspension Rattling Noise
- Steering - In and Out Steering Column Movement
- Drivetrain - Power Transfer Unit (PTU) Pop/Click Sound
- A/T/Engine Controls - False Solenoid DTC's Set
- A/T - Delayed Gear Engagement/Possible DTC's
- Campaign - PCM Connector Seals
- Instruments - Erroneous Tire Pressure Warning Lamp
- Engine Controls - Premature A/T Overdrive Clutch Wear
- A/T - Harsh 4th to 3rd Gear Downshifts
- Engine Controls - Long Crank/No Start/MIL ON/DTC's
- Engine Control - MIL ON, P2097 and EVAP Monitor Defect
- Recall - PCM Reprogramming for Engine Stalling
- Recall 04V113000: Engine Stalling Hazard
- Engine Controls - MIL ON/DTC P2066 Set
- Engine Controls - Flash Programming Failure Recovery
- Recall 03V471000: Fuel Line Retention Clip Installation
- Electrical - Driver's Door Switches Inoperative
- Entertainment Devices - Crackling Noise From Tweeters
- Interior - Front Seat Belts Emit Foul Odors
- Safety Systems - Inadvertent Damage/Disabling
- Body/Frame - Water Leaks Into Passenger Compartment
- Electrical - Radio Equipment Installation Recommendation
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Steering - Steering Wheel Tilt Mechanism Inoperative
- Body - Front Door Glass Service Procedure Revision
- Campaign - Seat Control Module/Drivers Door Handle
- Wipers/Washers - Wipers Smear or Streak Windshield
- Engine - Cold Start Ticking Noise
- Brakes - Brake Pedal Squeaking/Creaking Sound
- Engine - Accessory Drive Belt Chirping/Squeaking Noise
- Engine - Accessory Drive Belt Shield Missing
- A/T - ATF+4 Fluid Usage/Applications
- Suspension - Low Speed Rattle/Clunk Noise
- A/C - Intermittent Loss of A/C/Heater Display
- Electrical - IOD Fuse and Electrical System Information
- Interior - Dip/Sag in Center of Instrument Panel
- Suspension - Towing/Lifting Damage Precautions
- Accessories - MOPAR(R) Remote Starter Inoperative
- A/C - Water Leaks Onto Passenger Front Floor
- Steering - Power Steering Fluid Usage
- Power Steering - Additive Prohibition
- Interior - Hole In Back of Seat Trim Panel
- Body - Door Belt Molding Misaligned
- Entertainment System - Crackling Noise From Headphones
- Steering - Revised Power Steering Bleeding
- Drivetrain - Rear Axle Oil Seepage Diagnosis
- Instruments - Fuel Gauge Fluctuation
- Body - Front/Rear Rattle Sound at 45-70 MPH
- A/C - Musty Odors When Hot/Humid
- Engine - Rough Idle/MIL ON/P0300 DTC Set
- Engine Control - PCM Initialization Procedure
- Drivetrain - Clicking/Popping From Front Hub/Half Shaft
- A/C - Water leaks Under Passenger Side Carpet
- Engine Controls - Programming Generic PCMs
- Fuel System - Throttle Body Cleaning Procedure
- Body - Upper Applique Loose Above Left Front Door
- A/T - ATF + 4 Fluid Usage
- Interior - Rattle/Buzz From Doors With Audio ON
- Lighting - Color/Brightness Difference Between Headlamps
- Electrical - Memory Systems Diagnostics
- Electrical - Right Front Door Switches Inoperative
- A/T - Repair/Replacement Guidelines
- Wheels/Tires - Chrome Clad Wheel Balancing Information
- Fuel System - Difficult Fuel Fill/Nozzle Shuts Off
- Steering - Steering Column Knocking Noises
- Body/Frame - Vibration/Shake While Driving
- Body - Paint Overspray Removal Procedures
- A/T - MIL ON, DTC P1776 Set
- Paint - Clearcoat Blending During Refinish Process