Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall 95I001004: Liftgate Latch Defect
- Recall 95I001008: Liftgate Latch Defect
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Recall 85V164000: Sunscreen/Rearview Mirrors Required
- Recall 85V053000: Proportioning Valve Malfunction
- Customer Interest
- Engine - Hard Cold Start/Rough Idle/Hesitation
- Fuel Pump/Filter - Sag On Long Left Hand Turns
- Fuel System - Vapor Lock/Fuel Foaming
- Thermal Check Valve - Lack of Engine Power
- A/C Compressor Clutch - Repeat Failures
- Exhaust Manifold/Flex Joint - Squeak Noise
- Window Regulator - Inoperative
- Distributor - Cold Engine Sag on Acceleration
- Distributor - Cold Drive Sag On During Acceleration
- Carburetor - Lack of Power In Cold Weather
- Carburetor - Sags/Poor Hot Start Performance
- Fuel System - Engine Sags/Poor Performance
- Fuel System - Engine Sag/Poor Performance
- Fuel Hose - Restriction at Medium/Wide Open Throttle
- Fuel Tank - Gurgling Noises
- Low Speed Surge/Rough A/C Idle
- Emission Test - 2,500Rpm High CO Reading
- Seat Belt Anti-Rotation Tab - Modification
- A/T/M/T - Oil Leak at Speedometer Cable and Adapter
- Front Sway Bar - Squeak/Squawk Noises
- Engine - Lack of Power After Highway Travel
- Liftgate - Creaking When Closing
- Wipers/Washers - Wipers Smear or Streak Windshield
- Folding Arm Rest - Loose/Shakes
- Engine Mount - Drive Gear Whine
- M/T Shifter - Loose/Inoperative
- A/C, Heater - Temperature Lever Difficult to Move
- High "CO" At 2500 RPM Emission Test, Air Bleed Jet
- Lower Instrument Panel - Cracking
- Remote Quarter Window - Inoperative
- Gear Shift Indicator - Misaligned
- M/T Shift Cable - High Shift Effort
- Dash Panel - Cracking Noise
- A/T - High Effort Is Required to Disengage Park
- M/T - Hard Shifting Into and Out of 5TH Gear
- Front Door Upper Glass Run - Distorted/Wavy
- Superceded Bulletins
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Technical Service Bulletins - New Driveability Group
- Service Manual - Revision, Lubrication/Maintenance
- A/C - R-12 to R-134a Conversion Procedure
- Flooded Engine - Service Precautions
- Engine - Hard Cold Start/Rough Idle/Hesitation
- Fuel Pump/Filter - Sag On Long Left Hand Turns
- Fuel System - Vapor Lock/Fuel Foaming
- Thermal Check Valve - Lack of Engine Power
- A/C Compressor Clutch - Repeat Failures
- Cylinder Head and Block - Resurface Limits
- Exhaust Manifold/Flex Joint - Squeak Noise
- Window Regulator - Inoperative
- Upholstery - Cleaning Procedure
- Steering Column - Usage/Identification
- A/T Oil Pan - Fluid Leaks at Pan Bolts
- Torque Converter - Replacement Conditions
- Clutch Splines and Pilot Bushing - Lubrication
- Throttle Pressure Cable - `Quick Adjust' Feature
- Battery and Charging System - General Information
- Battery - New State of Charge Indicator
- Distributor - Cold Engine Sag on Acceleration
- Distributor - Cold Drive Sag On During Acceleration
- Carburetor - Lack of Power In Cold Weather
- Carburetor - Sags/Poor Hot Start Performance
- Fuel System - Engine Sags/Poor Performance
- Fuel System - Engine Sag/Poor Performance
- Fuel Hose - Restriction at Medium/Wide Open Throttle
- Fuel Tank - Gurgling Noises
- Low Speed Surge/Rough A/C Idle
- Emission Test - 2,500Rpm High CO Reading
- Radio/Clock - Defeat Function Explanation
- Seat Belt Anti-Rotation Tab - Modification
- Rear Seat Shoulder Belt - Retrofit Kits
- A/T/M/T - Oil Leak at Speedometer Cable and Adapter
- Front Sway Bar - Squeak/Squawk Noises
- Fails State I/M "CO" Emission Test
- Engine - Lack of Power After Highway Travel
- Recall 95I001004: Liftgate Latch Defect
- Recall 95I001008: Liftgate Latch Defect
- Liftgate - Creaking When Closing
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Wipers/Washers - Wipers Smear or Streak Windshield
- Recall 85V164000: Sunscreen/Rearview Mirrors Required
- Folding Arm Rest - Loose/Shakes
- Engine - Oil Application
- Engine Oil - New `SG' Level Oil
- Engine Coolant - Recycling Recommendations
- Engine Mount - Drive Gear Whine
- A/T - 404/413/415/470 Changes For 1986
- A/T - FWD Drive Gear Whine Noise at 40-50 MPH
- A/T - 404, 413, 470 Ring and Transfer Shaft Gears
- A/T - FWD Hard to Pull Out of Park
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Fluid Recommendation
- A/T - Shim Kits for Bearing Pre-Load Setting
- A/T - Pressure Tap Locations
- A/T - Engine Centering Procedure
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T Shifter - Loose/Inoperative
- Automatic Transmission - New Fluid Type
- A/C, Heater - Temperature Lever Difficult to Move
- High "CO" At 2500 RPM Emission Test, Air Bleed Jet
- Lower Instrument Panel - Cracking
- Jet Valve - Adjustment Specification, Manual Revision
- Leaded Fuel - Usage in Overseas Operation
- Remote Quarter Window - Inoperative
- Paint - Codes/Cross References/Applications
- Paint - Variance Program
- High Altitude Conversion Package
- Overview
- 1985 2.2L-2V Light Duty Trucks All Models With Federal Emissions Package (49 States) Dodge Ram Van, Dodge Caravan, Plymouth Voy
- 1985 2.2L-2V Light Duty Truck Dodge Ram Van, Dodge Caravan & Plymouth Voyager Only Equipped With "50 States" Emission Package
- 1985 2.6L-2V Light Duty Truck All Models With Federal Emissions Package (49 States)
- 1985 3.7L-1V Light Duty Trucks All Models With Federal Emission Package (49 States)
- 1985 5.2L-2V Light Duty Trucks All Models With "50 States" Emissions Packages
- 1985 5.2L-2V Light Duty Trucks All Models With Federal Emissions Package (49 States)
- 5.9L-4V Light Duty Trucks All Automatic Models With Federal Emissions Package
- 5.9L-4V Light Duty Trucks All Manual Models With Federal Emission Package
- Gear Shift Indicator - Misaligned
- Trailer Tow Wiring/Components - Installation Cautions
- Front Shock Tower - Metal Screws/Bolts Precautions
- M/T Shift Cable - High Shift Effort
- Dash Panel - Cracking Noise
- A/T - High Effort Is Required to Disengage Park
- M/T - Hard Shifting Into and Out of 5TH Gear
- Front Door Upper Glass Run - Distorted/Wavy
- Recall 85V053000: Proportioning Valve Malfunction
- Propane Idle Adjustment - Determination Guidelines
- Fuel - Alcohol Fuel Recommendations
- Rear Wheel Alignment - Specifications Revision
- Wheel Alignment - Specifications
- Front End Alignment Specifications - Manual Revision
- Seat Belt Extender - Information
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process