Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- TPS - MIL ON/Erratic Idle/Acceleration Sag
- Engine - Hard Cold Start/Rough Idle/Hesitation
- Fuel Pump/Filter - Sag On Long Left Hand Turns
- Fuel System - Vapor Lock/Fuel Foaming
- Fuel System - Vapor Lock/ Fuel Foaming
- Air Injection System - Backfire on Deceleration
- A/C Compressor Clutch - Repeat Failures
- Timing Belt - poor Performance/No Start When Cold
- Exhaust Flex Joint - Leakage/Noise
- Window Regulator - Inoperative
- Clutch - Gear rattle in Neutral
- Engine - Hard Start/Rough Idle
- ECM - Poor Driveability Above 3,000 Foot Elevation
- ECM - No Start or Hard Start
- Radio - Rapid Crackling Noise in FM Mode
- Carburetor - Choke Blades Sticking/Binding
- Carburetor - Air Intake System Icing
- Engine - Sag On Hard Left Hand Turns
- Air Filter Box - Oil Contamination
- Engine - Driveway Die Outs/Cold Start Up
- EVAP Canister - Fuel Vapor Odors
- Seat Belt Anti-Rotation Tab - Modification
- A/T/M/T - Oil Leak at Speedometer Cable and Adapter
- Front Sway Bar - Squeak/Squawk Noises
- Carburetor - Off Idle Wide Open Throttle Hesitation
- Liftgate - Creaking When Closing
- Wipers/Washers - Wipers Smear or Streak Windshield
- Folding Arm Rest - Loose/Shakes
- Engine Mount - Drive Gear Whine
- M/T Shifter - Loose/Inoperative
- A/C, Heater - Temperature Lever Difficult to Move
- Lower Instrument Panel - Cracking
- Rough Cold Idle/ Cold Driveway Die Out
- Remote Quarter Window - Inoperative
- Gear Shift Indicator - Misaligned
- M/T Shift Cable - High Shift Effort
- Dash Panel - Cracking Noise
- A/T - High Effort Is Required to Disengage Park
- Carburetor - Long Cold Engine Crank Times
- M/T - Hard Shifting Into and Out of 5TH Gear
- Front Door Upper Glass Run - Distorted/Wavy
- Superceded Bulletins
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Technical Service Bulletins - New Driveability Group
- Service Manual - Revision, Lubrication/Maintenance
- A/C - R-12 to R-134a Conversion Procedure
- Flooded Engine - Service Precautions
- TPS - MIL ON/Erratic Idle/Acceleration Sag
- Engine - Hard Cold Start/Rough Idle/Hesitation
- Fuel Pump/Filter - Sag On Long Left Hand Turns
- Fuel System - Vapor Lock/Fuel Foaming
- Fuel System - Vapor Lock/ Fuel Foaming
- Air Injection System - Backfire on Deceleration
- A/C Compressor Clutch - Repeat Failures
- Connecting Rod - Production Change
- Timing Belt - poor Performance/No Start When Cold
- Exhaust Flex Joint - Leakage/Noise
- Window Regulator - Inoperative
- Upholstery - Cleaning Procedure
- Steering Column - Usage/Identification
- Clutch - Gear rattle in Neutral
- A/T Oil Pan - Fluid Leaks at Pan Bolts
- Torque Converter - Replacement Conditions
- Clutch Splines and Pilot Bushing - Lubrication
- Throttle Pressure Cable - `Quick Adjust' Feature
- Engine - Hard Start/Rough Idle
- ECM - Poor Driveability Above 3,000 Foot Elevation
- ECM - No Start or Hard Start
- Battery - New State of Charge Indicator
- Radio - Rapid Crackling Noise in FM Mode
- Carburetor - Choke Blades Sticking/Binding
- Carburetor - Air Intake System Icing
- Recall 84V150000: Fuel Line Crack At Fuel Pump
- Engine - Sag On Hard Left Hand Turns
- Air Filter Box - Oil Contamination
- Engine - Driveway Die Outs/Cold Start Up
- EVAP Canister - Fuel Vapor Odors
- Radio/Clock - Defeat Function Explanation
- Seat Belt Anti-Rotation Tab - Modification
- Rear Seat Shoulder Belt - Retrofit Kits
- Engine - Oil Filter Application
- Diagnostic Test Procedure - Page Revisions
- Overview
- Test 1-Step A-Checking System For Fault Codes
- Test 2-Step A-Checking O2 Solenoid Circuit (Code 11)
- Test 2-Step B-Checking O2 Solenoid Control Circuit
- Test 7-Step C-Checking Coolant Sensor Circuit to Computer
- Test 8-Step A-Checking Speed Sensor Circuit (Code 28)
- Test 8-Step B-Checking the Speed Sensor Circuit
- Test 8-Step C-Checking Speed Sensor Wire to Computer
- Test 11-Step A-Checking Choke Vacuum Kick
- Test 12-Step A-Checking Heated Air Intake System
- Test 13-Step A-Checking Engine Coolant Sensor Calibration (1.6)
- Test 13-Step B-Checking Engine Coolant Sensor Calibration (2.2)
- Test 28-Step A-Checking Computer Controlled Components
- Test 28-Step B-Checking Radiator Fan Relay Circuit
- Test 28-Step C-Checking Radiator Fan Relay Control Circuit
- Test No. 33 (CONT'D.)
- Ignition Timing & Idle Set RPM Adjustment Procedure
- Carburetor Specifications
- Wiring Diagrams
- A/T/M/T - Oil Leak at Speedometer Cable and Adapter
- Front Sway Bar - Squeak/Squawk Noises
- Driveability Test Procedures - Revisions
- Carburetor - Off Idle Wide Open Throttle Hesitation
- Liftgate - Creaking When Closing
- Campaign - Liftgate Latch
- Wipers/Washers - Wipers Smear or Streak Windshield
- Recall 85V164000: Sunscreen/Rearview Mirrors Required
- Folding Arm Rest - Loose/Shakes
- Engine - Oil Application
- Engine Oil - New `SG' Level Oil
- Engine Coolant - Recycling Recommendations
- Oil Filter - Adapter Change
- Engine Mount - Drive Gear Whine
- A/T - 404/413/415/470 Changes For 1986
- A/T - FWD Drive Gear Whine Noise at 40-50 MPH
- A/T - 404, 413, 470 Ring and Transfer Shaft Gears
- A/T - FWD Hard to Pull Out of Park
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Fluid Recommendation
- A/T - Shim Kits for Bearing Pre-Load Setting
- A/T - Pressure Tap Locations
- A/T - Engine Centering Procedure
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- M/T Shifter - Loose/Inoperative
- Automatic Transmission - New Fluid Type
- A/C, Heater - Temperature Lever Difficult to Move
- Lower Instrument Panel - Cracking
- Rough Cold Idle/ Cold Driveway Die Out
- Remote Quarter Window - Inoperative
- Paint - Codes/Cross References/Applications
- Paint - Variance Program
- High Altitude Conversion Package
- Overview
- 1985 2.2L-2V Light Duty Trucks All Models With Federal Emissions Package (49 States) Dodge Ram Van, Dodge Caravan, Plymouth Voy
- 1985 2.2L-2V Light Duty Truck Dodge Ram Van, Dodge Caravan & Plymouth Voyager Only Equipped With "50 States" Emission Package
- 1985 2.6L-2V Light Duty Truck All Models With Federal Emissions Package (49 States)
- 1985 3.7L-1V Light Duty Trucks All Models With Federal Emission Package (49 States)
- 1985 5.2L-2V Light Duty Trucks All Models With "50 States" Emissions Packages
- 1985 5.2L-2V Light Duty Trucks All Models With Federal Emissions Package (49 States)
- 5.9L-4V Light Duty Trucks All Automatic Models With Federal Emissions Package
- 5.9L-4V Light Duty Trucks All Manual Models With Federal Emission Package
- Gear Shift Indicator - Misaligned
- Cylinder Head Bolts - Modification
- Trailer Tow Wiring/Components - Installation Cautions
- Front Shock Tower - Metal Screws/Bolts Precautions
- M/T Shift Cable - High Shift Effort
- Dash Panel - Cracking Noise
- A/T - High Effort Is Required to Disengage Park
- Carburetor - Long Cold Engine Crank Times
- M/T - Hard Shifting Into and Out of 5TH Gear
- Front Door Upper Glass Run - Distorted/Wavy
- Recall 85V053000: Proportioning Valve Malfunction
- Propane Idle Adjustment - Determination Guidelines
- Fuel - Alcohol Fuel Recommendations
- Rear Wheel Alignment - Specifications Revision
- Wheel Alignment - Specifications
- Front End Alignment Specifications - Manual Revision
- Seat Belt Extender - Information
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process