Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - Stamped Steel Road Wheels
- Recall 93V098000: Wheel Lug Nut Seats Defect
- Recall 97V149000: Safety Belt Anchor Hook Defect
- Recall 99V113000: Inadvertent Air Bag Deployment
- Recall - ABS Piston and Pump/Motor Assy.
- Recall 00V305000: Steering Wheel Separation
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Recall 95I001001: Rear Liftgate Latch Opens In Collision
- Recall 95I001005: Rear Liftgate Latch Opens
- Recall - Seat Belt Buckle and Anchor Clips
- Recall 97V148000: Seat Belt Buckles Can Dislodge
- Recall 96V099000: ABS Hydraulic Control Unit Failure
- Recall 99V189000: Possible Loss Of Wiper Function
- Recall - Windshield Wiper Pivot Failure
- Recall 99V213000: Liftgate and Strut Bolts Defect
- Customer Interest
- Crossmember/Alignment/Wheels/Tires - Vehicle Drifts Left
- Fuel Pump - High Pitched Noise
- Fuel Pump - Driveability Concerns
- Front Brakes - Severe Rotor Wear/Noise
- A/C Compressor - Locks Up/Drive Belt Slippage
- AC Ducts - Emit Odors
- Low Heater Performance - Diagnosis/Repair
- Air Duct - Insufficient Heat To Driver's Side Floor
- A/C Compressor - Moaning Noise
- A/C Evaporator - High Pitched Whistle Noise
- Air Conditioning Ducts - Emits Musty Odor
- Strut Mount Bearing - Squeak Noise on turns
- Cooling Fan Motor, A/C Clutch - Inoperative
- Cooling Module Fan - Vibrates/Comes Loose
- Serpentine Drive Belt - Chirping Noise
- Exhaust Flex Joint - Squeaking Noise
- Exhaust - Hissing or Puffing Noises
- Heater - Poor Performance
- Tires/Alignment/Crossmember - Vehicle Drifts Left
- Aluminum Wheel Cap - Falls Off/Missing
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Tire - Lead or Drift Corrections
- Lock Cylinder - Key Breakage in Cylinder
- Front Window - Rolls Up Incorrectly/Weatherstrip Binds
- Under Seat Storage Drawer - Cracks
- Liftgate - Howling Noise Above 40 Mph
- Top of the A Post - Wind Noise
- Headliner - Odor Like Fish
- A/T - Slips In Reverse At Low Temperature
- Converter Clutch - Vehicle Shudder on Lock Up
- TCC - Acceleration Shudder/DTC 38 Set
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- Transmission Cooler Line - Revised Clamps
- A/T - Ratcheting Sound When Coming To Stop
- PCM - Deceleration Shudder At Low Engine Speeds
- PCM - Rough Engine Idle After Cold Start
- Door Ajar Lamp - Flickers/Locks Cycle Repeatedly
- ABS - Warning Lamp ON
- A/T - Engine Stalls On Takeoff
- PCM - Cold Engine Knock
- MIL ON - Erroneously, DTC Hex #2E Set
- PCM - MIL ON/No Codes Set
- PCM - Sag or Hesitation on Cold Start Up
- Catalytic Converter - Excessive Sulfur Odor
- A/T - Harsh Shift At Low Speed/Speedo. Fluctuates
- Speed Control - Intermittent Dropout/Disengagement
- A/T - Poor Shift Quality
- A/T - Harsh Gear Engagement/Upshifts/Downshifts
- Front Seat Belts - Do Not Retract Fully
- A/C System - Poor Cooling Performance
- A/C Service Equipment - Difficulty Connecting
- Park Brake Cable - Intermittent Squeak
- Cooling Fan - Causes Steering Wheel Vibration
- Black Plastic Body Components - Chalky Residue
- Outside Door Handle - Body Separation
- Front Door - Sagging
- Sliding Door Center Hinge Roller - May Exit the Track
- Door Panel Carpet - Warpage
- Side Vent Glass - Bang Sound on Rough Roads
- Rear Wiper Blade - Does Not Clean The Glass Well
- Wipers/Washers - Wipers Smear or Streak Windshield
- A/T - Shudder/Bumps/Slippage
- A/T Transfer Gear - Whine or Whistle Type Noise
- Engine Mount - Squeak/Clunk Noise
- Serpentine Drive Belt - Comes Off Pulleys
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- A/C, Heater - Temperature Lever Difficult to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- Middle Side Glass Vent Latch - Difficult Operation
- Vent Window Latch - Snapping/Clicking Noise
- Radio - AM Ignition Interference
- A/T - 41TE and 42LE Whistling Noise At Idle
- A/T - 41TE Buzz In Reverse
- M/T - Shifter Squeak When Shifting
- Multiple Systems Relay - Failures
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- M/T - Vent Oil Leak
- Front Seat Adjuster Latch - Does Not Latch Smoothly
- Manual Transaxle - Locked in Neutral or Reverse
- Quarter Trim Panel - Cracks
- Child Seat - Head Restraint Rattle
- Left B Post Exhauster - Loose
- Factory Modifications
- Improved Performance
- Labor/Parts Updates
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240695 - 05/05/95
- 232593 - 04/30/93
- 21-18-96 - 12/27/96
- 083993 - 01/01/93
- 082892 11/30/92
- 080794A - 10/21/94
- 051093 06/01/93
- Front Window - Rolls Up Outside of Glass Run
- Sliding Door Ajar Switch - Adjustment
- Cruise Control - Erratic During Initial Speed Set
- Speed Control - Intermittent Operation
- Front Manual Seat - Does Not Latch Smoothly
- Headliner - Fish Like Odor
- Odor From Headliner - Information Only
- Door - Snapping Noise/Hard Opening/Closing
- Outside Door Handle - Separates From Body
- Outside Door Handle - Separating From Body
- Radio Transmitter Equipment - Installation
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Airbag - ON/OFF Switches Availability
- Airbag - ON/OFF Switches Available
- A/C Evaporator - High Pitched Whistle
- A/C Ducts - Emit Musty Odors
- Electrical - Wire Splice Procedure Revision
- ABS - Left Front Speed Sensor Identification
- A/T - Vehicle Shudder During Torque Converter Operation
- A/T - Poor Shifting Quality
- A/T Pan Gasket - Reusable Design
- A/T - Vehicle Shudder During T/C Lock-up
- TCM - 41TE or 42LE A/T, Poor Shift Quality/Shudder
- A/T Quick Learn Procedure - Manual Update
- PCM - Engine Sag/Hesitation in Cold Ambient Temperatures
- PCM - High Accelerator Pedal Effort When Cold
- PCM - Check Engine Light ON/No Codes Set
- Fuel Pump - Excessive Noise
- Fuel Pump - Engine, Low Power/Die Out
- Engine Controls - Flash Reprogramming Failure
- A/C - Loss of Flow and Cooling/Evaporator Freeze Up
- Heater - Poor Performance In Cold Temperatures
- Engine - Oil Leak Diagnosis/Prevention
- Wheel Center Cap - Missing/Falls Off
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble
- A/T - Vehicle Shudder During TC Lock-up
- A/T - 41TE/42LE Intermittent Delayed Engagement
- Engine Coolant - Recommendations
- Serpentine Belt - Comes Off Pulleys
- A/T - ATF Usage List
- A/T - 41TE Harsh Shifting at Low Speed
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- TSBs - Using Body Code Identification
- Brakes - Noise Explanation
- A/C - System Sealer Usage Prohibition
- Crossmember/Alignment/Wheels/Tires - Vehicle Drifts Left
- Engine - Knocking When Cold
- Idle Air Control Motor - Whistling Noise
- Fuel Pump and Filter - Replacement Information
- Fuel Pump Module - Wiring Connector
- Fuel Pump - High Pitched Noise
- Fuel Pump - Driveability Concerns
- Front Brakes - Severe Rotor Wear/Noise
- A/C Compressor - Locks Up/Drive Belt Slippage
- AC Ducts - Emit Odors
- Low Heater Performance - Diagnosis/Repair
- Air Duct - Insufficient Heat To Driver's Side Floor
- A/C Compressor - Moaning Noise
- A/C - Evaporator Freezes Up/Lack Of Cooling
- A/C Evaporator - High Pitched Whistle Noise
- Instrument Panel Vents - Emit White Flakes
- Air Conditioning Ducts - Emits Musty Odor
- Strut Mount Bearing - Squeak Noise on turns
- Engine - Piston Knock at Idle
- Engine - Noise Diagnosis
- Cooling Fan Motor, A/C Clutch - Inoperative
- Cooling Module Fan - Vibrates/Comes Loose
- Serpentine Drive Belt - Chirping Noise
- Exhaust Flex Joint - Squeaking Noise
- Exhaust - Hissing or Puffing Noises
- Heater - Poor Performance
- Tires/Alignment/Crossmember - Vehicle Drifts Left
- Aluminum Wheel Cap - Falls Off/Missing
- Recall - Stamped Steel Road Wheels
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Tires/Wheels - Smooth Road Vibration/Shake
- Tire - Lead or Drift Corrections
- Tires/Wheels - Runout Reference Chart
- Recall 93V098000: Wheel Lug Nut Seats Defect
- Lock Cylinder - Key Breakage in Cylinder
- Front Window - Rolls Up Incorrectly/Weatherstrip Binds
- Under Seat Storage Drawer - Cracks
- Liftgate - Howling Noise Above 40 Mph
- Top of the A Post - Wind Noise
- Headliner - Odor Like Fish
- A/T - 41TE/42LE Shudder During EMCC Shift
- A/T - Slips In Reverse At Low Temperature
- Converter Clutch - Vehicle Shudder on Lock Up
- TCC - Acceleration Shudder/DTC 38 Set
- A/T - 41TE/AE 42LE Delayed Gear Engagement
- Transmission Cooler Line - Revised Clamps
- A/T - Ratcheting Sound When Coming To Stop
- PCM - Deceleration Shudder At Low Engine Speeds
- PCM - Rough Engine Idle After Cold Start
- Door Ajar Lamp - Flickers/Locks Cycle Repeatedly
- ABS - Warning Lamp ON
- ABS - Wheel Speed Sensor Applications
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- ABS - Component Service Procedure
- A/T - Engine Stalls On Takeoff
- PCM - Cold Engine Knock
- MIL ON - Erroneously, DTC Hex #2E Set
- PCM - MIL ON/No Codes Set
- PCM - Sag or Hesitation on Cold Start Up
- Engine Controls - Flash Programming Failure Recovery
- Fuel Pressure Regulator - Installation Procedure
- Fuel Tank - Slow To Fill
- Catalytic Converter - Excessive Sulfur Odor
- A/T - (41TE) Pinion Factor Axle Ratio Values
- A/T - Harsh Shift At Low Speed/Speedo. Fluctuates
- Speed Control - Intermittent Dropout/Disengagement
- Radio - Poor FM Reception
- A/T - Poor Shift Quality
- A/T - Harsh Gear Engagement/Upshifts/Downshifts
- Radio Communication Equipment - Recommendations
- Recall 97V149000: Safety Belt Anchor Hook Defect
- Seat Belt - Configuration
- Front Seat Belts - Do Not Retract Fully
- Recall 99V113000: Inadvertent Air Bag Deployment
- Airbag/Clock Spring - Service
- A/C System - Poor Cooling Performance
- A/C Hose - Squeaking Noise
- A/C Service Equipment - Difficulty Connecting
- Park Brake Cable - Intermittent Squeak
- Antilock Brake System - Operation Characteristics
- Recall - ABS Piston and Pump/Motor Assy.
- ABS System - Revised Test Procedures
- Front Suspension - Squeak Noise Diagnosis
- Cooling Fan - Causes Steering Wheel Vibration
- Recall 00V305000: Steering Wheel Separation
- Black Plastic Body Components - Chalky Residue
- Radio Transmitters - Installation
- Airbag - NHTSA Authorized Deactivation
- Air Bag System - Diagnostic Procedures Revisions
- Diagnostic Manual - Revision
- Auto Computers - Y2K Effects
- Electrical - Pin Out and Graphics Revisions
- Power Door Lock Switch/Bezel - Service
- Outside Door Handle - Body Separation
- Front Door - Sagging
- Front Door - Replacement Precautions
- Sliding Door Center Hinge Roller - May Exit the Track
- Door Panel Carpet - Warpage
- Side Vent Glass - Bang Sound on Rough Roads
- Lift Gate Trim Panel - Cracked
- Campaign - Liftgate Latch
- Recall 95I001000: Rear Liftgate Latch Opens
- Recall 95I001001: Rear Liftgate Latch Opens In Collision
- Recall 95I001005: Rear Liftgate Latch Opens
- Rear Wiper Blade - Does Not Clean The Glass Well
- Wipers/Washers - Wipers Smear or Streak Windshield
- Mirror Glass - Precautions Against Scratching
- Tape Stripe and Molding Adhesive - Removal
- Engine - Coolant Recommendations
- A/T Quick Learn Transaxle - Manual Correction
- A/T - Shudder/Bumps/Slippage
- A/T - (41TE/42LE) Service Information
- A/T Transfer Gear - Whine or Whistle Type Noise
- A/T - 41TE/42LE Interactive Cruise Control
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Intermittent Electrical Problems
- A/T - A604 Snap Ring Breakage
- A/T - Failsafe Modes
- A/T - Chatter During Engagement or Shifts
- A/T - Intermittent Limp-In/Fault Codes
- A/T - Electrical Harness Repair Parts
- A/T - Circuit Leaks, Low/Reverse Accumulator Cover
- A/T - Engine Speed Sensing Problems
- A/T - Snap Ring Locations
- A/T - Neutral-Safety And PRNODL Switch Check
- A/T - Overdrive Reverse Piston Interchanges
- A/T - Underdrive Clutch Piston Outer Lip Seal Change
- A/T - 41TE (A604) Solenoid Body Electrical Check
- A/T - 41TE/42LE Bind-Up In Reverse
- A/T - 41TE/42LE DTC 41, 42, 43, or 44/Solenoid Circuit
- A/T - 41TE (A604) Neutral Safety Switch/No Start
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Engine Mount - Click/Snap Noise
- Engine Mount - Squeak/Clunk Noise
- Serpentine Drive Belt - Comes Off Pulleys
- Serpentine Belt - Comes Off Pulleys, Driving in Snow
- Transmission Range Sensor - Production Change
- Temperature Control Lever - Fails to Hold Position
- A/C, Heater - Temperature Lever Difficult to Move
- Speed Sensor - Intermittent Loss of Cruise Control
- Recall - Seat Belt Buckle and Anchor Clips
- Engine - Oil Leak Diagnosis
- Charging System - No Code test Procedure Revisions
- Wiring - Revised Splicing Procedure
- Electrical Connectors - Cleaning Precautions
- Speed Control - Adaptive Strategy
- Tires/Wheels - Radial Runout Specification Revision
- Middle Side Glass Vent Latch - Difficult Operation
- Vent Window Latch - Snapping/Clicking Noise
- Recall 97V148000: Seat Belt Buckles Can Dislodge
- Solarban Vs. Privacy Glass - Identification
- Radio - AM Ignition Interference
- Stone Guard - Paint Repair
- Paint - Codes/Cross references/Applications
- Overview
- Paint Suppliers/Codes By Assembly Plant
- Domestic Passenger Car and Truck Exterior Paint
- Domestic Car and Truck Interior Paint Monotone Colors
- Domestic Car and Truck Interior Paint Two-Tone Colors
- Domestic Passenger Car Vinyl Roof
- Chrysler-Plymouth-Dodge Painted Stripe Colors
- Painted Two-Tone Stripe Application Chart Upper/Lower Colors
- Fascias Colors
- Cherokee/Wrangler Bumpers
- Wrangler Hardtops
- Painted Steel Wheels and Dakota Light BAR Package
- Import Passenger Car and Truck Exterior Paint
- Electronic Cycling Clutch Switch - Availability
- A/T - 41TE and 42LE Whistling Noise At Idle
- A/T - 41TE Buzz In Reverse
- Front Shock Tower - Metal Screws/Bolts Precautions
- Recall 96V099000: ABS Hydraulic Control Unit Failure
- M/T - Shifter Squeak When Shifting
- Multiple Systems Relay - Failures
- A/T - Harsh 1-2/2-3 Upshifts and 3-2 Kickdown
- M/T - Vent Oil Leak
- Front Seat Adjuster Latch - Does Not Latch Smoothly
- R 134A Refrigerant - Leak Detection
- R 134A Refrigerant - Leak Detection Systems
- Recall 99V189000: Possible Loss Of Wiper Function
- Rear License Plate/Frame - Rattles
- Spare Tire Winch - Operation Precautions
- Manual Transaxle - Locked in Neutral or Reverse
- Recall - Windshield Wiper Pivot Failure
- Windshield Wiper Pivot - Revisions
- Recall 99V213000: Liftgate and Strut Bolts Defect
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Sliding Door Interior Trim Panel - Rattle
- Quarter Trim Panel - Cracks
- Child Seat - Head Restraint Rattle
- Left B Post Exhauster - Loose
- A/T Pan Gasket - Reusable Design/Installation
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process