Air Duct - Insufficient Heat To Driver's Side Floor
NO.: 24-12-93GROUP: Heater & A/C
DATE: May 21, 1993
SUBJECT:
Insufficient Heat At Driver's Side Right Floor
MODELS:
1993 (AS) Caravan/Grand Caravan/Caravan CV Voyager/Grand Voyager/Town & Country
SYMPTOM/CONDITION:
Insufficient heat at the driver's right foot.
PARTS REQUIRED:
1 Duct, Heat Distribution 3849219
REPAIR PROCEDURE:
This bulletin involves installing a revised heat distribution duct for the left side floor.
If the vehicle is not equipped with a lower console, skip to step 9.
1. Remove the center instrument panel bezel by carefully unsnapping it.
2. Remove the two 5/16 in. hex head screws just above the cubby hole.
3. Remove the ash receiver/cupholder assembly by depressing the two latching tabs.
4. Remove the two 5/16 in. hex head screws at the rear of the ash receiver/ cupholder assembly cavity.
5. Remove the two 5/16 in. hex head screws at the lower right and left sides of the console.
6. Pull the console loose and remove the three Phillips head screws holding the cubby hole to the console assembly. Two are in the front, one is on the rear.
7. Remove the ash tray light.
8. Remove the console.
9. Remove the three 5/16 in. hex head screws holding the floor air distribution duct to the bottom of the heater/air conditioning housing. Remove the duct and discard it.
10. Install revised duct (P/N 3849219) by reversing the steps above.
POLICY: Reimbursable within the provisions of the warranty.
TIME ALLOWANCE:
Labor Operation No. 24-65-49-90 0.3 Hrs.
FAILURE CODE: P8 - New Part