Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Frame - Popping Sound From Right Front of Vehicle
- Fuel Pump - Multiple Driveability Concerns
- Front Brakes - Lead or Drift When Braking
- Front Brakes - Vehicle Leads/Drifts Left or Right
- A/C Compressor - Growling Noise
- Air Conditioning Ducts - Emits Musty Odor
- Oil Pump Drive Gear - Driveability Concerns
- Cooling Fan - Noise on Light Load Conditions
- Transfer Case - Rattling Noise
- A/T - Cooler Bypass Kit
- A/T - Delayed Gear Engagement After Start Up
- A/T - Delayed Upshift
- A/T - Delayed Upshifts and Harsh Engagement Into D or R
- IAC Motor - Erratic Idle/Stalls On Decel/Hot Restart
- Rear Brakes - Moan or Howl Noise
- Distributor - Surging, Bucking, or Intermittent Missing
- Throttle Body - Poor or Rough Idle / Driveway Die Out
- Speed Control - Intermittent Dropout/Disengagement
- Fuel Gauge - Inaccurate
- Black Plastic Body Components - Chalky Residue
- Roof Seam - Water Leaks
- Windshield - Wind Noise
- Wipers/Washers - Wipers Smear or Streak Windshield
- M/T Speed Sensor - Oil Leak
- A/T Governor - Delayed Upshift
- Left Front Wheel Area - Click/Squeak Noises
- M/T - Will Not Go Into Reverse
- A/C Evaporator - Emits Odors
- A/T - Driveline Clunk on 4-3 Downshift
- Front Coil Spring - Squeak on Bumps
- Pickup Box Tailgate - Hard To Latch In Cold Temps.
- A/T - Delayed Transmission Engagement or No Drive
- Front Seat Cushion - Too Low/Lack of Thigh Support
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 240695 - 05/05/95
- 240195 - 03/03/95
- 140593A - 01/02/93
- 140593 - 01/01/93
- 082892 11/30/92
- 051594A - 10/07/94
- Speed Control - Intermittent Operation
- Radio Transmitter Equipment - Installation
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- A/C Ducts - Emit Musty Odors
- Electrical - Wire Splice Procedure Revision
- Rear Brakes - Moaning/Howling Noise
- ABS Systems - Operational Characteristics
- A/T - Identification
- A/T - Fluid FlowRestriction/Cooler Bypass Kit
- A/T - Downshift Clunk
- A/T - Delayed Engagement/No Drive
- Fuel Gauge - Does Not read Accurately
- Fuel Pump - Driveability Problems
- Idle Air Control Motor - Erratic Idle/Stalling
- Cooling Fan - Noise/Loss of Engine Power
- Engine - Oil Leak Diagnosis
- Engine - Oil Leak From Rear Main Seal Area, Diagnosis
- Oil Pump Drive Gear - Causes Driveabiity Concerns
- A/T - Fluid Usage
- Engine Coolant - Recommendations
- A/T - ATF Usage List
- AX-15 M/T - High Shift Effort When Cold
- All Technical Service Bulletins
- Frame - Popping Sound From Right Front of Vehicle
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- TSBs - Using Body Code Identification
- Brakes - Noise Explanation
- A/C - R-12 to R-134a Conversion Procedure
- A/C - System Sealer Usage Prohibition
- Engine - Knocking When Cold
- Fuel Pump and Filter - Replacement Information
- Fuel Pump - Multiple Driveability Concerns
- Fuel Pump/Sending Unit Module - Tightening Procedure
- Front Brakes - Lead or Drift When Braking
- Front Brakes - Vehicle Leads/Drifts Left or Right
- A/C Compressor - Growling Noise
- A/C - Evaporator Freezes Up/Lack Of Cooling
- Instrument Panel Vents - Emit White Flakes
- Air Conditioning Ducts - Emits Musty Odor
- Engine Pushrod - Manual Revision
- Oil Pump Drive Gear - Driveability Concerns
- Cooling Fan - Noise on Light Load Conditions
- Engine Rear Main Bearing Seal - Oil Leak Diagnosis
- Front Caliper Mounting/Steering Knuckle - Thread Repair
- Coil Spring - Installation Precautions
- Tires/Wheels - Runout Reference Chart
- Transfer Case - Rattling Noise
- NP 231 Transfer Case - Revised Shift Procedure
- A/T Cooler Hose - Blockage Inspection
- A/T - Cooler Bypass Kit
- A/T Cooler - Reverse Flush With Bypass Kit Installed
- A/T - Delayed Gear Engagement After Start Up
- A/T - Delayed Upshift
- A/T - Delayed Upshifts and Harsh Engagement Into D or R
- IAC Motor - Erratic Idle/Stalls On Decel/Hot Restart
- Rear Brakes - Moan or Howl Noise
- ABS - Kelsey Hayes EBC-5H, EBC 310 Test Revisions
- Distributor - Position Checking
- Distributor - Surging, Bucking, or Intermittent Missing
- Throttle Body - Poor or Rough Idle / Driveway Die Out
- Speed Control - Intermittent Dropout/Disengagement
- Radio Communication Equipment - Recommendations
- Fuel Gauge - Inaccurate
- ABS - Operational Characteristics
- Recall 93V082000: Undersized Brake Return Check Valve
- Black Plastic Body Components - Chalky Residue
- Roof Seam - Water Leaks
- Radio Transmitters - Installation
- Air Bag System - Diagnostic Procedures Revisions
- Diagnostic Manual - Correction
- Auto Computers - Y2K Effects
- Windshield - Wind Noise
- Wipers/Washers - Wipers Smear or Streak Windshield
- Mirror Glass - Precautions Against Scratching
- Tape Stripe and Molding Adhesive - Removal
- Engine - Coolant Recommendations
- Automatic Transmission - Identification Procedures
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - A500/A518 No 4th Gear
- A/T - Intermittent Electrical Problems
- A/T - A500/A518 Overdrive Section Assembly Tips
- A/T - A500/A518 Overdrive Bearing Failure
- A/T - Failsafe Modes
- A/T - A500 Binds on Manual Upshift From Low
- A/T - A500, A518 No Fourth Gear
- A/T - A500 No Fourth Gear After Rebuild
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- CD Player - CD Compatibility
- A/T - Fluid Level Checking
- A/T - ATF+4 Fluid Usage/Applications
- M/T Speed Sensor - Oil Leak
- Wiring - Revised Splicing Procedure
- Electrical Connectors - Cleaning Precautions
- Speed Control - Adaptive Strategy
- Stone Guard - Paint Repair
- Paint - Codes/Cross references/Applications
- Overview
- Paint Suppliers/Codes By Assembly Plant
- Domestic Passenger Car and Truck Exterior Paint
- Domestic Car and Truck Interior Paint Monotone Colors
- Domestic Car and Truck Interior Paint Two-Tone Colors
- Domestic Passenger Car Vinyl Roof
- Chrysler-Plymouth-Dodge Painted Stripe Colors
- Painted Two-Tone Stripe Application Chart Upper/Lower Colors
- Fascias Colors
- Cherokee/Wrangler Bumpers
- Wrangler Hardtops
- Painted Steel Wheels and Dakota Light BAR Package
- Import Passenger Car and Truck Exterior Paint
- A/T Governor - Delayed Upshift
- Recall - Brake Return Check Valve
- Left Front Wheel Area - Click/Squeak Noises
- R 134A Refrigerant - Leak Detection Systems
- M/T - Will Not Go Into Reverse
- Spare Tire Winch - Operation Precations
- A/C Evaporator - Emits Odors
- A/T - Driveline Clunk on 4-3 Downshift
- Front Coil Spring - Squeak on Bumps
- Pickup Box Tailgate - Hard To Latch In Cold Temps.
- A/T - Delayed Transmission Engagement or No Drive
- M/T - High Shift Effort When Cold
- Shift Indicator - Adjustment Procedure
- Brakes - Bleeding Procedure
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Front Seat Cushion - Too Low/Lack of Thigh Support
- A/T - ATF + 4 Fluid Usage
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process