Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine - Spark Knock on Acceleration
- Engine - Spark Knock/Oil Consumption
- Squeaking/Clicking Noises From Rear Leaf Springs
- Dual Cargo Door - Water Leak Diagnostic/Repair Procedure
- Axle - Noise/Whine Between 35 and 55 MPH
- A/T - Overdrive Unavailable in Cold Temperatures
- Front Suspension - Knocking Noise on Turns
- Brakes - Vibration/Shudder on Application
- Rear Axle - Vehicle Speed Is Inaccurate
- Engine - Spark Knock/PCM Reprogramming
- MIL ON, Erroneous DTC P0107 Set
- PCM - Incorrect Fault Mature Time for DTC#B7
- I/M Testing - OBDII CARB Readiness Monitor Information
- TCM - MIL ON/DTC P1763 Set
- Upper A-Pillar Area - Wind Noise
- Sliding Door - Will Not Open And/Or Close/Latch
- Side/Rear Cargo Door(s) - Open Too Far
- Wipers/Washers - Wipers Smear or Streak Windshield
- Ignition System - Cross Fire/Ignition Wire Induction
- A/T - Buzz/Whining in Reverse When Cold
- Side/Rear Cargo Door - Outside Handle(s) Loose
- A/T - Engine Bucking/Surging at 5,300 Rpm
- RKE Transmitter - Premature Battery Failure
- A/C - Musty Odors When Hot/Humid
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 18-05-00A - 06/23/00
- 18-05-00 - 09/15/00
- Outside Rearview Mirror Glass - Replacement
- Outside Mirror - Glass Replacement
- Outside Mirror Glass - Replacement
- Radio Transmitting Equipment - Installation
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Rear Leaf Springs - Squeaking/Clicking Noise
- Rear Leaf Springs - Squeaking Noise
- Electrical - Wire Splice Procedure Revision
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- MIL - Erroneously ON, DTC P1763 Set
- MIL - Erroneously ON, DTC #24 (P0107)
- PCM - Flash Programming Failure Recovery
- Engine - Spark Knock/Excessive Oil Consumption
- A/T - Fluid Usage
- A/C - Musty Odors When Hot or Humid
- A/T - ATF Usage List
- Engine - Spark Knock Noise
- Engine - Spark Knock.
- Engine - Spark Knock On Acceleration
- Engine - Spark Knock
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Engine - Spark Knock on Acceleration
- Fuel System/Engine Controls - Manual Revisions
- Steering Wander - Diagnosis and Correction Revised
- Engine Cooling Fan - Roaring Noise Explanation
- Viscous Fan Drive - Service Procedures
- Engine - Spark Knock/Oil Consumption
- Squeaking/Clicking Noises From Rear Leaf Springs
- Recall 98V076000: Seat Attaching Riser Welds Incorrect
- Dual Cargo Door - Water Leak Diagnostic/Repair Procedure
- Axle - Noise/Whine Between 35 and 55 MPH
- A/T - Overdrive Unavailable in Cold Temperatures
- Powertrain Control Module - Service Precaution
- Recall - Reprogram PCM
- Engine Controls/Fuel System - Service Manual Revisions
- Front Suspension - Knocking Noise on Turns
- Brakes - Vibration/Shudder on Application
- Rear Axle - Vehicle Speed Is Inaccurate
- Recall 04V185000: ABS Control Module Corrosion
- Recall - ABS Wiring Corrosion
- Brakes - Teves Mark IV/Teves Mark 20 ABS Revisions
- Brakes - Teves Mark 20 ABS System Test Revisions
- Engine - Spark Knock/PCM Reprogramming
- MIL ON, Erroneous DTC P0107 Set
- PCM - Incorrect Fault Mature Time for DTC#B7
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- TCM - MIL ON/DTC P1763 Set
- Radio Communication Equipment - Recommendations
- Airbag/Clock Spring - Service
- Recall - Airbag Electronic Control Module
- Engine Controls - Miss-Fire Test Revisions
- ABS/TCS - Diagnostic Test Revisions
- Brakes - Teves Mark IVG and Mark 20 ABS Revisions
- Brakes - Kelsey Hayes EBC2 and EBC325 ABS Revisions
- Brakes - Teves Mark 20 ABS, Manual Revisions
- Brakes - Teves Mark 20 ABS System Revisions
- Brakes - Kelsey Hayes EBC 2 and EBC 3 ABS Revisions
- Upper A-Pillar Area - Wind Noise
- Airbag - NHTSA Authorized Deactivation
- Antitheft System - Starting Difficulties
- Recall - VECI Label Replacement
- Leak Detection Pump - Monitor Test
- Evaporative System - Leak and DTC Diagnostics
- Auto Computers - Y2K Effects
- Generic Scan Tool - Reference Information
- Engine Controls/Fuel System - Manual Revisions
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Differential Cover - Updated Sealer and Fluid
- Sliding Door - Will Not Open And/Or Close/Latch
- Side/Rear Cargo Door(s) - Open Too Far
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Ignition System - Cross Fire/Ignition Wire Induction
- Engine Controls - ECT Sensor Test revisions
- Wiring - Revised Splicing Procedure
- Electrical - Pin-Out/Connector Manual Revisions
- A/T - Buzz/Whining in Reverse When Cold
- Side/Rear Cargo Door - Outside Handle(s) Loose
- A/T - Engine Bucking/Surging at 5,300 Rpm
- Differential - Lubricant and Sealing Requirements
- Recall - Power Seat Riser
- RKE Transmitter - Premature Battery Failure
- Steering - Power Steering Fluid Usage
- EVAP System - Leak Detection Pump Misdiagnosis
- Engine - High Driveability Index Fuels
- Fuel Pressure Gauge Adapter - Usage
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- A/C - Musty Odors When Hot/Humid
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process