Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C Compressor - Locks Up At Low Mileage
- Front Strut Bearings - Squeaking/Chirping Noise
- Power Steering - Honk Or Squeal Noise at Low Speed
- Serpentine Belt - Loss of Power Steering
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Front Suspension - Knock/Squawk Sound
- Front Seat Assist Handle - Loose Or Pulled Out
- Door Weatherstrip - Falls Off Mounting Flange
- Steering Wheel - Click/Rattle Sound
- Brakes - Howl/Moan From The Rear
- Radio - Poor AM Reception/Ignition Noise
- I/M Testing - OBDII CARB Readiness Monitor Information
- Accelerator Pedal - Vibration/Buzz
- EGR Diagnostic High Attitude Test Difficult
- PCV Valve Freeze-Up
- B-Pillar - Tick Type Noise While Driving
- Roof Panel - Wavy/Has Depressions
- Suspension/Body - Strut Tower Corrosion
- Power Door Lock Motor - Whirling Noise
- Sliding Door Power Lock Actuator - Chatter Sound
- Instrument Panel Speaker - Intermittent Operation/Static
- Steering Column - Pop/Tick From Steering Wheel Area
- Front Door Glass- Windnoise
- Right Side Sliding Door Trim Panel - Rubs Quarter Panel
- Sliding Door - Rattle Noise At B-Post Area
- Wipers/Washers - Wipers Smear or Streak Windshield
- Engine - Ticking Noise While At Idle
- Speed Sensor - Intermittent Loss of Cruise Control
- Air Bags - Warning Lamp ON Intermittently/Constantly
- Radio - Perceived Loss or Change Of Station Presets
- Speed Control - Does Not Maintain Speed on Grades
- Ignition Key - Will Not Turn And/Or Cannot Be Removed
- A/T - Case Porosity/Fluid Seepage
- RKE Transmitter - Is Intermittently Inoperative
- Quad Seat Easy Entry Latch - Rattles
- Recommended Repairs
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 23-28-96 - 05/03/96
- 08-34-98A - 07/24/98
- 08-34-98 - 07/02/98
- B-Pillar - Ticking Noise When Driving
- Outside Rearview Mirror Glass - Replacement
- Outside Mirror - Glass Replacement
- Radio Transmitting Equipment - Installation
- RKE Transmitter - Intermittently Inoperative
- Child Seat Tether Anchor - Parts/Labor Identification
- Airbag - On/Off Switch Availability
- A/C Compressor - Lock-Up At Low Mileage.
- Steering Wheel - Popping/Ticking Sound
- Electrical - Wire Splice Procedure Revision
- Brakes - Snow/Water Ingestion Into Rear Drum
- Brakes - Rear Drum Brake Freezing/Water/Snow Ingestion
- Brake Drums (Rear) - Snow/Water Ingestion
- Rear Brake Drums - Freezing/Rusting
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- A/T Pan Gasket - Reusable Design
- PCM - A/C System Blows Warm Air Intermittently
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- PCM - Flash Programming Failure Recovery
- A/C Suction/Discharge Line - Cracks
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Electrical Systems - Feature Changes
- A/C - System Leak Detection
- A/C/Interior/Drivetrain - Manual Updates
- A/C - System Sealer Usage Prohibition
- Engine - Service Procedures Revision
- A/C Compressor - Locks Up At Low Mileage
- Front Strut Bearings - Squeaking/Chirping Noise
- Power Steering - Honk Or Squeal Noise at Low Speed
- Steering - Steering Gear Removal/Installation Revisions
- Serpentine Belt - Loss of Power Steering
- Suspension - Coil Spring Service Procedures Update
- Electrical/Suspension - Service Manual Updates
- Aluminum Wheels - Special Balance Weights
- Tires/Wheels - Smooth Road Vibration/Shake/Wobble.
- Wheels and Tires - Low Speed Wobble
- Front Suspension - Knock/Squawk Sound
- Front Seat Assist Handle - Loose Or Pulled Out
- Door Weatherstrip - Falls Off Mounting Flange
- Steering Wheel - Click/Rattle Sound
- A/T Oil Cooler Line Hose Clamp - Revised
- BCM - Auto Lamp DTC Diagnostics
- Body Control Module - Erroneous DTC Set
- Electrical - Seat Heater Harness/BCM Pin-Out Revisions
- CV Boot - Grease Seepage Explanation
- Brakes - Howl/Moan From The Rear
- Ignition Switch - Housing Service
- Radio - Poor AM Reception/Ignition Noise
- A/T - DTC P1714 Stored in Memory
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine Controls - Flash Programming Failure Recovery
- Accelerator Pedal - Vibration/Buzz
- EGR Diagnostic High Attitude Test Difficult
- PCV Valve Freeze-Up
- Radio Communication Equipment - Recommendations
- Recall 02V076000: Seat Belt May Become Inoperative
- Airbag/Clock Spring - Service
- Cooling System - Cooling Fan Relay Revisions
- ABS System - 'No Response' Test Revisions
- B-Pillar - Tick Type Noise While Driving
- Roof Panel - Wavy/Has Depressions
- Suspension/Body - Strut Tower Corrosion
- Electrical - Wiring Schematic Revision
- Leak Detection Pump - Monitor Test
- Auto Computers - Y2K Effects
- Intermittent MIL W/Hex Code $1B (P0123) TPS Voltage High
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Power Door Lock Motor - Whirling Noise
- Sliding Door Power Lock Actuator - Chatter Sound
- Instrument Panel Speaker - Intermittent Operation/Static
- Steering Column - Pop/Tick From Steering Wheel Area
- Front Door Glass- Windnoise
- Right Side Sliding Door Trim Panel - Rubs Quarter Panel
- Sliding Door - Rattle Noise At B-Post Area
- Memory Power Seat - Travel Range
- Recall - Seat Belt Retractor Replacement
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Body - Power Mirror Description/Operation Revisions
- Engine - Ticking Noise While At Idle
- Recall 99V116000: Headlamp Module Defect
- Transmission Range Sensor - Production Change
- Speed Sensor - Intermittent Loss of Cruise Control
- Air Bags - Warning Lamp ON Intermittently/Constantly
- Recall - Clockspring Replacement/Warranty Extension
- Recall 04V480000: Air Bag Clockspring Replacement
- Electrical - Wiring Schematic Update
- Electrical - Wiring Schematics Revisions
- Fuel System - Service Procedures Update
- Radio - Perceived Loss or Change Of Station Presets
- Keyless Entry - Programming Procedure
- Campaign - Seat Heater Element/Module/Wiring Replacement
- Speed Control - Does Not Maintain Speed on Grades
- Ignition Key - Will Not Turn And/Or Cannot Be Removed
- A/T - Case Porosity/Fluid Seepage
- RKE Transmitter - Is Intermittently Inoperative
- Keyless Entry - Transmitter Programming Procedure Rev.
- Steering - Power Steering Fluid Usage
- Quad Seat Easy Entry Latch - Rattles
- Recall - Daytime Running Lamp Labels
- EVAP System - Leak Detection Pump Misdiagnosis
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Rear Wheel Park Brake Actuator/Lever - Service
- A/T Pan Gasket - Reusable Design/Installation
- Brakes - Rear Brake Drum Freezing/Water/Snow Ingestion
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process