Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Safety
- Recall 99V115000: Hydraulic Clutch Assembly Defect
- Recall - Hydraulic Clutch
- Recall 99V044000: CNG Fuel Rail Defect
- Recall - Secondary Hood Latch Lubrication
- Recall 01V119000: Seat Belt Retractor
- Recall 99V190000: Hydraulic Clutch Line Heat Shield
- Recall - Trailer Hitch Reinforcement Brackets
- Recall 00V107000: Trailer Hitch Bracket Defect
- Recall - Underbody Heat Shield
- Recall 99V034000: Incorrect CNG Fuel Tank Straps
- Customer Interest
- Steering System - Diagnosis
- Engine - Spark Knock/Oil Consumption
- Ball Joint - Steering Slow To Return To Center
- Suspension - Curb Height Too High to Attach Trailer
- Squeaking/Clicking Noises From Rear Leaf Springs
- Steering Column - Squeaking/Creaking Sound
- A/T - Harsh Reverse Gear Engagement
- PCM - Erroneous Engine Misfire
- PCM - False Mil ON, DTC P0443 Set
- PCM - Start and Stall, Idle Undershoot/Lost IAC Steps
- PCM - Addition of A Clear Flood Feature
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine - Spark Knock On Acceleration
- Engine - Surge/Lack of Power in 3rd Gear/Erratic Shifts
- Purge Bracket - Knocking Noise
- TCM - MIL ON/DTC P1763 Set
- Compass/Trip Computer - Indicates False MPG
- Radio - Interference To/From Two Way Radio Receiver
- Two Way Radio - Intermittent Poor Reception
- Oil Filter Adapter - Gasket Leakage
- Accessory Drive Belt - Noisy/Damaged
- Speakers - Static During Mirror Operation
- Entertainment Device - Front Door Speaker Buzz
- Speakers - Intermittent Operation/Static
- Window Channel - Rattle From Door Area
- Grille - Wind Noise At 45 To 65 Mph
- Seat Belt Retractor Cover - Bezel Comes Loose
- Wipers/Washers - Wipers Smear or Streak Windshield
- Power Steering - Hissing Sound
- Ignition System - Cross Fire/Ignition Wire Induction
- Instrument Cluster - Erratic Operation
- Instrument Panel - Creak/Squeak
- Paint - Surface Fogging or Whitening
- A/T - Buzz/Whining in Reverse When Cold
- Seat Vertical Adjuster - Stuck In Up/ Down Position
- Keyless Entry Transmitter - Intermittently Inoperative
- RKE Transmitter - Is Intermittently Inoperative
- M/T - NV 3500 Difficult Shifts/Pops Out Of Gear
- M/T - Incomplete Engagement of 1ST/2ND Gear
- Factory Modifications
- Superceded Bulletins
- 23-08-00B - 11/24/00
- 18-006-02B - 05/06/02
- Instrument Panel - Creaking Noise
- Outside Rearview Mirror Glass - Replacement
- Outside Mirror - Glass Replacement
- Outside Mirror Glass - Replacement
- Radio Transmitting Equipment - Installation
- Speaker - Intermittent Operation/Static
- RKE Transmitter - Intermittently Inoperative
- Child Seat Tether Anchor - Parts/Labor Identification
- Child Seat Tether Anchors - Parts/Labor Identification
- Child Seat - Tether Anchor Installation
- Airbag - On/Off Switch Availability
- Rear Leaf Springs - Squeaking/Clicking Noise
- Rear Leaf Springs - Squeaking Noise
- Electrical - Wire Splice Procedure Revision
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- Radio Receivers (2-Way) - Poor Reception
- Two Way Radio Receivers - Intermittent Interference
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- MIL - Erroneously ON, DTC P1763 Set
- PCM - Flash Programming Failure Recovery
- Engine - Spark Knock/Excessive Oil Consumption
- A/T - Fluid Usage
- Front Hub Seal - Grease Purge Explanation
- A/T - ATF Usage List
- Engine - Spark Knock/PCM Reprogramming
- All Technical Service Bulletins
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Steering System - Diagnosis
- Steering/Suspension - Drift Diagnosis and Repair
- Front Hub Seals - Grease Purge Explanation
- Viscous Fan Drive - Service Procedures
- Engine - Spark Knock/Oil Consumption
- Ball Joint - Steering Slow To Return To Center
- Suspension - Curb Height Too High to Attach Trailer
- Driveline - Vehicle Surge/Vibration Diagnosis
- Squeaking/Clicking Noises From Rear Leaf Springs
- Steering Column - Squeaking/Creaking Sound
- A/T - Apparent Front Pump Leak Explanantion
- Recall 99V115000: Hydraulic Clutch Assembly Defect
- Recall - Hydraulic Clutch
- A/T - Harsh Reverse Gear Engagement
- Wiper Module - CTM Mandatory PROM Update
- Brakes - Master Cylinder Service Revisions
- PCM - Erroneous Engine Misfire
- PCM - False Mil ON, DTC P0443 Set
- PCM - Start and Stall, Idle Undershoot/Lost IAC Steps
- PCM - Addition of A Clear Flood Feature
- I/M Testing - OBDII CARB Readiness Monitor Information
- Engine - Spark Knock On Acceleration
- Engine - Surge/Lack of Power in 3rd Gear/Erratic Shifts
- Engine Controls - Flash Programming Failure Recovery
- Recall 99V044000: CNG Fuel Rail Defect
- Purge Bracket - Knocking Noise
- TCM - MIL ON/DTC P1763 Set
- Compass/Trip Computer - Indicates False MPG
- Radio - Interference To/From Two Way Radio Receiver
- Radio Communication Equipment - Recommendations
- Interior - Seat Belt Cinch Bar Service
- Airbag/Clock Spring - Service
- Driver Airbag - Trim Cover Service
- Two Way Radio - Intermittent Poor Reception
- Oil Filter Adapter - Gasket Leakage
- Engine/Lighting - Stoplamp Switch/Vacuum Pump Rev.
- Accessory Drive Belt - Noisy/Damaged
- Antitheft System - Starting Difficulties
- Leak Detection Pump - Monitor Test
- Evaporative System - Leak and DTC Diagnostics
- Auto Computers - Y2K Effects
- DTC's - Caused By Open Fuses
- Generic Scan Tool - Reference Information
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Recall - Secondary Hood Latch Lubrication
- Speakers - Static During Mirror Operation
- Entertainment Device - Front Door Speaker Buzz
- Speakers - Intermittent Operation/Static
- Differential Cover - Updated Sealer and Fluid
- Window Channel - Rattle From Door Area
- Grille - Wind Noise At 45 To 65 Mph
- Seat Belt Retractor Cover - Bezel Comes Loose
- Recall 01V119000: Seat Belt Retractor
- Wipers/Washers - Wipers Smear or Streak Windshield
- Outside Rearview Mirror - Glass Replacement
- Front Bumper - Adjustable Front Fascia
- Power Steering - Hissing Sound
- A/T - 46RE Shift Quality and Durability Improvements
- CD Player - CD Compatibility
- A/T - ATF+4 Fluid Usage/Applications
- Ignition System - Cross Fire/Ignition Wire Induction
- Instrument Cluster - Erratic Operation
- Instrument Panel - Creak/Squeak
- Wiring - Revised Splicing Procedure
- Recall 99V190000: Hydraulic Clutch Line Heat Shield
- Keyless Entry - Programming Procedure
- Radio - Connector Repair Kit
- Paint - Surface Fogging or Whitening
- Cargo Net - Eliminated From Production
- A/T - Buzz/Whining in Reverse When Cold
- Recall - Trailer Hitch Reinforcement Brackets
- Recall 00V107000: Trailer Hitch Bracket Defect
- Recall - Underbody Heat Shield
- Differential - Fluid Discoloration Explanation
- A/T - (42RE) Revised Front Band Adjustment
- Seat Vertical Adjuster - Stuck In Up/ Down Position
- Keyless Entry Transmitter - Intermittently Inoperative
- RKE Transmitter - Is Intermittently Inoperative
- M/T - NV 3500 Difficult Shifts/Pops Out Of Gear
- Height Sensing Proportioning Valve - Removal
- Steering - Power Steering Fluid Usage
- M/T - Incomplete Engagement of 1ST/2ND Gear
- Recall 99V034000: Incorrect CNG Fuel Tank Straps
- EVAP System - Leak Detection Pump Misdiagnosis
- Air Bag System - ON-OFF Switch Availibility
- Air Bag - On/Off Switches
- Child Seat - Tether Anchor Part Numbers and Labor Time
- Child Seat Tether Anchor - Labor/Parts Identification
- Door Trim Panel Retainer Clip - Attachment Breakage
- Brakes/Electrical - Precaution/Schematic Updates
- A/T - ATF + 4 Fluid Usage
- A/T - Repair/Replacement Guidelines
- Restraints - Child Seat Tether Installation
- Recall - Replace Mopar(R) Value Line Catalytic Converter
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process