Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Safety
- Canada - Recall - H46 Steering Linkage
- Canada - Recall - E17 Out OF Park Alarm System
- Recall 11V350000: L/H Tie Rod Ball Stud Fracturing
- Recall - Aluminum Wheels Cracking
- Recall 03V033000: High Idle Speed/PROM Update
- Recall - Reprogram Diesel Engine Control Module
- Recall - Out-Of-Park Alarm System
- Recall - Steering Linkage Defects
- Recall - Left Tie Rod Replacement/Track Bar Torque
- Customer Interest
- Steering/Suspension - Vibration/Shimmy Above 50 MPH
- Body - Light To Moderate Paint Imperfections
- Fuel System - Water Separator Drain Restriction
- Body - Dirt/Mud in Door Opening Area
- Drivetrain - Launch Shudder
- A/T - 45RFE/545RFE Delayed Engage After Filter R and R
- Engine Controls - MIL ON/ Possible DTC P0123/P01596
- Charging System - Drive Belt Squealing Noise
- Engine Controls - Poor Throttle Response/DTC's Set
- A/T - Will Not Shift Out of 3rd Gear Until 70 Mph
- A/T - Stuck in 1st or 3rd Gear/No MIL or DTC's Present
- Engine Controls - Poor A/C Performance/DTC's Set
- Engine Controls - Long Crank Times in Extreme Cold
- Alarm System - Erroneous Horn Chirp/Alarm Siren
- Body - Water Leaks At Grab Handle
- Body - Aftermarket Window Tint Scratching
- Wipers/Washers - Wipers Smear or Streak Windshield
- Lamp Out Indicator - ON with Utility Bed Installed
- Steering - Vibration Felt in Steering Column
- Audio System - 'CD ERR' Message Displayed
- Diesel Engine - Drive Belt Chirp At Shut Down
- Body - Bug Deflector Wind Noise
- Body - Bug Deflector Loose Rattling
- Interior - Instrument Panel Whistling Sound
- Power Locks - Intermittently Lock/Unlock by Themselves
- Steering - Movement Felt in Column
- A/C - Lack of Air from Floor Vents
- Instruments - Erroneous Indicator lamp Illumination
- Body - Buzzing/Vibration from Front of Vehicle
- A/C - Musty Odors When Hot/Humid
- Steering - Front End Shimmy On Rough Roads
- Diesel Engine - White Smoke/Surge at Idle/Hard Start
- Engine Controls - Engine System Enhancements
- Fuel System - MIL ON/DTC P0251 Stored In Memory
- Superceded Bulletins
- 21-013-11 - 12/22/11
- H46 - 04/13/09
- 18-043-03 - 12/05/03
- 14-002-02 - 07/01/02
- Steering - Snapping or Ticking Sound From Column
- Steering - Revised Power Steering Bleeding Procedure
- Recall - Steering Damper/Drag Link Defects
- Recall - Steering Linkage Defect
- Brakes - Vibration/Shudder Above 50 Mph
- M/T - Diagnostic Tear Down Procedure
- A/T - Diagnostic Teardown Procedures
- A/T - Diagnostic Tear-Down Procedure
- Automatic Transmission - Diagnostic Teardown Procedure
- A/T - Diagnostic Teardown Procedure
- Engine Controls - Software Update for Several Issues
- Diesel Fuel System - Engine Surge at Idle
- Engine Controls - Cummins Generic ECM Programming
- Engine Controls - Flash Reprogramming Failure
- Engine Controls - Co-Pilot Support/Cable Selection
- Engine Controls - Generic Cummins ECM Programming
- Engine Controls - PCM Initialization After Replacement
- Engine Controls - PCM Initialization Procedure
- Emissions - ECM Update For I/M Check Failure
- A/C - Musty Odors When Hot or Humid
- Chrome Wheels - Care and Maintenance
- Wheels - Chrome Wheel Care
- A/T - ATF Usage List
- Diesel Fuel System - Hard Start/White Smoke/Surge/Noise
- Fuel System - Enhanced Fuel Filtering System
- Fuel System - Heavy Duty Fuel Filtration Kit
- Fuel System - Heavy Duty MOPAR Filtration Kit Retrofit
- All Technical Service Bulletins
- Diesel Engine - Heavy Duty Air Filtration Retrofitting
- Canada - Recall - H46 Steering Linkage
- Canada - Recall - E17 Out OF Park Alarm System
- Body/Frame - Welded Sheet Metal Repairs And Replacements
- Body - Don't Apply Corrosion Protection On Plastic Panels
- Body - Front Bumper Fascia Repair For License Bracket Holes
- Steering/Suspension - Vibration/Shimmy Above 50 MPH
- M/T - Diagnostic Teardown Procedure
- Collision - Safety Cert./Tire Press. Label Replacement
- Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
- Body - Light To Moderate Paint Imperfections
- Fuel System - Heavy Duty MOPAR Filtration Kit Retrofit
- Wheels - Reconditioned Wheel Usage
- Restraints - Replacement Seat Covers/Seat Cover Repairs
- Restraints - Use Of Salvaged Restraint System Components
- Body/Frame - Structural Repair Components
- Body/Frame - Usage Of Heat For Repair
- Engine - 'Dust-Out' Diagnostic Information
- Steering - Tie Rod Ball Stud Housing Alignment Procedure
- Recall 11V350000: L/H Tie Rod Ball Stud Fracturing
- A/C - System Leak Detection
- A/C - System Sealer Usage Prohibition
- Fuel System - Water Separator Drain Restriction
- Campaign - Diesel Engine Cooling Fan
- Recall 03V212000: Wheel Inspection/Replacement
- Recall - Aluminum Wheels Cracking
- Wheels - Caring for Chrome Wheels
- Body/Frame - Frame Alteration Guidelines/Precautions
- Body - Dirt/Mud in Door Opening Area
- Drivetrain - Launch Shudder
- A/T - 45RFE/545RFE Delayed Engage After Filter R and R
- Campaign - A/T Cooler Line Replacement
- Engine Controls - Incorrect VIN Affects PCM Programming
- Engine Controls - MIL ON/ Possible DTC P0123/P01596
- Campaign - PCM Connector Modification
- Engine Controls - Generic Engine Module Programming
- Charging System - Drive Belt Squealing Noise
- Recall 03V033000: High Idle Speed/PROM Update
- Engine Controls - Poor Throttle Response/DTC's Set
- A/T - Will Not Shift Out of 3rd Gear Until 70 Mph
- A/T - Stuck in 1st or 3rd Gear/No MIL or DTC's Present
- Engine Controls - Poor A/C Performance/DTC's Set
- Recall - Reprogram Diesel Engine Control Module
- Recall - Reprogram PCM Transmission OBD Calibration
- Engine Controls - Long Crank Times in Extreme Cold
- Engine Controls - Flash Programming Failure Recovery
- Alarm System - Erroneous Horn Chirp/Alarm Siren
- Safety Systems - Inadvertent Damage/Disabling
- Body - Water Leaks At Grab Handle
- Electrical - Radio Equipment Installation Recommendation
- Engine Controls - Co-Pilot Support/Correct Cable Usage
- Body - Aftermarket Window Tint Scratching
- Wipers/Washers - Wipers Smear or Streak Windshield
- Lamp Out Indicator - ON with Utility Bed Installed
- Steering - Vibration Felt in Steering Column
- Recall - Out-Of-Park Alarm System
- Drivetrain - Erroneous DTC's Stored in TCCM
- Audio System - CD Changer Operation/Features
- Audio System - 'CD ERR' Message Displayed
- Diesel Engine - Drive Belt Chirp At Shut Down
- A/T - ATF+4 Fluid Usage/Applications
- Body - Bug Deflector Wind Noise
- Body - Bug Deflector Loose Rattling
- Interior - Instrument Panel Whistling Sound
- Power Locks - Intermittently Lock/Unlock by Themselves
- Steering - Movement Felt in Column
- Drivetrain - Differential Fluid Requirements
- A/C - Lack of Air from Floor Vents
- Steering - Power Steering Fluid Usage
- Campaign - Torque Converter Drain Back Valve
- Instruments - Erroneous Indicator lamp Illumination
- Body - Buzzing/Vibration from Front of Vehicle
- Steering - Revised Power Steering Bleeding
- A/C - Musty Odors When Hot/Humid
- Steering - Front End Shimmy On Rough Roads
- Diesel Engine - White Smoke/Surge at Idle/Hard Start
- Engine Control - PCM Initialization Procedure
- Engine Controls - Engine System Enhancements
- Body - Trailer Tow Mirror Glass Replacement
- A/T - ATF + 4 Fluid Usage
- Diesel Fuel System - VP44 Injector Pump Tampering
- A/T - Repair/Replacement Guidelines
- Recall - Steering Linkage Defects
- Fuel System - MIL ON/DTC P0251 Stored In Memory
- Diesel Engine - Dust/Debris Ingestion/Power Upgrade Info
- Recall - ECM Update For OBD Readiness
- Recall - Left Tie Rod Replacement/Track Bar Torque
- Body - Paint Overspray Removal Procedures
- Paint - Clearcoat Blending During Refinish Process