Repair and Diagnosis: Technical Service Bulletins

• How to Find Technical Service Bulletins by Category/Symptom
• Recalls
  • Recall - Windshield Wiper Motor Defect
    • Overview
    • Service Procedure
    • Owner Letter
  • Recall 04V216000: Wiper Module Replacement
• Customer Interest
  • Body - Light To Moderate Paint Imperfections
  • A/T - 45RFE/545RFE Delayed Engage After Filter R and R
  • A/T/Engine Controls - False Solenoid DTC's Set
  • Engine Controls - Idle Undershoot
  • Engine Controls - 42RLE A/T Slow/Harsh/Delayed Shifts
  • Engine Controls - Stumble/Hesitation/False DTC's
  • Engine Controls - MIL ON/DTC's P2097/P2099 Set
  • A/T - 4th Gear Lock Up Shudder
  • Audio System - Intermittent Loss of Audio
  • A/T - 42RLE MIL ON/Multiple DTC's Set
    • Overview
    • AN/HB/ND Repair Procedure
    • KJ Repair Procedure
    • LX Repair Procedure
    • TJ Repair Procedure
    • Wiring Harness and Solenoid Repair Procedure
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • A/C - Water Leaks Onto Passenger Front Floor
  • Engine Controls - MIL ON/DTC P1776 Set
  • A/C - Musty Odors When Hot/Humid
    • Overview
    • AB/CS/LX/RS/WK/XK Vehicle Procedure
    • AN/DN/DR/HB/JR/KJ/LH/ND/PL/PT/TJ/WG/WJ Vehicles Procedure
    • ST Vehicle Procedure
    • VA Vehicle Procedure
  • Emissions - PCV System Freezes in Extreme Cold
  • Engine Controls - MIL ON/DTC's P0340/P0344 Set
  • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
  • A/T - MIL ON, DTC P1776 Set
• Superceded Bulletins
  • 21-013-11 - 12/22/11
  • A/C - Water Leaks Onto Passenger Side Floor
  • M/T - Diagnostic Tear Down Procedure
  • A/T - Diagnostic Teardown Procedures
  • A/T - Diagnostic Tear-Down Procedure
  • Automatic Transmission - Diagnostic Teardown Procedure
  • A/T - Diagnostic Teardown Procedure
  • A/T - MIL ON/DTC P1776 Set
  • Engine Control - Generic PCM Programming Procedure
  • A/T - MIL ON/DTC P1776 (Solenoid Switch Valve)
  • Engine Controls - Generic PCM Programming
  • Engine Controls - Generic PCM Programming Procedures
  • Engine Controls - Co-Pilot Support/Cable Selection
  • Engine Controls - Programming a Generic PCM
  • Engine Controls - PCM Initialization After Replacement
  • Engine Controls - PCM Initialization Procedure
  • A/C - Musty Odors When Hot or Humid
  • Wheels - Chrome Wheel Care
  • A/T - ATF Usage List
  • Drivetrain - Differential Fluid Level Inspection
• All Technical Service Bulletins
  • Body/Frame - Welded Sheet Metal Repairs And Replacements
  • Body - Don't Apply Corrosion Protection On Plastic Panels
  • Body - Front Bumper Fascia Repair For License Bracket Holes
  • M/T - Diagnostic Teardown Procedure
  • Collision - Safety Cert./Tire Press. Label Replacement
  • Steering/Suspension - Wheel Hub/Bearing Inspection COLL.
  • Body - Light To Moderate Paint Imperfections
  • Wheels - Reconditioned Wheel Usage
  • Restraints - Replacement Seat Covers/Seat Cover Repairs
  • Restraints - Use Of Salvaged Restraint System Components
  • Body/Frame - Structural Repair Components
  • Body/Frame - Usage Of Heat For Repair
  • A/C - System Sealer Usage Prohibition
  • Wheels - Caring for Chrome Wheels
  • A/T - 45RFE/545RFE Delayed Engage After Filter R and R
  • A/T/Engine Controls - False Solenoid DTC's Set
  • Engine Controls - Idle Undershoot
  • Engine Controls - 42RLE A/T Slow/Harsh/Delayed Shifts
  • Engine Controls - Stumble/Hesitation/False DTC's
  • Engine Controls - MIL ON/DTC's P2097/P2099 Set
  • A/T - 4th Gear Lock Up Shudder
  • Engine Controls - Flash Programming Failure Recovery
    • Overview
    • Connected/Disconnected Flash Mode Using TechCONNECT
    • Pay Attention While Performing Flash Reprogram Procedures
    • Error Messages
    • Enhanced and Original Abort Recovery
    • Enhanced Abort Recovery Screens
    • Original Abort Recovery Screen
    • Programmable Modules
    • Powertrain Modules - Engine and Transmission
  • Audio System - Intermittent Loss of Audio
  • Recall - Windshield Wiper Motor Defect
    • Overview
    • Service Procedure
    • Owner Letter
  • Recall 04V216000: Wiper Module Replacement
  • Safety Systems - Inadvertent Damage/Disabling
  • Electrical - Radio Equipment Installation Recommendation
  • A/T - 42RLE MIL ON/Multiple DTC's Set
    • Overview
    • AN/HB/ND Repair Procedure
    • KJ Repair Procedure
    • LX Repair Procedure
    • TJ Repair Procedure
    • Wiring Harness and Solenoid Repair Procedure
  • Engine Controls - Co-Pilot Support/Correct Cable Usage
  • Wipers/Washers - Wipers Smear or Streak Windshield
  • Audio System - CD Changer Operation/Features
  • A/T - ATF+4 Fluid Usage/Applications
  • A/C - Water Leaks Onto Passenger Front Floor
  • Steering - Power Steering Fluid Usage
  • Engine Controls - MIL ON/DTC P1776 Set
  • A/C - Musty Odors When Hot/Humid
    • Overview
    • AB/CS/LX/RS/WK/XK Vehicle Procedure
    • AN/DN/DR/HB/JR/KJ/LH/ND/PL/PT/TJ/WG/WJ Vehicles Procedure
    • ST Vehicle Procedure
    • VA Vehicle Procedure
  • Differential - Fluid Level Inspection Procedure
  • Engine Control - PCM Initialization Procedure
  • Audio System - Cell Phone Induced Clicking From Speakers
  • Engine Controls - Programming Generic PCMs
  • A/T - ATF + 4 Fluid Usage
  • Emissions - PCV System Freezes in Extreme Cold
  • A/T - Repair/Replacement Guidelines
    • Overview
    • Repair Procedure
      • Information
      • 40TE, 41TE/AE, 42LE/RLE and 62TE Transmissions
      • 30RH, 30TH, 31TH, 32RH, 36RH, 42RE/RH, 46RE/RH, 47RE and 48RE
      • 45RFE/545RFE and 68RFE Transmissions
      • NAG1 Transmissions
  • Engine Controls - MIL ON/DTC's P0340/P0344 Set
  • Engine Controls - Low Power In Rev./MIL/DTCs P1713/P1776
  • Body - Paint Overspray Removal Procedures
  • A/T - MIL ON, DTC P1776 Set
  • Paint - Clearcoat Blending During Refinish Process