Powertrain Management: Technical Service Bulletins

• Recalls
  • Recall Supplement 1 - Fuel/Exhaust/Cooling Modification
    • Overview
    • Supplemental Technical Notes
      • Assistance Hotline, Warnings, Disabled Thermactor System & Voltage Check Information
      • Precautions, Instructions, Revised & Corrected Instructions & Installing Fuel Instruments
      • Fuel Tanks or Fuel Filler Pipes & Special Instructions Information
      • Fleetwood Technical Assistance
  • Recall 82V124001: Fuel Pump Diode Defect
  • Recall 82V124000: Fuel Pump Circuit Modification
  • Recall 87V113000: EVAP System Modification
  • Recall 87V144000: Fuel System Modification
  • Recall 85V061000: Fuel/Water Separator Shield
• Customer Interest
  • Fuel Pump - Buzzing/Humming After Engine Shut Down
  • EGR Valve/Engine - Piston Slap Noise
  • EGR Valve/Engine - Piston Slap
  • Engine - Spark Knock/Detonation
  • EVP Sensor - Rough Engine Idle/Stalling
  • Instrument Cluster Warning Lights - Dimly Lit
  • Ignition System - Weak/No Spark
  • Engine/Ignition - No Start Condition
  • Ignition Coil - Stumbles/Stalls/Noise In Radio
  • Accelerator Linkage - Raspy/Sticky
  • Engine - Rough Idle/Noise
  • Air Injection - Heavy White Exhaust Smoke
  • Carburetor - Hard Start Flooding or Rough Idle
• By Symptom
  • Abnormal wear/deterioration
    • Engine/Ignition - No Start Condition
  • Customer Interest
    • Fuel Pump - Buzzing/Humming After Engine Shut Down
    • EGR Valve/Engine - Piston Slap Noise
    • EGR Valve/Engine - Piston Slap
    • Engine - Spark Knock/Detonation
    • EVP Sensor - Rough Engine Idle/Stalling
    • Instrument Cluster Warning Lights - Dimly Lit
    • Ignition System - Weak/No Spark
    • Engine/Ignition - No Start Condition
    • Ignition Coil - Stumbles/Stalls/Noise In Radio
    • Accelerator Linkage - Raspy/Sticky
    • Engine - Rough Idle/Noise
    • Air Injection - Heavy White Exhaust Smoke
    • Carburetor - Hard Start Flooding or Rough Idle
  • Driveability
    • EVP Sensor - Rough Engine Idle/Stalling
    • Ignition Coil - Stumbles/Stalls/Noise In Radio
    • Engine - Rough Idle/Noise
    • Carburetor - Hard Start Flooding or Rough Idle
  • False instrument warning light/gauges
    • Instrument Cluster Warning Lights - Dimly Lit
  • Low, Dead battery
    • Fuel Pump - Buzzing/Humming After Engine Shut Down
  • Noise
    • Fuel Pump - Buzzing/Humming After Engine Shut Down
    • EGR Valve/Engine - Piston Slap Noise
    • EGR Valve/Engine - Piston Slap
    • Engine - Spark Knock/Detonation
    • Engine - Rough Idle/Noise
  • Recalls
    • Recall Supplement 1 - Fuel/Exhaust/Cooling Modification
      • Overview
      • Supplemental Technical Notes
        • Assistance Hotline, Warnings, Disabled Thermactor System & Voltage Check Information
        • Precautions, Instructions, Revised & Corrected Instructions & Installing Fuel Instruments
        • Fuel Tanks or Fuel Filler Pipes & Special Instructions Information
        • Fleetwood Technical Assistance
    • Recall 82V124001: Fuel Pump Diode Defect
    • Recall 82V124000: Fuel Pump Circuit Modification
    • Recall 87V113000: EVAP System Modification
    • Recall 87V144000: Fuel System Modification
    • Recall 85V061000: Fuel/Water Separator Shield
  • Shorted/Open circuit
    • Ignition System - Weak/No Spark
  • Smoke, Fumes
    • Air Injection - Heavy White Exhaust Smoke
  • Starting problems
    • Fuel Pump - Buzzing/Humming After Engine Shut Down
    • Engine/Ignition - No Start Condition
    • Carburetor - Hard Start Flooding or Rough Idle
  • Sticking/Binding
    • Fuel Pump - Buzzing/Humming After Engine Shut Down
    • Accelerator Linkage - Raspy/Sticky
  • Weak Spark
    • Ignition System - Weak/No Spark
• All Technical Service Bulletins
  • Driveability TSB's - Summary
    • Overview
    • 1.3L
    • 1.6L
    • 1.6L EFI Turbo
    • 1.9L CFI
    • 1.9L EFI
    • 2.0L
    • 2.2L
    • 2.3L
    • 2.3L EFI Turbo
    • 2.3L HSC
    • 2.5L CFI
    • 2.5L HSC
    • 2.8L EFI
    • 2.9L EFI
    • 3.0L
    • 3.8L
    • 4.9L
    • 5.0L
    • 5.8L
    • 6.9L Diesel
    • 7.3L Diesel
    • 7.5L
  • Recall Supplement 1 - Fuel/Exhaust/Cooling Modification
    • Overview
    • Supplemental Technical Notes
      • Assistance Hotline, Warnings, Disabled Thermactor System & Voltage Check Information
      • Precautions, Instructions, Revised & Corrected Instructions & Installing Fuel Instruments
      • Fuel Tanks or Fuel Filler Pipes & Special Instructions Information
      • Fleetwood Technical Assistance
  • Fuel Pump - Buzzing/Humming After Engine Shut Down
  • TPS Mounting Screws - Hard to Remove
  • Fuel Filter - Replacement Information
  • Recall 82V124001: Fuel Pump Diode Defect
  • Recall 82V124000: Fuel Pump Circuit Modification
  • EGR Valve/Engine - Piston Slap Noise
  • EGR Valve/Engine - Piston Slap
  • High Altitude Service Adjustments
  • Fuel System - Injector Tester/Cleaner Service Tips
  • Engine - Spark Knock/Detonation
  • EVP Sensor - Rough Engine Idle/Stalling
  • EGR Solenoids - Contamination
  • Alternator - Replacement Precautions
  • Instrument Cluster Warning Lights - Dimly Lit
  • Ignition System Resistance - Manual Revision
  • Duraspark II Ignition - Revised Applications
  • TFI Module/PIP Sensor - New Diagnostic Procedure
    • Overview
    • Part 2 TFI-IV Ignition System With TFI Ignition Tester
      • Preliminary Checkout, Equipment & Notes
      • Functional Schematic
      • Ignition Coil Secondary Voltage (Crank Mode)
      • Wiring Harness
      • Stator - TFI
      • TFI Module
      • Ignition Coils - Secondary & Primary Resistance
      • EEC-IV - TFI-IV
      • Ignition Coil Supply Voltage
      • Wiring Harness
    • Part 2 TFI-IV Closed Bowl Distributor (With TFI Ignition Tester)
      • Preliminary Checkout, Equipment & Notes
      • Functional Schematic
      • Ignition Coil Secondary Voltage - Crank Mode
      • Wiring Harness
      • Stator
      • TFI Module
      • Ignition Coil, Primary & Secondary
      • EEC IV - Wiring
      • Wiring Harness
      • Ignition Coil, TFI & Stator Voltage
      • Wiring Harness
  • Ignition System - Weak/No Spark
  • Engine/Ignition - No Start Condition
  • Ignition - Coil Durability/Radio Frequency Interference
  • Ignition Coil - Stumbles/Stalls/Noise In Radio
  • Fuel Hoses - Special Material
  • Air Cleaner - Sealing Procedure
  • Accelerator Linkage - Raspy/Sticky
  • Exhaust Air Pump Assembly - Obsolete Part Return
  • Antitheft Devices - Installation Precautions
  • Specifications - Update
    • Overview
    • Section 1 General Information
    • Section 3 Passenger Car Calibration Specifications
      • 1.6L Engine
        • Calibration:2-03B-R11
        • Calibration:2-03B-R17
        • Calibration:2-03B-R18
        • Calibration:2-03B-R20
        • Calibration:3-03A-R12
        • Calibration:3-03A-R13
        • Calibration:3-03B-R00
        • Calibration:3-03A-R13
        • Calibration:3-03B-R10
        • Calibration:3-03C-R14
        • Calibration:3-03G-R11
        • Calibration:3-03H-R02
        • Calibration:3-03H-R02
        • Calibration:3-04A-R10
        • Calibration:3-04H-R00
        • Calibration:3-04H-R00
        • Calibration:3-04H-R00
        • Calibration:3-04H-R00
        • Calibration:3-04H-R00
        • Calibration:3-04Q-R12
        • Calibration:3-04Q-R12
        • Calibration:3-04T-R00
        • Calibration:3-04Y-R00
        • Calibration:3-04Y-R00
      • 2.3L Engine
        • Calibration:3-05A-R02
        • Calibration:3-05E-R10
        • Calibration:3-06N-R10
      • 3.3L Engine
        • Calibration:3-12J-R10
        • Calibration:3-12Q-R00
      • 3.8L Engine
        • Calibration:3-14A-R11
        • Calibration:3-14B-R00
        • Calibration:3-14B-R11
        • Calibration:3-14C-R00
        • Calibration:3-14C-R10
        • Calibration:3-14G-R00
        • Calibration:3-14G-R11
        • Calibration:3-14J-R00
        • Calibration:3-14N-R04
        • Calibration:3-14P-R10
        • Calibration:3-14P-R04
        • Calibration:3-14Q-R01
        • Calibration:3-14Q-R10
        • Calibration:3-14W-R10
      • 5.0L Engine
        • Calibration:2-20H-R00
        • Calibration:2-22A-R00
        • Calibration:2-22A-R15
        • Calibration:2-22A-R17
        • Calibration:2-22A-R19
        • Calibration:3-21A-R03
        • Calibration:2-22Y-R11
        • Calibration:3-21A-R11
        • Calibration:3-21A-R03
        • Calibration:3-21A-R11
        • Calibration:3-21A-R14
        • Calibration:3-21A-R14
        • Calibration:3-21P-R01
        • Calibration:3-21P-R01
        • Calibration:3-22D-R00
        • Calibration:3-22D-R00
        • Calibration:3-22W-R00
        • Calibration:3-22W-R00
    • Section 4 Truck Calibration Specifications
      • 2.3L Engine
        • Calibration:3-49G-R20
        • Calibration:3-49G-R20
        • Calibration:3-49H-R17
        • Calibration:3-49S-R16
        • Calibration:3-49T-R20
        • Calibration:3-49T-R20
        • Calibration:3-49Y-R19
        • Calibration:3-50H-R18
        • Calibration:3-50S-R18
        • Calibration:3-50Y-R18
      • 2.8L Engine
        • Calibration:4-61F-R00
        • Calibration:4-62D-R00
        • Calibration:4-62S-R01
        • Calibration:4-62S-R10
      • 5.8L Engine
        • Calibration:1-63T-R15B
        • Calibration:1-64T-R15B
        • Calibration:2-63Y-R14B
        • Calibration:2-64Y-R14B
    • Section 5 Liquid Propane Gas Calibration Specifications
    • Section 6 Diesel Calibration Specifications
      • 2.2L Engine
        • Calibration:3-47D-R00
        • Calibration:3-47D-R00
      • 6.9L Engine
        • Calibration:3-68J-R00
        • Calibration:3-68J-R10
  • Emissions Diagnosis - Manual Revisions
    • Overview
    • 2.3L Passenger Car (Sect. 18-28; 18-29; 18-32)
      • Fuel Always Lean
      • Fuel Always Rich
    • 2.0L/2.3L Truck (Sect. 16-26; 16-27; 16-31)
      • Fuel Always Lean
      • Fuel Always Rich
    • 4.9L Truck (Sect. 17-27; 17-28; 17-31)
      • Fuel Always Lean
      • Fuel Always Rich
  • Emission Control System - Technician's Glossary
    • 91FORD13 A
    • B
    • C
    • D
    • E
    • F
    • H
    • I
    • K
    • L
    • M
    • N
    • O
    • P
    • Q
    • R
    • S
    • T
    • U
    • V
    • W
    • Z
  • Recall 87V113000: EVAP System Modification
  • Recall 87V144000: Fuel System Modification
  • Diagnostic/Service Manual Updates
  • EEC IV - Invalid/Erratic Service Codes
  • Electronic Modules - Protection From Static Electricity
  • Electrical/Electronic/Fuel Induction - Glossary
    • Overview
    • A
    • B
    • C
    • D
    • E
    • F
    • G
    • H
    • I
    • J
    • K
    • L
    • M
    • N
    • O
    • P
    • Q
    • R
    • S
    • T
    • U
    • V
    • W
    • X
    • Z
  • Engine - Rough Idle/Noise
  • Fuel Tank Filler Cap - New Design Available
  • Recall 85V061000: Fuel/Water Separator Shield
  • Air Injection - Heavy White Exhaust Smoke
  • Carburetor - Hard Start Flooding or Rough Idle
  • Rotunda Gas Chek Kit - Requires Modification
  • Fuel - California Reformulated Gasoline