Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Recall - Front Door Latch Release Cable Replacement
- Recall 92V006000: Door Latch Release Cable Replacement
- Recall 93E039000: Incorrect Glass Markings
- Recall - Parking Brake Lock In Wedge Installation
- Recall 94V169000: Parking Brake Defect
- Recall 94V169001: Parking Brake Defect
- Customer Interest
- Brakes/Steering - Pull or Drift Diagnosis and Service
- Air Conditioning - Musty/Mildew Type Odors
- Power Steering System - Noisy
- Steering/Suspension - Pull/Drift Diagnostic Procedure
- Overview
- Service Procedure
- Pull Drift Diagnostic Procedure
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - Rbs Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Warranty Coding
- Engine - Hard Starting/Lack of Power
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Surge On Acceleration
- A/C and Accessory Drive Belt - Breakage/Squeal
- Defroster - Poor Performance
- Heater Core - Gurgling Sound When Cold
- Steering Gear - Leak At the Input Shaft
- Engine - Cooling Concerns and/or Vibration
- Accessory Drive Belt - Noise/Excessive Wear
- A/C - Poor Heating or Cooling Performance
- Heater - Low/No Heat When Set At Full Heat
- A/C - Low/No Heat/Stiff Control Operation
- Frame/Crossmember - Snapping/Popping Noise
- Ball Joint - Clunk Noise From Front End
- Chrome Wheels - Reddish 'Rusty' Appearance
- Frame - Popping or Creaking Noise
- Bumper - Rust Staining
- Overview
- 1997-98 Expedition/F-150/250 LD 4X4 Frnt. Bumper
- 1997-98 F-150/250 LD 4X2 Front Bumper
- 1997-98 F-150/250 LD Rear Bumper (4X2/4X4)
- 1990-97 F-250 HD/F-350/Bronco Frnt./Rear Bumper
- 1997-98 Expedition - Rear Bumper
- 1997 Explorer XLT/Eddie Bauer - Frnt. Bumper
- 1997 Explorer - Rear Bumper
- 1997 Econoline - Front Bumper
- Door Lock Cylinder - Loose in Replacement Door
- Driveline - Vibration/Noise at Highway Speeds
- A/T - Torque Converter Access Plug Dislodges
- Brake/Clutch Pedal Support - Excessive Wear/Lash
- PCM - MIL ON/Code 41 Set/No Driving Concerns
- PCM - MIL ON/Code 173 Set
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Electrical - Multiple Systems Malfunctions
- Rear Brakes - Grab When Cold
- Brakes - Sticking/Binding/Grabbing
- Alternator - Discharge
- Fuel Lines - Knocking Noises
- Heated Backlite - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Headlamp Housing - Melts
- Roof - Cosmetic Cracks In Seam Sealer
- Roof Sheet Metal - Cracks On Roof Panel
- Power Door Lock - Inoperative
- Steering/Suspension - Steady State Left Pull/Drift
- Steering - Pulls Left When Braking
- Differential - Chatter On Turns
- Door Trim Panel - Squeaks or Creaking Noise
- Front Seat Shoulder Safety Belts - Slow to Retract
- Door Glass - Separation of Door Glass From Glass Channel
- Rear View Mirror - Detaches From Windshield
- Accessory Drive Belt - Chirping Noise
- Exhaust System - Buzzing/Rattling Noise
- Parking Brake Control Assembly - Concerns
- A/T - E4OD Shift Concerns/DTC's Set
- Spark Plug Wire - Miss/Buck/Spark Knock
- A/T - Shift Selector Indicates Incorrect Gear
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Instrument Panel - Squeaking Noise
- Right Side Instrument Panel - Loose and Rattling
- Electrical Systems - Multiple Malfunctions
- Paint - Rough Texture and/or Orange/Rust Dots
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - E4OD No 2nd - 3rd Gear Upshift
- Wipers - Clicking During Intermittent Operation
- Front Seat - Clunks On Acceleration/Stops/Turns
- Transfer Case Shift Lever - Buzz/Rattle
- A/T - E40D Clunk Shifting to Drive or Reverse
- A/T - E4OD Vehicle Does Not Move
- Parking Brake Pedal - Goes to Floor With Little Effort
- Heater - Lack of Heat
- Seat - Front Passenger Seat Back Rattles or Squeaks
- Passenger Seat Back - Rattles When Unoccupied
- A/T - Low Transmission Fluid/Shift/Engagement Concerns
- Chemicals,Additives
- Bumper - Rust Staining
- Overview
- 1997-98 Expedition/F-150/250 LD 4X4 Frnt. Bumper
- 1997-98 F-150/250 LD 4X2 Front Bumper
- 1997-98 F-150/250 LD Rear Bumper (4X2/4X4)
- 1990-97 F-250 HD/F-350/Bronco Frnt./Rear Bumper
- 1997-98 Expedition - Rear Bumper
- 1997 Explorer XLT/Eddie Bauer - Frnt. Bumper
- 1997 Explorer - Rear Bumper
- 1997 Econoline - Front Bumper
- Rear View Mirror - Detaches From Windshield
- Bumper - Rust Staining
- Labor/Parts Updates
- A/C - Low/No Heat/Stiff Control Operation
- Ball Joint - Clunk Noise From Front End
- Driveline - Vibration/Noise at Highway Speeds
- Headlamp Housing - Melts
- Rear Anti-Lock Brakes - Adverse Characteristics
- Steering/Suspension - Steady State Left Pull/Drift
- A/T - E4OD Shift Concerns/DTC's Set
- Passenger Seat Back - Rattles When Unoccupied
- Recommended Repairs
- Bumper - Rust Staining
- Overview
- 1997-98 Expedition/F-150/250 LD 4X4 Frnt. Bumper
- 1997-98 F-150/250 LD 4X2 Front Bumper
- 1997-98 F-150/250 LD Rear Bumper (4X2/4X4)
- 1990-97 F-250 HD/F-350/Bronco Frnt./Rear Bumper
- 1997-98 Expedition - Rear Bumper
- 1997 Explorer XLT/Eddie Bauer - Frnt. Bumper
- 1997 Explorer - Rear Bumper
- 1997 Econoline - Front Bumper
- Bumper - Rust Staining
- Superceded Bulletins
- 911414 - 07/11/91
- 90148 - 07/05/90
- 90137 - 06/20/90
- 90119 - 05/23/90
- 87716 - 04/08/87
- Wiper Motor - Service Replacement
- Body - Roof Cracking
- Fiberglass Roof - Cosmetic Cracks
- Frame Rivets - Damaged/Loose
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- A/C System - Musty/Mildew Odors
- A/C Evaporator - Leak Test Required For Warranty Claim
- A/C - O Ring Removal From Spring Lock Coupling
- Frame - Popping/Creaking noise
- Frame/Suspension - Popping/Creaking Noise
- Frame - Rivet Replacement With Bolts, Service Tip
- Suspension - Clunk Noise From Ball Joints
- Power Steering Gear - Leak Fluid At the Input Shaft
- Power Steering Pump - Noise
- Power Steering Pump - Noisy
- Power Steering Pump - Noises
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Electrical - Wiring Harness Terminal Repair Kit
- Wire Harness - Terminal Repair Kits
- Wire Harness Terminal and Connector - Repair Kit
- Wire Harness - New Terminal Repair Kit
- Park Brake Pedal - Goes To Floor With Little/No Effort
- Parking Brake Pedal - Goes to the Floor On Application
- Park Brake Pedal - Goes to Floor W/Little or No Effort
- Brakes - Special Lubricant Requirements
- Front Brakes - Stick/Bind/Grab
- Transfer Case - Buzz or Rattle Through Shift Lever
- Driveline - Vibration/Noise
- Driveline - Noise/Vibration
- Driveline - Vibration or Noise
- A/T - E4OD Updated Parts Installation
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - E4OD MIL ON/Codes 62/628/1728 Set
- A/T - E4OD Internal Parts Usage Chart
- A/T - E4OD Parts Usage Chart
- A/T - E4OD Internal Part Usage Chart
- A/T - E40D Upgrade Components During Overhaul
- No 2nd - 3rd gear Upshift
- A/T- E4OD/4R100 Parts Usage Chart
- A/T - Fluid Level/Shift Concerns
- A/T - E4OD Clunk During Gear Engagement
- A/T - E4OD Internal Part Usage Table
- A/T - E4OD Accumulator Body Usage Chart
- A/T - A4LD Shift Position Indicator Misalignment
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel - Volatility Related Concerns
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Radio - Whine/Buzz
- Radio - Buzzing/Whining Noise
- Fuel Lines - Knocking Noise
- Deposit Resistant Fuel Injectors - ID and Application
- Fuel - Volatility Related Driveability Information
- A/T - E4OD MIL ON/DTC's 62/628/1728 Set
- EEC Processor - MIL ON/Code 41 In Continuous Memory
- Exhaust System - Buzz or Rattle Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Heater Core - Repeated Failure
- Cooling System - Diagnosis Procedure
- A/C System - New A/C Filter Kit
- A/C - New Filter to Prevent Compressor Damage
- A/C System - New Filter Kit
- Air Conditioning - Prevent Damage to Compressor
- Accessory Drive Belt - Intermittent Chirping Noise
- A/C Compressor - FX 15 Belt Noise/Failure
- A/C - Refrigerant Filtering Tips
- A/C Drive Belt - Squealing Noise
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Chrome Wheels - Reddish/Rusty Appearance
- Chrome Wheels - Red/Rusty Appearance
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- A/T - E4OD/4R100 Fluid In-Line Filter Kit
- Steering - Pull Or Drift Left
- Propylene Glycol Coolant - Recommendations
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - Filter Kit Installation After Replacing Compressor
- A/C Compressor Replacement - Refrigerant Filtering
- A/C System - Use of R12 Refrigerant Substitutes
- Air Conditioning - Filtering Refrigerant
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- Vehicle - Towing Guidelines
- Fuel Filter - Revised Scheduled Maintenance
- EEC IV Processor - MIL ON and Code 41 Set
- All Technical Service Bulletins
- Brakes/Steering - Pull or Drift Diagnosis and Service
- Vehicle - Towing Behind RVs Guidelines
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- Air Conditioning - Musty/Mildew Type Odors
- Air Conditioning - Return of Obsolete Filter Kits
- A/C - Filtering Refrigerant After Compressor Replacement
- Power Steering System - Noisy
- Steering/Suspension - Pull/Drift Diagnostic Procedure
- Overview
- Service Procedure
- Pull Drift Diagnostic Procedure
- Diagnostic Procedure # 1 - Tire Mismatch
- Diagnostic Procedure # 2 - Alignment
- Diagnostic Procedure # 3 - Tires
- Diagnostic Procedure # 4 Steering Gear Valve Off Center
- Diagnostic Procedure # 5 - Rbs Linkage
- Diagnostic Procedure # 6 - Brake Imbalance
- Diagnostic Procedure # 7 - Miscellaneous
- Warranty Coding
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Electrical - New Terminal Grease Released For Service
- Engine - Hard Starting/Lack of Power
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Surge On Acceleration
- A/C Compressor - Oil Recovery/Measuring Procedures
- A/C Compressor - Oil Recovery and Measuring Procedure
- A/C and Accessory Drive Belt - Breakage/Squeal
- Defroster - Poor Performance
- A/C Clutch - Slips At High Ambient Temperature
- A/C - Fixed Orifice Tube Color Code Revised
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Heater Core - Gurgling Sound When Cold
- Heater Core - Revised Removal/Installation Procedures
- Steering Gear - Leak At the Input Shaft
- Engine - Spark Knock Diagnostic Procedure
- Cooling System - New System Diagnostics
- Engine - Cooling Concerns and/or Vibration
- Accessory Drive Belt - Noise/Excessive Wear
- Air Conditioner Vacuum Tank - Replacement Tip
- A/C - Vacuum Tank Replacement Procedure
- A/C - Poor Heating or Cooling Performance
- Heater - Low/No Heat When Set At Full Heat
- A/C - Low/No Heat/Stiff Control Operation
- A/C - FX15 Clutch Application Chart
- Frame/Crossmember - Snapping/Popping Noise
- Ball Joint - Clunk Noise From Front End
- Chrome Wheels - Reddish 'Rusty' Appearance
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Frame - Popping or Creaking Noise
- Bumper - Rust Staining
- Overview
- 1997-98 Expedition/F-150/250 LD 4X4 Frnt. Bumper
- 1997-98 F-150/250 LD 4X2 Front Bumper
- 1997-98 F-150/250 LD Rear Bumper (4X2/4X4)
- 1990-97 F-250 HD/F-350/Bronco Frnt./Rear Bumper
- 1997-98 Expedition - Rear Bumper
- 1997 Explorer XLT/Eddie Bauer - Frnt. Bumper
- 1997 Explorer - Rear Bumper
- 1997 Econoline - Front Bumper
- Door Lock Cylinder - Loose in Replacement Door
- Driveline - Vibration/Noise at Highway Speeds
- Driveline - Modification Guidelines
- Overview
- Guidelines For Modifying Light Truck Drivelines
- Guideline - Driveline Balance
- Guideline - Runout Limits For an Unbalanced Driveshaft
- Coupling Shaft & Driveshaft Diameters, and Sizing
- Guideline - Driveline Angles
- Driveline Component Phasing
- List of "Things-Gone-Wrong"
- Further Discussion
- Multiple Driveshafts and System Balancing
- General Comments
- References
- Four Wheel Drive (4 X 4) - General Information
- A/T - E4OD Main Regulator Booster Service Tip
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T Torque Converter - Leak Test Procedure
- A/T - Torque Converter Access Plug Dislodges
- Brake/Clutch Pedal Support - Excessive Wear/Lash
- Universal Joint - Greasable Design Availability
- Deposit Resistant Fuel Injectors - Identification
- Fuel Injectors - Non Warranty Reimbursement Testing
- High Altitude Calibration Conversion
- PCM - MIL ON/Code 41 Set/No Driving Concerns
- PCM - MIL ON/Code 173 Set
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Electrical - Multiple Systems Malfunctions
- Heated Exhaust Gas Oxygen Sensor - Application Chart
- EGO Sensors - Silicone Contamination
- Rear Brakes - Grab When Cold
- Brake Computer Module - Obsolete Service Part Return
- Antilock Brakes - Service Tips
- Brakes - Sticking/Binding/Grabbing
- Alternator - Discharge
- Nylon Fuel Lines - Servicing Procedure
- Fuel Line - Disconnect Procedure
- Fuel Lines - Knocking Noises
- A/T - E4OD Turbocharger/Supercharger Incompatible
- Accelerator Cable - Service Procedures/Tips
- Heated Backlite - Inoperative
- Safety Belts - Front/Rear Twisted at `D' Ring
- Brake Rotor - Machining Equipment/Warranty Information
- Ignition System Diagnostics - Revision
- Overview
- 8A-1 Ignition System Application
- 8A-73 Mustang DIS No Start
- 8A-87 IDM Open, High or LT Coil Pack Failure, Code 218
- 8A-30 DIS No Start and/or Code 224 Coil Failure
- 8A-103 DIS Code 213/412 or No Code and Lack of Power
- 8A-175 SEFI-SHO and DIS Diagnostics By Code and Symptom
- 8A-179 SEFI Sc DIS No Start
- 8A-187 IDM Low or CID to DIS Open, Code 212
- SEFI Sc DIS Code: 215, 216 or 217 Coil Failure
- Horn - Service Procedure Revision
- Temperature Gauge - Reads Low/Erratic
- Headlamp Housing - Melts
- Wiper Motor - Upgraded Service Kits
- Engine - Revised Oil Pan Gasket Replacement Procedure
- ABS System - Component Location Revision
- Rear Anti-Lock Brakes - Adverse Characteristics
- Front Drive Axle - Identification Tags
- Roof - Cosmetic Cracks In Seam Sealer
- Roof Sheet Metal - Cracks On Roof Panel
- Antitheft System - Recap of TSB's/Service Tips
- Emission Control - Part/System Name Standardization
- MIL ON/No Codes Set Explanation
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- A/T - E4OD TCIL Flashing/DTC's 62/628/1728 Stored
- Power Door Lock - Inoperative
- Steering/Suspension - Steady State Left Pull/Drift
- Steering - Pulls Left When Braking
- Differential - Chatter On Turns
- Door Latch Release - Repair Kit Parts Purge
- Recall - Front Door Latch Release Cable Replacement
- Recall 92V006000: Door Latch Release Cable Replacement
- Door Trim Panel - Squeaks or Creaking Noise
- Front Seat Shoulder Safety Belts - Slow to Retract
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Recall 93E039000: Incorrect Glass Markings
- Door Glass - Separation of Door Glass From Glass Channel
- Rear View Mirror - Detaches From Windshield
- Rear View Mirror - Reattachment
- Motor Oil - Viscosity Grade Recommendation
- Accessory Drive Belt - Chirping Noise
- Cooling System - Proper Fluid Concentrations
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- Brake Hoses - Wet Appearance
- Parking Brake Control Assembly - Concerns
- A/T - E4OD/C6 Low One-Way Clutch Service Tips
- A/T - E4OD Intermediate Brake Drum Assembly Service Tip
- A/T - E4OD Direct Clutch Plate Usage Chart/Service Tip
- A/T - E40D Overdrive One Way Clutch Tips
- A/T - E4OD Reverse Clutch Piston and Seal Usage
- A/T - AOD Diagnostic Information
- A/T - E4OD Upgraded Transmission Components
- Overview
- Symptoms/Upgrades
- Overheating, Discoloration, Burned Clutches and Fluid
- Other Upgraded Components
- Case Bushing Wear and Sun Gear Bushing Wear
- Forward Clutch Spline Wear
- Failure Mode Effects Management (FMEM) Enhancements
- FIPL/TP Installation and Adjustments
- Aux. Oil Cooler Install Procedure 89-92 F-Series 7.3L Diesel
- 89-91 E-Series 7.3 Diesel 48 Plate Aux. Oil Cooler Installation
- 1992 E-Series 7.3 Diesel Aux. Oil Cooler Installation
- Front and Rear Case Bushings Removal & Installation
- Low One-Way Clutch Removal and Installation
- Warranty Information
- A/T - E40D Adhesive Repair Kit Availability
- A/T - E40D/ATX Transmission Exchange Program
- A/T - E4OD Upgrade Ball Bearing Center Support Kit
- A/T - E4OD Schematics Revision
- A/T - E40D Delayed Forward Engagement
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- A/T - AOD 3-4 Accumulator Change
- A/T - Check Ball Locations And Function
- A/T - Engine Vacuum Testing
- A/T - E40D Quick Tests
- A/T - AOD 4th Gear Complaints
- A/T - Delayed Engagement In Reverse and Drive
- A/T - Direct Clutch Failure/Excessive Case Bore Wear
- A/T - How To Use A Pressure Gauge
- A/T - E40D Burned Overdrive Section
- A/T - Buzzing Noise/Missing Cup Plugs
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - E40D Overdrive Sprag Rotation and Installation
- A/T - E40D Rebuild Tips
- A/T - E40D Check Ball Locations
- A/T - E40D Case Damage During Pump Removal
- A/T - E40D Indexing Manual Valve After Rebuild
- A/T - E40D Case, Separator Plate, and Valve Body I.D.
- A/T - Intermittent Electrical Problems
- A/T - E40D Intermediate Sprag Rotation
- A/T - E40D Front Seal Blow Out
- A/T - E40D Bellhousing Leaks
- A/T - E40D Overdrive Planetary Failure
- A/T - Failsafe Modes
- A/T - E40D No Converter Engage, 2nd and 4th Gear Starts
- A/T - Stacked Shifts/No Kickdown/OD Cancel Inoperative
- A/T - Preventing Front Planetary Gear Failure
- A/T - E40D Extension Housing Bushing Failure
- A/T - E40D No Upshifts or Harsh Upshifts/4th Gear Starts
- A/T - E40D Delayed Engagements
- A/T - E40D Vibration When TCC is Applied
- A/T - AODE Cooler Return Line Filter Installation
- A/T - E40D ATF Leaking Out Vent
- A/T - AOD Harsh 4-3 Kickdown/Valve Body Repair
- A/T - E40D Pump Upgrade
- A/T - E40D Pump Modifications
- A/T - E40D No Forward Engagement In O/D, 4-3 Flare Up
- A/T - Intermediate Accumulator Regulator Filter/Spring
- A/T - Delayed Engagement, Shift Errors, MLPS Codes
- A/T - E40D New Solenoid Bodies
- A/T - E40D Intermediate Servo Piston Redesigned
- A/T - E40D No Cooler Flow
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - C6 No. 9 Thrust Washer Failure
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - E4OD Description
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Mercon V ATF Usage
- A/T - E4OD Shift Concerns/DTC's Set
- Heater Control Knob - Obsolete Part Return
- Spark Plug Wire - Miss/Buck/Spark Knock
- A/T - Shift Selector Indicates Incorrect Gear
- A/C - FX 15 Compressor Clutch Shaft and Hub Assembly
- Speedometer - Recalibration Tips
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Instrument Panel - Squeaking Noise
- Right Side Instrument Panel - Loose and Rattling
- Engine - New Gasket Sealer
- Engine Harness - Connector Removal Procedures
- Wire Harness - Terminal Repair Kit
- A/T - E4OD Proper Stoplamp Circuit Splicing
- Fuel System - Fuel Stabilizer For Extended Storage
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Electrical Systems - Multiple Malfunctions
- Plastic Credit Card Keys - Cutting Procedure
- Paint Codes - New Identification Labels
- Paint - Preparation Procedure And MSDS Information
- Paint - Rough Texture and/or Orange/Rust Dots
- Exterior Paint - Comprehensive Repair Procedures
- Overview
- Section A Has Been Superseded By TSB # 9264, Dated 3/92.
- (B) Paint Exterior Color Peeling From Ultra Violet Light
- (C) Lower Body Stone Protection Repair Tips
- (D) Procedure For PVC Body Side Moldings
- (E) Lower Body-Side Stone Chip Protection Program
- (F) Surface Defect Removal Without Repainting
- (G) Color Compatible Spray Primer Chart
- (H) Paint Repair For Tinted Clear Coat
- (I) Paintable Plastics
- (J) 1992 Paint Color Codes
- Paint - Iron Particle Removal
- Electrical Diode - Identification and Replacement
- New Cylinder Head Bolt - Service Tips
- A/T - E40D Revised Rear Case Bushing
- Running Boards - Noise/Vibration Installation Tips
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - Main Controls/Separator Plate/Gaskets Usage
- A/T - E4OD No 2nd - 3rd Gear Upshift
- Wipers - Clicking During Intermittent Operation
- Recall - Parking Brake Lock In Wedge Installation
- Recall 94V169000: Parking Brake Defect
- Recall 94V169001: Parking Brake Defect
- A/T - E4OD Redesigned Intermediate Band Apply Servo
- Hood Lamp Switch - Revised
- Front Seat - Clunks On Acceleration/Stops/Turns
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- A/T - E4OD Upgraded Overdrive Planet Assembly
- Manual Transmission - Specification Revision
- Transfer Case Shift Lever - Buzz/Rattle
- Air Conditioning - O Ring Removal Service Tip
- A/C - New Refrigerant O-Rings
- A/C O Ring - Availability and Applications
- A/C - New O Ring Applications
- A/T - E40D Clunk Shifting to Drive or Reverse
- A/T - E4OD Vehicle Does Not Move
- A/C Instrument Panel Register - Vane Replacement
- Brakes - New Silicone Compound/Grease
- Parking Brake Pedal - Goes to Floor With Little Effort
- Parking Brake - Service Procedure
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- Front End Alignment - Service Procedures
- Heater - Lack of Heat
- A/C - Adding Refrigerant Oil Service Tip
- A/C Compressor - Service Tips
- Tailgate Applique - Cracks In Plastic Ford Letters
- Seat Leather - Cleaning Procedure Tips
- Seat - Front Passenger Seat Back Rattles or Squeaks
- Passenger Seat Back - Rattles When Unoccupied
- A/T - Low Transmission Fluid/Shift/Engagement Concerns
- M/T - Mercon(R) V ATF Usage Information