Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 96I003002: Drive Belt Detachment
- Recall 96I003000: Drive Belt Detachment
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Recall 94V018000: Front Bumper Arm Detachment
- Recall 96V064000: Seat Wire Harness Shorting
- Recall - Driver Side Power Seat Wiring Modification
- Recall 05V388000: Cruise Control Switch Replacement
- Recall 93V155000: Air Bag Monitor Defect
- Recall 93V184000: Non-Functional Air Bag Module
- Recall 93E039000: Incorrect Glass Markings
- Recall - Parking Brake Lock In Wedge Installation
- Recall 94V169000: Parking Brake Defect
- Recall 94V169001: Parking Brake Defect
- Recall 96V055010: Seat Frame Bolt defect
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Customer Interest
- Vehicle - Pull Or Drift Diagnostic/Service Procedures
- Air Conditioning - Musty/Mildew Type Odors
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Shudder/Vibration/Squealing Noise
- A/C - Insufficient Cooling/ Compressor Failure
- Defroster - Poor Performance
- A/C Plenum - Whistling Noise With Fan ON
- Accessory Drive Belt - Early Wear of Tensioner Pulley
- Engine - White Smoke Coming From Exhaust Pipe
- Heater - Low/No Heat When Set At Full Heat
- A/C - Low/No Heat/Stiff Control Operation
- Ball Joint - Clunk Noise From Front End
- Frame - Popping or Creaking Noise
- Door Lock Cylinder - Loose in Replacement Door
- Side Doors - Wind Noises
- A/T - Vibration/Shudder On Light Acceleration
- A/T - AODE Intermittent Loss of Torque at 3-4 Upshift
- A/T - Torque Converter Access Plug Dislodges
- Clutch - Hard to Depress/Premature Slave Cylinder Wear
- A/T - E4OD Downshifts Too Often/No 4th Gear
- Engine - Rattle/Clatter Noise On Cold Driveaway
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Electrical - Multiple Systems Malfunctions
- Engine - Lean Driveability Symptoms
- Alternator - Discharge
- Ignition Switch - Harness Connector Non-Mating
- Airbag System - Code 51 Diagnostics/Repair
- Headlamp Housing - Melts
- Electrical/Auxiliary Systems - Inoperative
- Differential - Chatter On Turns
- Door Trim Panel - Squeaks or Creaking Noise
- Exhaust System - Buzzing/Rattling Noise
- Parking Brake Control Assembly - Concerns
- A/T - AODE/4R70W Delayed or No Forward Engagement
- A/T - Shifts From Park Without Brake Pedal Depression
- A/T - E4OD Shift Concerns/DTC's Set
- A/T - 4R70W/AODE DTC's Set/Shift Concerns
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Right Side Instrument Panel - Loose and Rattling
- A/T - Inadvertent Shift Interlock Disabling
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - E4OD No 2nd - 3rd Gear Upshift
- A/T - 4R70W (Remanufactured) Delayed or No 2-3 Upshift
- A/T - AODE/4R70W Erratic/Prolonged 1-2 Shift
- Tailgate - Chucking/Squeak/Rattle On Bumps
- A/T - E4OD Vehicle Does Not Move
- Parking Brake Pedal - Goes to Floor With Little Effort
- Rear Jump Seat - Difficult to Fold Down to Flat Position
- Seat - Front Passenger Seat Back Rattles or Squeaks
- Labor/Parts Updates
- Superceded Bulletins
- 05S28S5 - 09/30/05
- 97-14-14 - 07/07/97
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Recall - Cruise Control Deactivation Switch/Fire Hazard
- Recall - Speed Control System Modification
- Recall - Cruise Control Deactivation Switch Defects
- Recall - Cruise Control Switch Modification
- Recall - Cruise Control Switch Defect/Fire Hazard
- Recall - Cruise Control Switch Defect
- Side Doors - Wind noise Service Tip
- Side Doors - Wind Noise Service Tip
- Side Door - Wind Noise Service Tips
- Side Doors - Wind Noise
- A/C - Musty and Mildew Type Odors
- A/C - Identification Of Non Approved Refrigerants
- Air Conditioning - Musty Odors
- A/C - Approved Flushing Procedures
- Defroster - Performance Enhancement
- Frame - Popping/Creaking noise
- Frame/Suspension - Popping/Creaking Noise
- Frame - Rivet Replacement With Bolts, Service Tip
- Suspension - Clunk Noise From Ball Joints
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Wire Harness - New Terminal Repair Kit
- Park Brake Pedal - Goes To Floor With Little/No Effort
- Brakes - Special Lubricant Requirements
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- On Vehicle Setup For Brake Rotor Machining
- Brakes - Rotor/Drum Sanding Elimination
- Front Brakes - Shudder/Squeal
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - E4OD MIL ON/Codes 62/628/1728 Set
- A/T - E4OD Internal Parts Usage Chart
- A/T - E4OD Parts Usage Chart
- A/T - E4OD Internal Part Usage Chart
- A/T- E4OD/4R100 Parts Usage Chart
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Brake Shift Interlock - Inadvertent Disabling
- A/T - Fluid Level/Shift Concerns
- A/T - AODE Transmission Pan Gasket/Reusable Design
- A/T - AODE/4R70W Forward Clutch Service Tip
- A/T - AODE/4R70W Main Control/Case Usage
- A/T - E4OD Internal Part Usage Table
- A/T - E4OD Accumulator Body Usage Chart
- PCM - Reprogramming Service Tip
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel Economy - Expectations Versus Usage
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- Fuel Pump - Buzz/Whine Through Radio Speakers
- Fuel Pump - Whine/Buzz Noise Heard In Speakers
- Fuel - Volatility Related Driveability Information
- A/T - E4OD MIL ON/DTC's 62/628/1728 Set
- PCM - Out Of Vehicle Reprogramming
- A/T - E4OD Erratic Upshifts/Downshifts
- Engine - High Pitched Rattle/Clatter Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Heater Core - Repeated Failure
- A/T - Fluid Application Charts
- Steering/Brakes - Pull Or Drift
- Brakes/Steering - Pull or Drift Diagnosis/Repair
- A/C - Refrigerant Filtering Tips
- A/C Compressor - Lack of Cooling/Failure
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Air Conditioning - Lack of Cooling/Compressor Failure
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- A/T - E4OD/4R100 Fluid In-Line Filter Kit
- Recycled Engine Coolant - Service Tip
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C - R134A Tracer Dye Factory Installed
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- A/C - Lack of Cooling/Compressor Failure
- All Technical Service Bulletins
- Vehicle - Towing Behind RVs Guidelines
- Vehicle - Pull Or Drift Diagnostic/Service Procedures
- A/C System - Service TSB List
- Air Conditioning - Musty/Mildew Type Odors
- A/C - Filtering Refrigerant After Compressor Replacement
- Recall 96I003002: Drive Belt Detachment
- Recall 96I003000: Drive Belt Detachment
- Electrical - New Terminal Grease Released For Service
- Throttle Position Sensor - Function and Diagnostic Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Shudder/Vibration/Squealing Noise
- A/C - Insufficient Cooling/ Compressor Failure
- Defroster - Poor Performance
- A/C Plenum - Whistling Noise With Fan ON
- A/C Evaporator Core - On Vehicle Leak Test Requirement
- Air Conditioning - Approved Flushing Procedures
- Heater Core - On Car Pressure Test For Warranty Claim
- Radiator - New Manufacturing Process
- Accessory Drive Belt - Early Wear of Tensioner Pulley
- Engine - White Smoke Coming From Exhaust Pipe
- Air Conditioner Vacuum Tank - Replacement Tip
- Heater - Low/No Heat When Set At Full Heat
- A/C - Low/No Heat/Stiff Control Operation
- Ball Joint - Clunk Noise From Front End
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Lug Nuts - Proper Installation/Torqueing Procedure
- Frame - Rivet Replacement with Bolts Service Tip
- Frame - Popping or Creaking Noise
- Front Bumper - New Torque Specification
- Recall 94V018000: Front Bumper Arm Detachment
- Door Lock Cylinder - Loose in Replacement Door
- Recall 96V064000: Seat Wire Harness Shorting
- Recall - Driver Side Power Seat Wiring Modification
- Side Doors - Wind Noises
- A/T - AODE/4R70W Reusable Pan Gasket/Filter
- A/T - Vibration/Shudder On Light Acceleration
- A/T - E4OD Main Regulator Booster Service Tip
- Torque Converter - Cleaning and Replacement Guidelines
- A/T - Cooler Flushing Service Tips
- A/T - AODE Intermittent Loss of Torque at 3-4 Upshift
- A/T Torque Converter - Leak Test Procedure
- A/T - Torque Converter Access Plug Dislodges
- Hydraulic Clutch - Bleeding Procedure Service Tips
- Clutch - Hard to Depress/Premature Slave Cylinder Wear
- Universal Joint - Greasable Design Availability
- Fuel Injectors - Non Warranty Reimbursement Testing
- A/T - E4OD Downshifts Too Often/No 4th Gear
- PCM - Reprogramming Tips
- Engine - Rattle/Clatter Noise On Cold Driveaway
- A/T - E4OD Harsh/Double Bump On Reverse Engagement
- Electrical - Multiple Systems Malfunctions
- Engine - Lean Driveability Symptoms
- Alternator - Discharge
- Ignition Switch - Harness Connector Non-Mating
- Campaign - Alarm System Update
- Accelerator Cable - Service Procedures/Tips
- Recall 05V388000: Cruise Control Switch Replacement
- Air Bag Modules - Discolored/Marred Covers
- Airbag System - Code 51 Diagnostics/Repair
- Campaign - Airbag Diagnostic Monitor Inspection
- Recall 93V155000: Air Bag Monitor Defect
- Recall 93V184000: Non-Functional Air Bag Module
- Brake Rotor - Machining Equipment/Warranty Information
- Brakes - Elimination Of Sanding Rotors And Drums
- Rotors - Caliper-Mount Lathe Machining Setup Procedure
- Hub-Mount Brake Rotor Machining Equipment
- Temperature Gauge - Reads Low/Erratic
- Headlamp Housing - Melts
- Wiper Motor - Upgraded Service Kits
- Sheet Molding Composite - Body Repair
- Electrical/Auxiliary Systems - Inoperative
- Antitheft System - Recap of TSB's/Service Tips
- EEC IV - Self Test Codes and MIL Service Tips
- Overview
- Overview of Three Digit EEC-IV Self-Test Codes
- 1) Technician Not Familiar With Self-Test Code Output
- 2) Inadvertent Erasure of Continuous Memory Self-Test Codes
- 3) Concern Setting Continious Memory Code Isn't Present
- 4) Grounded STO/MIL Circuit
- 5) Engine Running In Hlos
- 6) Misinterpretation of MIL Bulb Check
- 7) MIL Flashes During Self-Test
- 8) Processor KAM Is Erased or Fails
- 9) Damaged Star Tester
- 10) KOEO Processor Ram Test Failed
- 11) Intermittent VSS Fault Detected In Wiggle Mode
- 12) IDM Pulswidth Not Recognized By Processor (EDIS Vehicles)
- 13) Intermittent Ignition System Fault
- 14) Intermittent Open STI Circuit
- 15) Power Lost to EEC Processor
- 16) Other Warning Lamps Mistaken For MIL
- 17) Development Testing /Wrong Processor Released to Production
- A/T - E4OD TCIL Flashing/DTC's 62/628/1728 Stored
- Differential - Chatter On Turns
- Door Trim Panel - Squeaks or Creaking Noise
- Interior Door Trim Panel - Replacement Tip
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Recall 93E039000: Incorrect Glass Markings
- Rear View Mirror - Reattachment
- Engine - Revised Oil Fill Procedures
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- Parking Brake Control Assembly - Concerns
- A/T - AODE/4R70W Delayed or No Forward Engagement
- A/T - E4OD Intermediate Brake Drum Assembly Service Tip
- A/T - E4OD Direct Clutch Plate Usage Chart/Service Tip
- A/T - E40D Overdrive One Way Clutch Tips
- A/T - E4OD Reverse Clutch Piston and Seal Usage
- A/T - AODE/4R70W Revised Forward Clutch Service Tip
- A/T - E4OD Upgraded Transmission Components
- Overview
- Symptoms/Upgrades
- Overheating, Discoloration, Burned Clutches and Fluid
- Other Upgraded Components
- Case Bushing Wear and Sun Gear Bushing Wear
- Forward Clutch Spline Wear
- Failure Mode Effects Management (FMEM) Enhancements
- FIPL/TP Installation and Adjustments
- Aux. Oil Cooler Install Procedure 89-92 F-Series 7.3L Diesel
- 89-91 E-Series 7.3 Diesel 48 Plate Aux. Oil Cooler Installation
- 1992 E-Series 7.3 Diesel Aux. Oil Cooler Installation
- Front and Rear Case Bushings Removal & Installation
- Low One-Way Clutch Removal and Installation
- Warranty Information
- A/T - E4OD Upgrade Ball Bearing Center Support Kit
- A/T - E40D Delayed Forward Engagement
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - Shifts From Park Without Brake Pedal Depression
- A/T - In Line Fluid Filter Kit
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- A/T - Mercon V ATF Usage
- A/T - E4OD Shift Concerns/DTC's Set
- A/T - 4R70W/AODE DTC's Set/Shift Concerns
- A/T - E4OD New Design Transmission Range Sensor
- Speedometer/Odometer - (Programmable) Pointer Waiver
- Right Side Instrument Panel - Loose and Rattling
- Engine - New Gasket Sealer
- Wiring - Summary Of Possible Short Locations
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Remote Keyless Entry - Diagnostic Service Tips
- Keyless Entry System - Service Tips
- Paint - Preparation Procedure And MSDS Information
- Paint - Iron Particle Removal
- A/T - Inadvertent Shift Interlock Disabling
- Electrical Diode - Identification and Replacement
- A/T - E40D Revised Rear Case Bushing
- Running Boards - Noise/Vibration Installation Tips
- Steering Wheel - Clicking Noise Heard When Turning
- A/T - AODE/4R70W Service Tips
- A/T - Main Controls/Separator Plate/Gaskets Usage
- A/T - E4OD No 2nd - 3rd Gear Upshift
- Recall - Parking Brake Lock In Wedge Installation
- Recall 94V169000: Parking Brake Defect
- Recall 94V169001: Parking Brake Defect
- A/T - E4OD Redesigned Intermediate Band Apply Servo
- Hood Lamp Switch - Updated Replacement Part
- A/T - 4R70W (Remanufactured) Delayed or No 2-3 Upshift
- A/T - AODE/4R70W Erratic/Prolonged 1-2 Shift
- Campaign - Keyless Entry System Transmitters
- A/C - Increased Refrigerant Charge
- A/C - Release of R134a Fluorescent Dye
- A/C - Identification of Non Approved Refrigerants
- A/T - E4OD Upgraded Overdrive Planet Assembly
- Air Conditioning - O Ring Removal Service Tip
- A/C O Ring - Availability and Applications
- A/C - New O Ring Applications
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Tailgate - Chucking/Squeak/Rattle On Bumps
- A/T - E4OD Vehicle Does Not Move
- Brakes - New Silicone Compound/Grease
- Brakes - Vibration/Inspection Service Tips
- Parking Brake Pedal - Goes to Floor With Little Effort
- Parking Brake - Service Procedure
- A/C - Oil Visible At Spring Lock Couplers
- Fuel - California Reformulated Gasoline
- Fuel - Volatility Related Driveability Concerns
- A/C - Adding Refrigerant Oil Service Tip
- A/C - Refrigerant Oil Refill Capacity
- Tailgate Applique - Cracks In Plastic Ford Letters
- Seat Leather - Cleaning Procedure Tips
- Rear Jump Seat - Difficult to Fold Down to Flat Position
- Seat - Front Passenger Seat Back Rattles or Squeaks
- Recall 96V055010: Seat Frame Bolt defect
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter