Fuel Delivery and Air Induction: Technical Service Bulletins

• Recalls
  • Emissions
    • Recall - Fuel Filler Valve Replacement
      • Overview
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
        • Affected Vehicle Information
        • Fuel Line Venting Procedure
        • Crown Victoria
        • E-Series - BI-Fuel
        • E-Series - Dedicated
        • Expedition
        • F-Series - BI-Fuel
        • F-Series - Dedicated
        • Preparing Authorized Modifications Label
      • Attachment IV - New Part Procurement Process
      • Owner Letter - Federal Locations
      • Owner Letter - CA and Mass. Certified Vehicles
    • Recall - CNG Rear High Pressure Fuel Line Inspection
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor Allowances and Parts Ordering Information
      • Attachment III - Technical Information
      • Owner Letter - Registered In CA, MA, ME, NY and Vt Only
      • Owner Letter - Federal Customer
  • Generals
    • Campaign - Fuel Door Label Replacement
      • Information
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
      • Owner Letter
  • Safety
    • Recall 00V284000: Fuel System Non-Compliance
    • Recall 01V114000: Possible Fuel Tank Crack
• Customer Interest
  • Fuel Pump - Whine Heard Through Radio Speakers
  • Audio System - Whining/Buzzing Noise From Speakers
    • Overview
    • Service Procedure
  • Compuvalve - Rough Idle Speed/Stalls at Idle Speeds
  • Fuel System (CNG) - Rough Running/No Start
  • Fuel System (CNG/LPG) - No Start Condition
  • CNG Fuel System - Rough Idle/No Start Condition
  • CNG Fuel System - Hard Start/DTC's Set/Low Power
  • Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
  • CNG Fuel Fill Valve - Leaks/Fuel Odors
  • Fuel System - CNG Fuel Leak at Fill Valve
• By Symptom
  • Abnormal wear/deterioration
    • CNG Fuel System - Hard Start/DTC's Set/Low Power
  • Customer Interest
    • Fuel Pump - Whine Heard Through Radio Speakers
    • Audio System - Whining/Buzzing Noise From Speakers
      • Overview
      • Service Procedure
    • Compuvalve - Rough Idle Speed/Stalls at Idle Speeds
    • Fuel System (CNG) - Rough Running/No Start
    • Fuel System (CNG/LPG) - No Start Condition
    • CNG Fuel System - Rough Idle/No Start Condition
    • CNG Fuel System - Hard Start/DTC's Set/Low Power
    • Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
    • CNG Fuel Fill Valve - Leaks/Fuel Odors
    • Fuel System - CNG Fuel Leak at Fill Valve
  • Driveability
    • Fuel System (CNG) - Rough Running/No Start
    • CNG Fuel System - Rough Idle/No Start Condition
    • CNG Fuel System - Hard Start/DTC's Set/Low Power
  • Erratic Operation
    • CNG Fuel System - Hard Start/DTC's Set/Low Power
  • Leaks
    • Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
    • Fuel System - CNG Fuel Leak at Fill Valve
  • Noise
    • Fuel Pump - Whine Heard Through Radio Speakers
    • Audio System - Whining/Buzzing Noise From Speakers
      • Overview
      • Service Procedure
  • Recalls
    • Campaign - Fuel Door Label Replacement
      • Information
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
      • Owner Letter
    • Recall - Fuel Filler Valve Replacement
      • Overview
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor and Parts Information
      • Attachment III - Technical Information
        • Affected Vehicle Information
        • Fuel Line Venting Procedure
        • Crown Victoria
        • E-Series - BI-Fuel
        • E-Series - Dedicated
        • Expedition
        • F-Series - BI-Fuel
        • F-Series - Dedicated
        • Preparing Authorized Modifications Label
      • Attachment IV - New Part Procurement Process
      • Owner Letter - Federal Locations
      • Owner Letter - CA and Mass. Certified Vehicles
    • Recall 00V284000: Fuel System Non-Compliance
    • Recall - CNG Rear High Pressure Fuel Line Inspection
      • Dealer Letter
      • Attachment I - Administrative Information
      • Attachment II - Labor Allowances and Parts Ordering Information
      • Attachment III - Technical Information
      • Owner Letter - Registered In CA, MA, ME, NY and Vt Only
      • Owner Letter - Federal Customer
    • Recall 01V114000: Possible Fuel Tank Crack
  • Starting problems
    • Bi Fuel - Intermittent Starting or Driveability Tip
    • Fuel System (CNG) - Rough Running/No Start
    • Fuel System (CNG/LPG) - No Start Condition
• All Technical Service Bulletins
  • Driveability - Vacuum Leak Detection
  • Campaign - Fuel Door Label Replacement
    • Information
    • Dealer Letter
    • Attachment I - Administrative Information
    • Attachment II - Labor and Parts Information
    • Attachment III - Technical Information
    • Owner Letter
  • OBDII Diagnostic Monitor - Application Strategies
  • Bi Fuel - Intermittent Starting or Driveability Tip
  • Recall - Fuel Filler Valve Replacement
    • Overview
    • Dealer Letter
    • Attachment I - Administrative Information
    • Attachment II - Labor and Parts Information
    • Attachment III - Technical Information
      • Affected Vehicle Information
      • Fuel Line Venting Procedure
      • Crown Victoria
      • E-Series - BI-Fuel
      • E-Series - Dedicated
      • Expedition
      • F-Series - BI-Fuel
      • F-Series - Dedicated
      • Preparing Authorized Modifications Label
    • Attachment IV - New Part Procurement Process
    • Owner Letter - Federal Locations
    • Owner Letter - CA and Mass. Certified Vehicles
  • Recall 00V284000: Fuel System Non-Compliance
  • PCM - Bi-Fuel Reprogramming
  • Fuel Economy - Customer Expectation vs. Vehicle Usage
  • Fuel Pump - Whine Heard Through Radio Speakers
  • Audio System - Whining/Buzzing Noise From Speakers
    • Overview
    • Service Procedure
  • Compuvalve - Rough Idle Speed/Stalls at Idle Speeds
  • Fuel System (CNG) - Rough Running/No Start
  • Fuel System (CNG/LPG) - No Start Condition
  • CNG Fuel System - Rough Idle/No Start Condition
  • CNG Fuel System - Hard Start/DTC's Set/Low Power
  • Recall - CNG Rear High Pressure Fuel Line Inspection
    • Dealer Letter
    • Attachment I - Administrative Information
    • Attachment II - Labor Allowances and Parts Ordering Information
    • Attachment III - Technical Information
    • Owner Letter - Registered In CA, MA, ME, NY and Vt Only
    • Owner Letter - Federal Customer
  • Recall 01V114000: Possible Fuel Tank Crack
  • Fuel System - CNG Fuel Tank Inspection
    • Overview
    • Service Information
  • Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
  • CNG Fuel Fill Valve - Leaks/Fuel Odors
  • Bi-Fuel - Compuvalve Connecting/Disconnecting Procedure
  • Fuel System - CNG Fuel Leak at Fill Valve