Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 98V021000: Incorrect Safety Certification Label
- Recall 98V021000: Incorrect Tire Certification Label
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Recall 97V186000: Fuel Line Damage/Melting
- Recall 97V186001: Fuel Line Melting/Damaged
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Recall 99V204000: A/T Park Mechanism May Not Engage
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Customer Interest
- Cooling System - Lack of Heat/MIL ON/DTC P0125 Set
- Throttle Position Sensor - High Engine Idle Speed
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C Clutch - Loud Engagement Noise
- A/C - Condensate Drips Onto Passenger Floor
- A/T Cooler - Fluid Leaks at Radiator
- Leaf Springs - Vehicle Sits Low In Rear
- Suspension - Left Rear Side Of Vehicle Seems Low
- Side Doors - Wind Noises
- Steering Column - Clunking Felt Rocking Steering Wheel
- M/T Clutch - Hooting/Eeking/Moaning Noise
- A/T - 4R44E/5R55E OD Lamp Flashing/Codes Set
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine - Lean Driveability Symptoms
- MAF Sensor - Hesitation/Surge/DTC's P0102/P0103/MIL ON
- Speedometer/Odometer - Inaccurate/Inoperative
- Engine - No Start/Dead Battery/Corrosion At Battery Tray
- Engine - High Idle/MIL ON/DTC P0320 Set
- A/C Hose - Booming Noise At 2,500-3,000 RPM
- Body/Frame - Squeaking/Rattling Noise While in Motion
- Cab - Squeaking/Creaking Noise When Driving
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Body Wire Harness - Chafing/Driveability Concerns
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Windshield - Water Leaks
- Exhaust System - Buzzing/Rattling Noise
- Antitheft System - Alarm Sounds Inadvertently
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Radio - Poor Reception/Antenna Broken
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- Outside Door Handle - Excessive Lifting Effort
- A/T - 4R44E/5R55E Whistling/Hissing Noise At Idle
- Power Window - Downward Travel Is 1-5 Inches
- Interior - Driver/Passenger Seat Track Rattles
- M/T - M5OD Buzzing/Grinding Noise
- Power Windows - Chatter/Binding When Operating
- Power Windows - Chattering When Operated
- Tailgate - Squeaking/Binding Condition
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- A/C - Heater Core Electrolysis/Leakage
- Chemicals,Additives
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- Power Windows - Chatter In Down Mode
- Power Window - Chatter When Operating In Down Mode
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Interior - Front Seat Tracks Rattle
- Driver/Passenger Seat Track - Rattling Noise
- Paint - Materials For Warranty And Post Warranty Repair
- Outside Rearview Mirrors - Revised Service Parts
- Locks - Lock Service Package Availability
- Locks - Lock Service Kit Availability
- Locks - Lock Service Kits Availability
- Interior Trim - Repairs To Vinyl Surfaces
- Side Doors - Wind noise Service Tip
- Side Doors - Wind Noise Service Tip
- Side Door - Wind Noise Service Tips
- GEM Module - Multiple Electrical Faults
- Speedometer - Readings Inaccurate
- A/C - Identification Of Non Approved Refrigerants
- A/C - Condensate Drips Onto The Passenger Floor
- Suspension - Vehicle Sits Low In Rear
- Suspension - Left Rear Side Of Vehicle Appears Low
- Electrical - Wiring Soldering/Crimping Tips
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Brakes - Roughness/Vibration
- Brake Rotor - Hub Mounted Machining Equipment
- Driveline - Pinging/Creaking When Vehicle Put In Gear
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - Slipping Shifts/Delayed Engagements/DTC's Set
- Shift Interlock (BRAKE) - Inadvertent Disabling
- A/T - Fluid Leak At Radiator Oil Cooler
- Radiator - Transmission Fluid Leaks
- Speaker - Whining/Buzzing Noise
- Speakers - Whining/Buzzing Noise
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Speedometer - Inaccurate/MIL ON
- EVAP - MIL ON/DTC's P0442/P0455/No Driveability Concerns
- EVAP System - MIL ON/DTC's P0442/P0455 Stored
- Emissions - MIL ON/EVAP System DTC's Set
- PCM - Out Of Vehicle Reprogramming
- Exhaust System - Buzzing/Rattling Noises
- Temp Gauge/Cooling System - Fluctuates/Noise
- Heater Core - Repeated Failure
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- A/T - Slipping/Delayed Engagement/DTC P1762 Set
- Engine - Oil Recommendations/Applications
- Automatic Transmission - Fluid Usage Charts
- A/C - Identifying Non-Approved Refrigerants
- All Technical Service Bulletins
- Campaign - Revised Safety Certification Labels
- Cooling System - Lack of Heat/MIL ON/DTC P0125 Set
- A/C - Filtering Refrigerant After Compressor Replacement
- Driveability - Vacuum Leak Detection
- Electrical - New Terminal Grease Released For Service
- Throttle Position Sensor - High Engine Idle Speed
- Fuel Pump - Replacement Procedure
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C Clutch - Loud Engagement Noise
- A/C - Condensate Drips Onto Passenger Floor
- A/T Cooler - Fluid Leaks at Radiator
- Transmission Crossmember - New Service Kit
- Recall 98V021000: Incorrect Safety Certification Label
- Recall 98V021000: Incorrect Tire Certification Label
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Leaf Springs - Vehicle Sits Low In Rear
- Suspension - Left Rear Side Of Vehicle Seems Low
- Body - Frame Mounted Front Bumper Service
- Side Doors - Wind Noises
- Steering Column - Clunking Felt Rocking Steering Wheel
- M/T Clutch - Hooting/Eeking/Moaning Noise
- A/T - 4R44E/5R55E OD Lamp Flashing/Codes Set
- A/T - Cooler Flushing Service Tips
- Fuel Injectors - Non Warranty Reimbursement Testing
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - Reprogramming Out of Vehicle
- Emissions/Engine Controls - Driveability Diagnosis
- Engine - Lean Driveability Symptoms
- MAF Sensor - Hesitation/Surge/DTC's P0102/P0103/MIL ON
- Speedometer/Odometer - Inaccurate/Inoperative
- Engine - No Start/Dead Battery/Corrosion At Battery Tray
- Engine - High Idle/MIL ON/DTC P0320 Set
- Engine Controls - General PCM Programming Procedures
- Recall 97V186000: Fuel Line Damage/Melting
- Recall 97V186001: Fuel Line Melting/Damaged
- Hub-Mount Brake Rotor Machining Equipment
- A/C Hose - Booming Noise At 2,500-3,000 RPM
- Campaign - Four Wheel ABS Invoicing/Window Sticker
- Paint - Anti Chip Stone Abrasion Undercoat Service Tip
- Body/Frame - Squeaking/Rattling Noise While in Motion
- Cab - Squeaking/Creaking Noise When Driving
- Body - Structural Adhesive Recommendations
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Body Wire Harness - Chafing/Driveability Concerns
- A/T - Multiple DTC's Stored Diagnosis
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Interior Door Trim Panel - Replacement Tip
- Windshield - Water Leaks
- Campaign - Windshields Not Marked With AS1 Standard
- Outside Rearview Mirrors - Revised Service Part
- Mud Flaps - Difficult To Install, Service Tip
- Motor Oil - Viscosity Grade Recommendation
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- Exhaust System - Buzzing/Rattling Noise
- A/T - Cold Fluid Level Checking
- A/T - In Line Fluid Filter Kit
- A/T - Transmission Flush and Fill Tool Available
- Antitheft System - Alarm Sounds Inadvertently
- Recall 99V062001: Cruise Control Cables, Binding
- Recall - Speed Control Cable Replacement
- Overview
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Question and Answer Sheet
- Owner Letter
- Supplement # 1 - Dealer Letter
- Supplement # 1 - Attachment I
- Supplement # 1 - Attachment II
- Supplement # 1 - Attachment III
- Supplement # 2 - Dealer Letter
- Supplement # 2 - Attachment I
- Supplement # 2 - Attachment II
- Supplement # 2 - Attachment III
- Supplement # 2 - Owner Letter
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - New Gasket Sealer
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Keyless Entry System - Service Tips
- Radio - Poor Reception/Antenna Broken
- Interior Trim - Vinyl Surface Repair Tips
- Locks - Lock Service Packages Available
- Paint - Surface Defect Removal Without Repainting
- Paint - Materials For After Warranty/Warranty Repairs
- Paint - Rough Texture
- A/T - Inadvertent Shift Interlock Disabling
- Outside Door Handle - Excessive Lifting Effort
- A/T - 4R44E/5R55E Whistling/Hissing Noise At Idle
- GEM/CTM - Erroneous Trouble Codes
- Recall 99V204000: A/T Park Mechanism May Not Engage
- Power Window - Downward Travel Is 1-5 Inches
- Interior - Driver/Passenger Seat Track Rattles
- A/C - Identification of Non Approved Refrigerants
- M/T - M5OD Buzzing/Grinding Noise
- Power Windows - Chatter/Binding When Operating
- Power Windows - Chattering When Operated
- Tailgate - Squeaking/Binding Condition
- Brakes - Vibration/Inspection Service Tips
- Fuel - Volatility Related Driveability Concerns
- Steering/Suspension - Alignment Procedure Revision
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- Seat Leather - Cleaning Procedure Tips
- A/C - Heater Core Electrolysis/Leakage
- A/T - 5R44E/5R55E Part Level Change/Compatibility
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Comprehensive Noise/Vibration/Harshness Procedure
- Overview
- Description and Operation
- Diagnosis and Testing
- Overview
- Diagnostic Process
- 1. Customer Interview
- 2. Pre-Drive Check
- 3. Preparing For the Road Test
- 4. Verify the Customer Concern
- 5. Road Test
- 6. Check OASIS/TSBs/Repair History
- 7. Diagnostic Procedure
- NVH Condition and Symptom Categories
- Symptom Charts
- Pinpoint Tests
- Overview
- Pinpoint Test A: Brake Vibration/Shudder Diagnosis
- Pinpoint Test B: Engine Ticking Noise Diagnosis
- Pinpoint Test C:Front ENG. ACC. Drive (Fead) Bearing Hoot Diag.
- Pinpoint Test D: Power Steering Moan Diagnosis
- Pinpoint Test E: Engine Driven Cooling Fan Moan Diagnosis
- Pinpoint Test F: Drumming Noise Diagnosis
- Pinpoint Test G: Engine Ticking, Knock/Continuous Rattle Diag.
- Pinpoint Test H: Front Suspension Noise Diagnosis
- Pinpoint Test I: Rear Suspension Noise Diagnosis
- Pinpoint Test J: Wheel and Tire Diagnosis
- Pinpoint Test K: High Speed Shake or Shimmy Diagnosis
- Pinpoint Test L: Clutch Vibration
- Pinpoint Test M: Transfer Case Vibration
- Component Tests
- Tire Wear Patterns & Frequency Calculations
- General Procedures