Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall 00V115000: Rear Wheel Attaching Studs
- Recall - Cracked Fuel Tanks, Incorrect VIN's Listed
- Recall 01V114000: Possible Fuel Tank Crack
- Recall 07V336000: Cruise Control Fire Hazard
- Recall 08V051000: Incorrect Speed Control Jumper Harness
- Recall - Cruise Control Switch Jumper Harness
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating
- Customer Interest
- HVAC - Blower Motor Inoperable or Functions On 1 Speed
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Frame - Creaking Noise/Cracked
- Rear Axle, Dana 80,- Whine Noise
- A/T - Torque Converter Access Plug Dislodges
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- Differential - Chattering On Turns
- Driveline - Clunk/Bump When Starting From A Stop
- Driveline - Clunk/Bump Starting From A Stop
- Front Door - Inner/Outer Panel Separation
- Restraints - Seat Belts Slow to Retract
- A/T - 4R70W Ticking Noise In 1ST Gear
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- Steering/Suspension - Apparent 'Dogtracking'
- A/C - Heater Core Electrolysis/Leakage
- Restraints - Air Bag Lamp ON/DTC's B1876/B1880/B1920
- Starting System- No Crank Condition
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Steering/Brakes - Brake Pedal Kick-Back/Grabbing
- Engine - Spark Knock on Light Load/Acceleration
- Factory Modifications
- Recommended Repairs
- Superceded Bulletins
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Restraint System - Seat Belts Slow to retract
- Air Bag System - Lamp ON/Multiple DTC's Set
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Recall - Incorrect Cruise Control Jumper Harness
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- EVAP System - MIL ON Multiple DTC's Set
- Electrical/SRS - Air Bag Lamp ON/DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Electrical - Air Bag Lamp ON/Multiple DTC's Set
- Emissions - MIL ON/EVAP System DTC's Set
- Speedo Inaccurate/Inoperative, 4x4 lamp luminates/DTCs
- PCM - DTC's P1635 or P1639 Set/4X4 Lamp ON
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- A/T - E4OD/4R100 In Line Filter Kit Tips
- A/T - E4OD/4R100 Fluid In-Line Filter Kit
- Alignment/Suspension - ``Dogtracking'' Condition
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- HVAC - Blower Motor Inoperable or Functions On 1 Speed
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- Frame - Creaking Noise/Cracked
- Wheels/Tires - Road Force Measurement Equipment
- Recall 00V115000: Rear Wheel Attaching Studs
- Rear Axle, Dana 80,- Whine Noise
- A/T - Cooler Flushing Service Tips
- A/T - Torque Converter Access Plug Dislodges
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - DTC P1635 Set After PCM/IC Replacement
- Emissions/Engine Controls - Driveability Diagnosis
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- Recall - Cracked Fuel Tanks, Incorrect VIN's Listed
- Recall 01V114000: Possible Fuel Tank Crack
- Engine Head Gasket - Approved Replacement Procedures
- Campaign - Axle Pivot Bracket Defect
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- Engine Controls - MIL ON/Lean DTC Service Tips
- Differential - Chattering On Turns
- Driveline - Clunk/Bump When Starting From A Stop
- Driveline - Clunk/Bump Starting From A Stop
- Front Door - Inner/Outer Panel Separation
- Restraints - Seat Belts Slow to Retract
- Engine Oil - Oil Recommendations/Applications
- A/T - 4R70W Ticking Noise In 1ST Gear
- A/T - 4R70W Green Service Tag Service procedure
- A/T - 4R100 Orange Service Tag Service Procedure
- A/T - Mercon V ATF Usage
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Locks - Lock Service Packages Available
- A/T - Inadvertent Shift Interlock Disabling
- A/C - Identification of Non Approved Refrigerants
- A/T - 4R70W Clunk Noise on 2nd to 1st Gear Downshift
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Brakes - Vibration/Inspection Service Tips
- Steering/Suspension - Apparent 'Dogtracking'
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Restraints - Air Bag Lamp ON/DTC's B1876/B1880/B1920
- Starting System- No Crank Condition
- Lighting - Addition of Bulbs to Turn/Hazard Flashers
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Steering/Brakes - Brake Pedal Kick-Back/Grabbing
- Recall 07V336000: Cruise Control Fire Hazard
- Engine - Spark Knock on Light Load/Acceleration
- Recall 08V051000: Incorrect Speed Control Jumper Harness
- Recall - Cruise Control Switch Jumper Harness
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating