Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Safety
- Recall - Lug Nut Procedure and Torque Specification
- Recall 00V170000: Master Cylinder Pushrod Retaining Clip
- Recall - Fuel System Integrity
- Recall 99V265000: Accelerator Cable and Throttle Body
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Recall 06V286000: Cruise Control Switch Fire Hazard
- Recall 00V228001: Seat Belt Buckle Defect
- Recall - Seat Belt Buckle Inspection/Replacement
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Pad/Caliper Rattle on Bumps
- Engine - Rough Idle/Noise When Cold
- A/C - Thumping Noise On Cold Engine Start-up
- Steering/Suspension - Stiff, Wandering
- A/T Cooler - Fluid Leaks at Radiator
- Exhaust System - 'Miss' Sound From Exhaust
- Suspension - Vehicle Leans/Sags To One Side
- A/T - Torque Converter Access Plug Dislodges
- Engine Controls - Rough Idle/Hesitation
- Starting System - No Start/Repeat Starter Failure
- PCM - MIL ON, DTC's P0350/P0360 Set
- PCM - Low Power In Reverse Gear
- Body - Water Leaks From Roof Flange Area
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- Driveline - Clunk/Bump When Starting From A Stop
- Driveline - Clunk/Bump Starting From A Stop
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Trailer Tow Wiring - Difficult To Locate
- A/T - Inadvertent Shift Interlock Disabling
- Tailgate - Squeaking/Binding Condition
- A/C - Heater Core Electrolysis/Leakage
- Drivetrain - Drive-Away Shudder/Vibration
- Body - Running Board Corrosion
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Exhaust System - Broken Exhaust Manifold Studs
- Factory Modifications
- Superceded Bulletins
- Rear Inner Fender Well - Dented or Dinged
- Front Wipers - Operate While Switch is in OFF Position
- Front Wipers - Operate While Switch Is In Off Position
- Lighting - Adding Additional Turn Signal/Hazard Bulbs
- Lighting - Additional Turn Signal/Hazard Flasher Bulbs
- Lighting - Addition of Hazard/Turn Signal Bulbs
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Recall - Cruise Control Deactivation Switch/Fire Hazard
- Recall - Speed Control System Modification
- Recall - Cruise Control Deactivation Switch Defects
- Parking Assist System - False Tone Activation
- Passive Antitheft System (PATS) - Diagnostics Tips
- Restraint System - Seat Belts Slow to retract
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Turn Signals/Hazard Flashers - Bulb Addition
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- Drivetrain - Drive Away Shudder/Vibration
- Drivetrain - Driveaway Shudder or Vibration
- A/T - New Transmission Cooler Flusher/Service Tip
- Shift Interlock (BRAKE) - Inadvertent Disabling
- Starting System - Starter Failure/Ignition Lock Sticking
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- Heater Core - Repeated Failure
- Engine - Cylinder Head Straightedge Flatness Check
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- A/T - E4OD/4R100 In Line Filter Kit Tips
- A/T - E4OD/4R100 Fluid In-Line Filter Kit
- Engine - Oil Recommendations/Applications
- Ignition System - Engine Misfire Diagnostics Tips
- Ignition System - Engine Misfire Diagnostic Tips
- Engine - Cylinder Head Spark Plug Thread Repair
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- Driveability - Vacuum Leak Detection
- Aluminum Engine - New Cleaners/Service Tips
- Campaign - Missing Engine Information label
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Front Brakes - Pad/Caliper Rattle on Bumps
- Engine - Rough Idle/Noise When Cold
- A/C - Thumping Noise On Cold Engine Start-up
- Steering/Suspension - Stiff, Wandering
- Engine - Aluminum Block/Head Machining
- Engine - Cylinder Head Straightedge Surface Check
- A/T Cooler - Fluid Leaks at Radiator
- Exhaust System - 'Miss' Sound From Exhaust
- Campaign - Engine Oil Cooler Inspection/Replacement
- Wheels/Tires - Road Force Measurement Equipment
- Suspension - Vehicle Leans/Sags To One Side
- Recall - Lug Nut Procedure and Torque Specification
- A/T - Cooler Flushing Service Tips
- A/T - Torque Converter Access Plug Dislodges
- Emissions/Engine Controls - Driveability Diagnosis
- Engine Controls - Rough Idle/Hesitation
- Recall 00V170000: Master Cylinder Pushrod Retaining Clip
- Starting System - No Start/Repeat Starter Failure
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- PCM - MIL ON, DTC's P0350/P0360 Set
- PCM - Low Power In Reverse Gear
- Engine Controls - General PCM Programming Procedures
- Recall - Fuel System Integrity
- Recall 99V265000: Accelerator Cable and Throttle Body
- Restraints - Seat Belt Stop Button Service
- Brake Rotor - Incorrect Discard Thickness Specification
- Recall 01V258000: Wiper Motor Gear Case Cover
- Recall - Defective Wiper Motor Switch/Gear Cover
- Engine Head Gasket - Approved Replacement Procedures
- Body - Water Leaks From Roof Flange Area
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- LPG - Parameter Identification Data Input and Output
- Engine Controls - MIL ON/Lean DTC Service Tips
- Driveline - Clunk/Bump When Starting From A Stop
- Driveline - Clunk/Bump Starting From A Stop
- Body - Corrosion At Bottom of Door or Tailgate
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - 4R100 Orange Service Tag Service Procedure
- A/T - In Line Fluid Filter Kit
- A/T - (4R100) Fluid Overheats, Updated Cooler
- Recall 06V286000: Cruise Control Switch Fire Hazard
- A/T - Mercon V ATF Usage
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Trailer Tow Wiring - Difficult To Locate
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Bi Fuel System - Component Identification
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Locks - Lock Service Packages Available
- A/T - Inadvertent Shift Interlock Disabling
- Hood Lamp Switch - Updated Replacement Part
- A/C - Identification of Non Approved Refrigerants
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Recall 00V228001: Seat Belt Buckle Defect
- Recall - Seat Belt Buckle Inspection/Replacement
- Tailgate - Squeaking/Binding Condition
- Brakes - Vibration/Inspection Service Tips
- Bi-Fuel System - Compuvalve Replacement
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Lighting - Addition of Bulbs to Turn/Hazard Flashers
- Drivetrain - Drive-Away Shudder/Vibration
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Body - Running Board Corrosion
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Recall 07V336000: Cruise Control Fire Hazard
- Engine - Spark Plug Hole Thread Repair Procedure
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Recall 09V399000: Cruise Control Deactivation Switch
- Recall - Cruise Control Deactivation Switch Overheating
- Exhaust System - Broken Exhaust Manifold Studs