Repair and Diagnosis
- A L L Diagnostic Trouble Codes ( DTC )
- Relays and Modules
- Relays and Modules - Accessories and Optional Equipment
- Relays and Modules - Body and Frame
- Relays and Modules - Brakes and Traction Control
- Relays and Modules - Cooling System
- Relays and Modules - Cruise Control
- Relays and Modules - HVAC
- Relays and Modules - Instrument Panel
- Relays and Modules - Lighting and Horns
- Relays and Modules - Power and Ground Distribution
- Relays and Modules - Powertrain Management
- Relays and Modules - Restraints and Safety Systems
- Relays and Modules - Starting and Charging
- Relays and Modules - Windows and Glass
- Relays and Modules - Wiper and Washer Systems
- Sensors and Switches
- Sensors and Switches - Body and Frame
- Sensors and Switches - Brakes and Traction Control
- Sensors and Switches - Cooling System
- Sensors and Switches - Cruise Control
- Sensors and Switches - Engine
- Sensors and Switches - HVAC
- Sensors and Switches - Instrument Panel
- Sensors and Switches - Lighting and Horns
- Sensors and Switches - Powertrain Management
- Sensors and Switches - Computers and Control Systems
- Air Flow Meter/Sensor
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Oil Pressure Sensor
- Oil Temperature Sensor For ECM
- Oxygen Sensor
- Pressure Feedback Exhaust Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Sensors and Switches - Emission Control Systems
- Sensors and Switches - Fuel Delivery and Air Induction
- Sensors and Switches - Ignition System
- Sensors and Switches - Computers and Control Systems
- Sensors and Switches - Restraints and Safety Systems
- Sensors and Switches - Starting and Charging
- Sensors and Switches - Steering and Suspension
- Sensors and Switches - Transmission and Drivetrain
- Sensors and Switches - Windows and Glass
- Sensors and Switches - Wiper and Washer Systems
- Maintenance
- Alignment
- Tune-up and Engine Performance Checks
- Timing Belt
- Timing Component Alignment Marks
- Drive Belt
- Filters
- Hoses
- Fluids
- Brake Bleeding
- Air Bag(s) Arming and Disarming
- Fuses and Circuit Breakers
- Service Reminder Indicators
- Wheels and Tires
- Vehicle Lifting
Service Precautions- Service Intervals
- Routine Service
- Special Operating Conditions T, I, D, O, E, S
- Normal Service
- 5000 MI or 8000 KM
- 10000 MI or 16000 KM
- 15000 MI or 24000 KM
- 20000 MI or 32000 KM
- 25000 MI or 40000 KM
- 30000 MI or 48000 KM
- 35000 MI or 56000 KM
- 40000 MI or 64000 KM
- 45000 MI or 72000 KM
- 50000 MI or 80000 KM
- 55000 MI or 88000 KM
- 60000 MI or 96000 KM
- 65000 MI or 104000 KM
- 70000 MI or 112000 KM
- 75000 MI or 120000 KM
- 80000 MI or 128000 KM
- 85000 MI or 136000 KM
- 90000 MI or 144000 KM
- 95000 MI or 152000 KM
- 100000 MI or 160000 KM
- 105000 MI or 168000 KM
- 110000 MI or 176000 KM
- 115000 MI or 184000 KM
- 120000 MI or 192000 KM
- 125000 MI or 200000 KM
- 130000 MI or 208000 KM
- 135000 MI or 216000 KM
- 140000 MI or 224000 KM
- 145000 MI or 232000 KM
- 150000 MI or 240000 KM
- Severe Service
- 3000 MI or 4800 KM
- 5000 MI or 8000 KM
- 6000 MI or 9600 KM
- 9000 MI or 14400 KM
- 10000 MI or 16000 KM
- 12000 MI or 19200 KM
- 15000 MI or 24000 KM
- 18000 MI or 28800 KM
- 20000 MI or 32000 KM
- 21000 MI or 33600 KM
- 24000 MI or 38400 KM
- 25000 MI or 40000 KM
- 27000 MI or 43200 KM
- 30000 MI or 48000 KM
- 33000 MI or 52800 KM
- 35000 MI or 56000 KM
- 36000 MI or 57600 KM
- 39000 MI or 62400 KM
- 40000 MI or 64000 KM
- 42000 MI or 67200 KM
- 45000 MI or 72000 KM
- 48000 MI or 76800 KM
- 50000 MI or 80000 KM
- 51000 MI or 81600 KM
- 54000 MI or 86400 KM
- 55000 MI or 88000 KM
- 57000 MI or 91200 KM
- 60000 MI or 96000 KM
- 63000 MI or 100800 KM
- 65000 MI or 104000 KM
- 66000 MI or 105600 KM
- 69000 MI or 110400 KM
- 70000 MI or 112000 KM
- 72000 MI or 115200 KM
- 75000 MI or 120000 KM
- 78000 MI or 124800 KM
- 80000 MI or 128000 KM
- 81000 MI or 129600 KM
- 84000 MI or 134400 KM
- 85000 MI or 136000 KM
- 87000 MI or 139200 KM
- 90000 MI or 144000 KM
- 93000 MI or 148800 KM
- 95000 MI or 152000 KM
- 96000 MI or 153600 KM
- 99000 MI or 158400 KM
- 100000 MI or 160000 KM
- 102000 MI or 163200 KM
- 105000 MI or 168000 KM
- 108000 MI or 172800 KM
- 110000 MI or 176000 KM
- 111000 MI or 177600 KM
- 114000 MI or 182400 KM
- 115000 MI or 184000 KM
- 117000 MI or 187200 KM
- 120000 MI or 192000 KM
- 123000 MI or 196800 KM
- 125000 MI or 200000 KM
- 126000 MI or 201600 KM
- 129000 MI or 206400 KM
- 130000 MI or 208000 KM
- 132000 MI or 211200 KM
- 135000 MI or 216000 KM
- 138000 MI or 220800 KM
- 140000 MI or 224000 KM
- 141000 MI or 225600 KM
- 144000 MI or 230400 KM
- 145000 MI or 232000 KM
- 147000 MI or 235200 KM
- 150000 MI or 240000 KM
Service and Repair
Technical Service Bulletins
- Engine, Cooling and Exhaust
- Engine
- Compression Check
- Camshaft, Lifters and Push Rods
- Cylinder Block Assembly
- Cylinder Head Assembly
- Drive Belts, Mounts, Brackets and Accessories
- Engine Lubrication
- Intake Manifold
- Lamps and Indicators - Engine
- Seals and Gaskets
- Sensors and Switches - Engine
- Timing Components
- Tune-up and Engine Performance Checks
- Water Pump
- Application and ID
Description and Operation
Testing and Inspection
Locations- Service and Repair
- Cylinder Heads
- Disassembly and Assembly of Sub-Assemblies
- Engine
- Engine System - General Information
Specifications- Technical Service Bulletins
Tools and Equipment
- Cooling System
- Coolant
- Coolant Reservoir
- Radiator Cooling Fan
- Engine - Coolant Temperature Sensor/Switch
- Fan Shroud
- Heater Core
- Heater Hose
- Lamps and Indicators - Cooling System
- Radiator
- Radiator Cap
- Radiator Hose
- Relays and Modules - Cooling System
- Sensors and Switches - Cooling System
- Temperature Gauge
- Thermostat
- Thermostat Housing
- Water Pump
- Description and Operation
- Testing and Inspection
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Exhaust System
- Technical Service Bulletins
- Engine
- Powertrain Management
- Relays and Modules - Powertrain Management
- Sensors and Switches - Powertrain Management
- Sensors and Switches - Computers and Control Systems
- Air Flow Meter/Sensor
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Oil Pressure Sensor
- Oil Temperature Sensor For ECM
- Oxygen Sensor
- Pressure Feedback Exhaust Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Sensors and Switches - Emission Control Systems
- Sensors and Switches - Fuel Delivery and Air Induction
- Sensors and Switches - Ignition System
- Sensors and Switches - Computers and Control Systems
- Tune-up and Engine Performance Checks
- Computers and Control Systems
- Air Flow Meter/Sensor
- Air Temperature Sensor ( Ambient / Intake )
- Auxiliary Air Valve (Idle Speed)
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Data Link Connector
- Engine Control Module
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Idle Speed/Throttle Actuator - Electronic
- Information Bus
- Knock Sensor
- Main Relay (Computer/Fuel System)
- Malfunction Indicator Lamp
- Oil Pressure Sensor
- Oil Temperature Sensor For ECM
- Oxygen Sensor
- Pressure Feedback Exhaust Sensor
- Relays and Modules - Computers and Control Systems
- Sensors and Switches - Computers and Control Systems
- Air Flow Meter/Sensor
- Camshaft Position Sensor
- Clutch Switch
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Fuel Pressure Sensor
- Fuel Tank Pressure Sensor
- Air Temperature Sensor ( Ambient / Intake )
- Knock Sensor
- Oil Pressure Sensor
- Oil Temperature Sensor For ECM
- Oxygen Sensor
- Pressure Feedback Exhaust Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Throttle Position Sensor
- Transmission Position Sensor/Switch
- Vehicle Speed Sensor
- Description and Operation
- Electronic Engine Control (EC) System
- PCM Inputs
- Camshaft Position Sensor
- Clutch Pedal Position/Park-Neutral Position Switches
- Crankshaft Position Sensor (Integrated Ignition Systems)
- Cylinder Head Temperature Sensor
- Engine Coolant Temperature
- Engine Oil Temperature
- Fuel Rail Pressure Sensor
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Knock Sensor
- Mass Air Flow Sensor
- Power Steering Pressure Sensor
- Power Steering Pressure Switch
- Throttle Position Sensor
- Vehicle Speed Sensor
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Reading Diagnostic Trouble Codes
- Performance Diagnostic Overview (Quick Test)
- Performance Diagnostic Procedures/Quick Test
- QT - Step 1: PCM Quick Test
- QT - Step 2: No DTC(s) Present Symptom Chart Index
- QT - Step 3: No DTC(s) Present Symptom Charts
- Chart 1 - Stalls After Start
- Chart 2 - Hard Start/Long Crank - Erratic Start/Erratic Crank
- Chart 3 - No Start, Normal Crank
- Chart 4 - Slow Return to Idle
- Chart 5 - Fast Idle, Diesels/Runs on
- Chart 6 - Low/Slow Idle, Deceleration
- Chart 7 - Backfires
- Chart 8 - Lack/Loss of Power
- Chart 9 - Spark Knock
- Chart 10 - Poor Fuel Economy
- Chart 11 - Emissions Compliance
- Chart 12 - MIL, TCIL, SIL,, Temp Warning/Check Fuel Cap Lamps
- Chart 13 - Upshift, Downshift, Engagement
- Chart 14 - Tachometer Inoperative
- Chart 15 - High Oil Consumption, Leaks
- Chart 16 - Electric Cooling Fan(s) Inop (Low and/or High Speed)
- Chart 17 - Electric Cooling Fan(s) Always Runs
- Chart 18 - Smoke
- Chart 19 - Odor, Engine Compartment
- Chart 20 - Engine Noise (Under Hood)
- Chart 21 - Climate Control
- Chart 22 - Odor (Sulfur, Rotten Egg Smell)
- Clearing Diagnostic Trouble Codes
- Reading Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- No-Start Testing
- QT: Step 1: PCM Quick Test
- Step 2: No DTC(s) Present Symptom Chart Index
- Step 3: No DTC(s) Present Symptom Charts
- Chart 1 - Stalls After Start
- Chart 2 - Hard Start/Long Crank - Erratic Start/Erratic Crank
- Chart 3 - No Start, Normal Crank
- Chart 4 - Slow Return to Idle
- Chart 5 - Fast Idle, Diesels/Runs on
- Chart 6 - Low/Slow Idle, Deceleration
- Chart 7 - Backfires
- Chart 8 - Lack/Loss of Power
- Chart 9 - Spark Knock
- Chart 10 - Poor Fuel Economy
- Chart 11 - Emissions Compliance
- Chart 12 - MIL, TCIL, SIL,, Temp Warning/Check Fuel Cap Lamps
- Chart 13 - Upshift, Downshift, Engagement
- Chart 14 - Tachometer Inoperative
- Chart 15 - High Oil Consumption, Leaks
- Chart 16 - Electric Cooling Fan(s) Inop (Low and/or High Speed)
- Chart 17 - Electric Cooling Fan(s) Always Runs
- Chart 18 - Smoke
- Chart 19 - Odor, Engine Compartment
- Chart 20 - Engine Noise (Under Hood)
- Chart 21 - Climate Control
- Chart 22 - Odor (Sulfur, Rotten Egg Smell)
- Pinpoint Tests
- Test A: No Start
- Test B: Electronic Engine Control (EC) Power Relay
- Test C: Reference Voltage
- Test H: Fuel Control
- Test X: Constant Control Relay Module (CCRM)
- Test Z: Intermittent
- Tests DA: Intake Air Temp. (IAT)/Engine Coolant Temp. (ECT) Sensors
- Tests DB: Engine Fuel Temperature (EFT) Sensor
- Tests DC: Mass Air Flow (MAF) Sensor
- Tests DD: Fuel Rail Pressure (FRP) Sensor
- Tests DE: Flexible Fuel (FF) Sensor
- Tests DF: Vehicle Speed Circuit Check
- Tests DG: Knock Sensor (KS)
- Tests DH: Throttle Position (TP) Sensor
- Tests DL: Cylinder Head Temperature (CHT) Sensor
- Tests DP: Vehicle Speed Sensor/Transfer Case Speed Sensor
- Tests DQ: Barometric Pressure (BARO) Sensor
- Tests DR: Camshaft Position (CMP) Sensor
- Tests DS: Air Conditioning Pressure (ACP) Sensor
- Tests DT: Power Steering Pressure (PSP) Sensor
- Tests DU: Intake Air Temperature 2 (IAT2)
- Tests EM: Emissions Compliance
- Tests FD: Brake Pedal Position (BPP) Switch
- Tests FF: Power Steering Pressure (PSP) Switch
- Tests FH: Generator Load Input (GLI)
- Tests HC: Fuel Delivery System
- Tests HD: Misfire Detection Monitor
- Tests HE: Exhaust Gas Recirculation (EGR) Systems
- Tests HF: Catalyst Efficiency Monitor and Exhaust Systems
- Tests HG: Positive Crankcase Ventilation (PCV) System
- Tests HM: Secondary Air Injection (AIR) System
- Tests HU: Intake Air Systems
- Tests HX: Evaporative Emission (EVAP) Monitor and System
- Tests HY: Generator/Regulator System
- Tests JB: Secondary Ignition
- Tests JD: Crankshaft Position (CKP) Sensor
- Tests JE: Integrated Ignition Coil 1, 2, 3 or 4 Failure
- Tests JF: Integrated Ign Coil on Plug Coil 1 Through 10 Failure
- Tests JH: Tachometer Output Failure
- Tests KA: Fuel Pump Relay
- Tests KB: Fuel Pump Driver Module (FPDM)
- Tests KE: Idle Air Control (IAC) Valve
- Tests KF: Fan Control (FC) Relay
- Tests KH: Hydraulic Cooling Fan
- Tests KM: A/C Clutch Relay, A/C Circuits
- Tests NB: Malfunction Indicator Lamp (MIL)
- Tests NC: Ignition Engine Speed Input Circuit
- Tests ND: Engine RPM/Vehicle Speed Limiter
- Tests QA: Unable to Activate Self-Test/SCP Comm. Error/DTC Not Listed
- Tests QB: Diagnostic Trouble Code (DTC) P0603/P1605/P1633
- Tests QC: OBD II Monitor Testing Not Complete - DTC P1000
- Tests QD: Diagnostic Trouble Code (DTC) P1260
- Tests TA: Park/Neutral Position/Clutch Pedal Position Switches
- Tests TB: Trans Control Switch/Trans Control Indicator Lamp
- Tests TH: Reverse Switch (RS)
- Tests TJ: Output Shaft Speed (OSS) Sensor
- Scan Tool Testing and Procedures
- Mode 6 Data
- Monitors, Trips, Drive Cycles and Readiness Codes
- Programming and Relearning
Diagrams- Technical Service Bulletins
- Emission Control Systems
- Catalytic Converter
- Evaporative Emissions System
- Canister Purge Control Valve
- Canister Purge Solenoid
- Evaporative Canister Filter
- Evaporative Emission Control Canister
- Evaporative Emissions Hose
- Leak Detection Valve
- Liquid Vapor Separator
- Refueling Vapor Recovery System
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Technical Service Bulletins
- Tools and Equipment
- Exhaust Gas Recirculation
- Positive Crankcase Ventilation
- Sensors and Switches - Emission Control Systems
- Description and Operation
- Acronym Definitions
- Engine Emission Controls
- Engine/Evaporative Emission System Information
- General
- Vehicle Emission Control Information
- Diagrams
- Technical Service Bulletins
- Fuel Delivery and Air Induction
- Fuel Pressure
- Fuel Pressure Release
- Idle Speed
- Injection Timing
- Accelerator Pedal
- Air Cleaner Housing
- Air Flow Meter/Sensor
- Auxiliary Air Valve (Idle Speed)
- Fuel Filler Cap
- Fuel Filter
- Fuel Injector
- Fuel Line Coupler
- Fuel Pressure Regulator
- Fuel Pressure Test Port
- Fuel Pressure Pulsation Damper
- Fuel Pump
- Fuel Rail
- Fuel Supply Line
- Fuel Tank
- Fuel Tank Unit
- Fuel Temperature Sensor
- Idle Speed/Throttle Actuator - Electronic
- Inertia Fuel Shutoff Switch
- Intake Air Duct
- Main Relay (Computer/Fuel System)
- Relays and Modules - Fuel Delivery and Air Induction
- Sensors and Switches - Fuel Delivery and Air Induction
- Throttle Body
- Throttle Cable/Linkage
- Throttle Position Sensor
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Ignition System
- Firing Order
- Ignition Timing
- Camshaft Position Sensor
- Crankshaft Position Sensor
- Hall Effect Sensor
- Ignition Cable
- Ignition Coil
- Knock Sensor
- Sensors and Switches - Ignition System
- Spark Plug
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Specifications
- Transmission Control Systems
- PROM - Programmable Read Only Memory
- Application and ID
- Description and Operation
- Acronym Definitions
- Malfunction Indicator Lamp (MIL)
- Monitors
- Catalyst Efficiency Monitor - Federal Test Procedure
- Comprehensive Component Monitor
- EGR System Monitor - Differential Pressure Feedback EGR
- Evaporative Emission (EVAP) Leak Check Monitor
- Fuel System Monitor
- Heated Oxygen Sensor (HO2S) Monitor
- Misfire Detection Monitor
- On Board Diagnostics II Monitors
- Thermostat Monitor
- PCM Inputs
- Air Conditioning Cycling Switch
- Air Conditioning Pressure Sensor
- Air Conditioning High Pressure Switch
- Brake Pedal Position Switch
- Camshaft Position Sensor
- Clutch Pedal Position/Park-Neutral Position Switches
- Crankshaft Position Sensor (Integrated Ignition Systems)
- Cylinder Head Temperature Sensor
- Differential Pressure Feedback EGR Sensor
- Engine Coolant Temperature
- Engine Fuel Temperature Sensor
- Engine Oil Temperature
- Flexible Fuel Sensor
- Fuel Level Input
- Fuel Pump Monitor
- Fuel Tank Pressure Sensor
- Fuel Rail Pressure Sensor
- Generator Monitor (GEN Mon)
- Generator Load
- Heated Oxygen Sensor
- Intake Air Temperature Sensor
- Intake Manifold Runner Control
- Knock Sensor
- Mass Air Flow Sensor
- Power Steering Pressure Switch
- Power Steering Pressure Sensor
- Power Take-Off Switch and Circuit
- Purge Flow Sensor, Evaporative System
- Throttle Position Sensor
- Transmission Control Switch
- Transmission Input
- Solid State Relay
- Vehicle Speed Sensor
- PCM Outputs
- Canister Vent Solenoid
- Coil Pack
- Ignition Coil Pack
- Coil on Plug
- Engine Crank/Engine Running
- CMP FMEM
- Engine Cooling Fan Control
- Hydraulic Cooling Fan Drive
- EGR Vacuum Regulator Solenoid
- Electric Secondary Air Injection Pump
- Evaporative Emission Canister Purge Valve
- Fuel Pump
- Fuel Injectors
- Fuel Pressure Regulator Control Solenoid
- Generator Communication (GEN COM)
- Idle Air Control Solenoid
- Intake Manifold Tuning Valve
- Intake Manifold Runner Control
- Secondary Air Injection Bypass Solenoid
- Solid State Relay
- Transmission Control Indicator Lamp
- Transmission Input
- Wide Open Throttle A/C Cut-Off
- Vapor Management Valve
- Powertrain Control Hardware
- Powertrain Control Software
- Systems
- AIR System Monitor-Electric Secondary Air Injection Pump System
- Catalyst and Exhaust Systems
- Electronic Engine Control (EC) System
- Engine/Evaporative Emission System Information
- Evaporative Emission Systems
- Exhaust Gas Recirculation Systems
- Gasoline Fuel Systems
- Ignition Systems
- Intake Air Systems
- PCM-Controlled Charging System
- Positive Crankcase Ventilation System
- Secondary Air Injection (AIR) Systems
- Vehicle Emission Control Information
- Diagrams
- Technical Service Bulletins
- Transmission and Drivetrain
- Actuators and Solenoids - Transmission and Drivetrain
- Automatic Transmission/Transaxle
- Actuators and Solenoids - A/T
- Band
- Band Apply Servo
- Extension Housing
- Fluid - A/T
- Fluid Filter - A/T
- Fluid Line/Hose
- Fluid Pan
- Fluid Pump
- Lamps and Indicators - A/T
- Parking Pawl
- Pressure Regulating Solenoid
- Seals and Gaskets
- Sensors and Switches - A/T
- Shift Interlock
- Shifter A/T
- Shift Linkage
- Torque Converter
- Torque Converter Clutch Solenoid
- Transmission Cooler
- Transmission Mode Indicator - A/T
- Transmission Mode Switch
- Transmission Mount
- Transmission Position Sensor/Switch
- Transmission Speed Sensor
- Valve Body
- Wiring Harness
- Application and ID
- Description and Operation
- External Controls
- 4R44E
- Apply Components
- Hydraulic System, Brakes
- Main Components and Functions
- Main Control
- Range Selection
- Shift Patterns
- Transmission Description
- Transmission Electronic Control System
- Air Conditioning (A/C) Clutch
- Anti-Lock Brake Speed Sensor
- Brake Pedal Position (BPP) Switch
- Coast Clutch Solenoid (CCS)
- Digital Transmission Range
- Electronic Ignition (EI) System
- Electronic Pressure Control (EPC) Solenoid
- Electronic System Description
- Engine Coolant Temperature (ECT) Sensor
- Intake Air Temperature (IAT) Sensor
- Mass Air Flow (MAF) Sensor
- Powertrain Control Module (PCM)
- Shift Solenoids-A, B. C, and D
- Throttle Position (TP) Sensor
- Torque Converter Clutch (TCC) Solenoid
- Transmission Control Indicator Lamp (Tcil)
- Transmission Control Switch (TSC)
- Transmission Fluid Temperature (TFT) Sensor
- Turbine Shaft Speed (TSS) Sensor
- 4X4 Low (4X4L) Switch
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Diagnosis By Symptom - External Controls
- 4R44E
- Diagnosis By Symptom Chart Directions
- Diagnosis By Symptom Index
- General Specifications
- Engagement Concerns
- 201/301: No Forward Only
- 202/302: No Reverse Only
- 203/303: Harsh Reverse Only
- 204/304: Harsh Forward Only
- 205/305: Delayed/Soft Reverse
- 206/306: Delayed/Soft Forward
- 207A/307A: No Forward and No Reverse
- 207B/307B: No Forward In (D) Position and No Reverse
- 208/308: Harsh Forward and Reverse
- 209/309: Delayed Forward and Delayed Reverse
- Other Concerns
- 251/351: Shift Lever Efforts High
- 252/352: External Leaks
- 253A/353A: Driveability Concerns
- 253B/353B: Vehicle Runs Poor, Wrong Gear Ratio (D, 2ND and 1ST)
- 254/354: Noise/Vibration - Forward or Reverse
- 255/355: Engine Will Not Crank
- 256/356: No Park Range
- 257/357: Transmission Overheating
- 258/358: No Engine Braking In 2ND Position
- 259/359: No Engine Braking In 1ST Position
- 260/360: No Engine Braking With OD Cancelled (In 2ND and 3RD)
- 261/361: Fluid Venting/Foaming
- 263/363: Slips/Chatters In Manual 1ST Position
- 264/364: Slips/Chatters In Manual 2ND Position
- 265/365: FMEM-Harsh Engagements and Shifts
- Shift Concerns
- 210/310: Some or All Shifts Missing
- 211/311: Timing - Early/Late (Some/All)
- 212/312: Timing - Erratic/Hunting (Some/All)
- 213/313: Feel - Soft/Slipping (Some/All)
- 214/314: Feel - Harsh (Some/All)
- 215/315: No 1ST Gear In Drive, Engages In High-Gear
- 216/316: No First Gear In Manual 1ST Position
- 217/317: No Manual 3RD Gear In 2ND Position
- 220/320: No 1-2 Shift (Automatic)
- 221/321: No 2-3 Shift (Automatic)
- 222/322: No 3-4 Shift (Automatic)
- 226/326: Soft/Slipping 1-2 Only (Automatic)
- 227/327: Soft/Slipping 2-3 Only (Automatic)
- 228/328: Soft/Slipping 3-4 Only (Automatic)
- 229/329: Soft/Slipping 4-3 Downshifts
- 232/332: Harsh 1-2 Only (Automatic)
- 233/333: Harsh 2-3
- 234/334: Harsh 3-4 Shift Only (Automatic)
- 235/335: Harsh 4-3 Only (Automatic)
- 236/336: Harsh 3-2 Only (Automatic)
- Torque Converter Clutch Operation Concerns
- Pinpoint Tests
- Pinpoint Tests - External Controls
- Test A: Shift Interlock System Does Not Release/Lock Correctly
- Test B: The Shift Control Is Out of Correct Gear Relationship
- Test C: The Trans Control Switch Is Not Operating Properly
- Test D: Transmission Control Indicator Lamp (TCIL) Doesn't Illuminate
- Test E: Trans Control Indicator Lamp (TCIL) Stays Illuminated
- 4R44E
- Before Pinpoint Tests
- Pinpoint Test Notes
- Shift Solenoid Failure Mode Chart "Always Off"
- Shift Solenoid Failure Mode Chart "Always On"
- Shift Solenoid Pre-Diagnosis
- Solenoid Operation Chart
- Test A: Shift Solenoid
- Test B: Transmission Fluid Temperature (TFT) Sensor
- Test C: Torque Converter Clutch (TCC) Solenoid
- Test D: Digital Transmission Range (TR) Sensor
- Test E: Electronic Pressure Control (EPC) Solenoid
- Test F: Turbine Shaft Speed (TSS) Sensor
- Test G: Coast Clutch Solenoid (CCS)
- Test H: Solenoid Mechanical Failure
- Transmission Connector Layout
- Pinpoint Tests - External Controls
- Component Tests and General Diagnostics
- Monitors, Trips, Drive Cycles and Readiness Codes
- Locations
- Service and Repair
- Removal
- Disassembly
- Disassembly and Assembly of Subassemblies
- Center Support
- Converter Housing and Fluid Pump
- End Play Check
- Forward Clutch
- Forward Geartrain
- Intermediate Brake and Direct Clutch Drum Assembly
- Main Control Valve Body
- Output Shaft Ring Gear and Hub Shaft Assembly
- Overdrive Brake and Coast Clutch Drum Assembly
- Overdrive Planetary and One-Way Clutch Assembly
- Overdrive Planetary Gears
- Reverse Brake Drum
- Stator to Impeller Interference Check
- Torque Converter
- Torque Converter Cleaning and Inspection
- Torque Converter Flushing
- Torque Converter Leak Check
- Assembly
- General Procedures
- Installation
- Diagrams
- Specifications
- Mechanical Specifications
- Band Adjustment and Torque Chart
- Band/Clutch Application Chart No. 601 (4R44E)
- Clutch Plate Usage and Clearance Specifications
- End Play Specification
- Fluid Maintenance
- General Specifications
- Line Pressure Chart
- Selective Snap Rings
- Shift Speeds-MPH (km/H)
- Solenoid Operation Chart-4R44E
- Stall Speed
- Torque Converter End Play
- Torque Specifications
- 4R44E Service Identification Model Chart
- Capacity Specifications
- Fluid Type Specifications
- Mechanical Specifications
- Technical Service Bulletins
- Clutch
- Differential Assembly
- Drive Axles, Bearings and Joints
- Drive/Propeller Shafts, Bearings and Joints
- Flex Plate
- Flywheel
- Lamps and Indicators - Transmission and Drivetrain
- Manual Transmission/Transaxle
- Bell Housing
- Case
- Countershaft
- Drain Plug
- Extension Housing
- Fill Plug
- Fluid - M/T
- Flywheel Gear
- Gear
- Output Shaft
- Reverse Idler Gear
- Sensors and Switches - M/T
- Shift Fork
- Shifter M/T
- Shift Linkage
- Transmission Mount
- Transmission Speed Sensor
- Application and ID
- Description and Operation
- Testing and Inspection
- Service and Repair
- Specifications
- Tools and Equipment
- Sensors and Switches - Transmission and Drivetrain
- Transmission Control Systems
- Application and ID
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- Component Tests and General Diagnostics
- Analysis of Inoperative Conditions
- Analysis of Leakage
- Analysis of Vibration
- Contact Pattern Location
- Driveline Vibration
- Driveshaft Vibrates
- Inspection For Bent Rear Axle Housing
- Noise Acceptability
- Pinion Flange Runout Check - Circular
- Tooth Contact Pattern Check - Gearset
- Traction-LOK(R) Differential Check Road Test
- Traction-LOK(R) Differential Operation Check
- Universal Joint (U-Joint) Inspection
- Locations
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Brakes and Traction Control
- Antilock Brakes / Traction Control Systems
- Diagnostic Connector - ABS
- Differential Speed Sensor
- Electronic Brake Control Module
- Hydraulic Control Assembly - Antilock Brakes
- Wheel Speed Sensor
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- A: Brake Indicator Does Not Self-Check
- A: No Communication With the Anti-Lock Brake Control Module
- AB: C1169 Excessive Dump Time (Built After 11/30/00)
- B: Brake Indicator Stays On With Ignition in Run
- B: B1676 Battery Voltage Out of Range
- C: ABS Indicator Does Not Self-Check
- C: C1145/C1155/C1230 - Sensor Circuit Failure
- D: ABS Indicator Self-Check OK But Then Begins Flashing
- D: C1233/C1234/C1237 - Sensor Output Failure
- E: ABS Indicator Self-Checks OK But No Retrieved
- E: C1095 - ABS Hydraulic Pump Motor Circuit Failure
- F: Code 2 - Open Isolation Valve Wiring or Bad Module
- F: C1102 G - Switch Circuit Failure
- F: C1169 - Excessive Dump Time
- G: Code 3 - Open Dump Valve Wiring or Bad Module
- G: Yellow ABS Warning Indicator Does Not Self-Check
- H: Code 4 - Open/Grounded RABS Valve Reset Switch Circuit
- I: Code 5 - Excessive Dump Solenoid Activity
- J: Code 6 - Erratic Sensor Signal While Rolling
- K: Code 7 - No Isolation Solenoid During Self-Check
- L: Code 8 - No Dump Solenoid During Self-Check
- M: Code 9 - Speed Sensor: High Resistance or Open Wiring
- M: C1169 Excessive Dump Time
- M: C1169 Excessive Dump Time (Built pre 11/30/00)
- N: Code 10 - Speed Sensor Low Resistance or Shorted Wiring
- O: Code 11 - BPP Switch Closed or Circuit Worn or Damaged
- P: Code 12 - Loss of Hydraulic Brake Fluid
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Diagrams
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Brake Bleeding
- Brake Pedal Assy
- Disc Brake System
- Drum Brake System
- Hydraulic System
- Brake Bleeding
- Brake Caliper
- Brake Fluid
- Brake Fluid Level Sensor/Switch
- Brake Fluid Pressure Sensor/Switch
- Brake Hose/Line
- Brake Proportioning/Combination Valve
- Hydraulic Control Assembly - Antilock Brakes
- Hydraulic System Junction Block
- Brake Master Cylinder
- Wheel Cylinder
- Description and Operation
- Specifications
- Parking Brake System
- Power Brake Assist
- Relays and Modules - Brakes and Traction Control
- Sensors and Switches - Brakes and Traction Control
- Application and ID
- Description and Operation
- Testing and Inspection
- Locations
- Specifications
- Technical Service Bulletins
- Antilock Brakes / Traction Control Systems
- Starting and Charging
- Sensors and Switches - Starting and Charging
- Relays and Modules - Starting and Charging
- Battery
- Charging System
- Alternator
- Charging System Control Module
- Voltage Regulator
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Test Notes
- Test A: Charging Indicator Is ON With The Engine Running
- Test B: Warning Indicator Off W/Ignition Switch In Run & Engine Off
- Test C: Charging Indicator On, Engine On And, Voltage Increases
- Test D: Indicator OFF W/Ign In Run And Eng OFF
- Test E: Indicator OK But the Battery Voltage Does Not Increase
- Test F: Battery Dead or Not Stay Charged or Low Batt or Gen Volts
- Test G: Charging System Warning Indicator Flickers/Is Intermittent
- Test H: System Overcharges (Battery Voltage Greater Than 15.5 Volts)
- Test J: Battery Leakage or Damage
- Test K: Voltage Gauge Reads High or Low
- Test L: Generator Is Noisy
- Test M: Radio Interference
- Component Tests and General Diagnostics
- Diagrams
- Specifications
- Tools and Equipment
- Starting System
- Power and Ground Distribution
- Technical Service Bulletins
- Power and Ground Distribution
- Steering and Suspension
- Alignment
- Sensors and Switches - Steering and Suspension
- Steering
- Front Steering Knuckle
- Power Steering
- Steering Column
- Air Bag(s) Arming and Disarming
- Key Reminder Switch
- Steering Column Lock
- Description and Operation
- Testing and Inspection
- Locations
- Service and Repair
- Specifications
- Tools and Equipment
- Steering Gear
- Steering Wheel
- Tie Rod
- Application and ID
- Testing and Inspection
- Locations
- Service and Repair
- Specifications
- Technical Service Bulletins
- Tools and Equipment
- Suspension
- Ball Joint
- Control Arm
- Front Steering Knuckle
- Sensors and Switches - Suspension
- Spindle
- Stabilizer Bar
- Suspension Control ( Automatic - Electronic )
- Suspension Spring ( Coil / Leaf )
- Suspension Strut / Shock Absorber
- Torsion Bar
- Wheel Bearing
- Wheel Hub
- Application and ID
- Description and Operation
- Testing and Inspection
- Locations
- Specifications
- Technical Service Bulletins
- Wheels and Tires
- Technical Service Bulletins
- Heating and Air Conditioning
- Accumulator HVAC
- Air Conditioning Switch
- Air Door
- Air Duct
- Air Register
- Blower Motor
- Blower Motor Relay
- Blower Motor Resistor
- Blower Motor Switch
- Cabin Air Filter / Purifier
- Compressor HVAC
- Compressor Clutch Relay
- Compressor Fitting HVAC
- Condenser HVAC
- Control Assembly
- Coupler HVAC
- Evaporator Case
- Evaporator Core
- Expansion Block/Orifice Tube
- Expansion Valve
- Heater Core
- Heater Core Case
- Heater Hose
- High Pressure Safety Valve HVAC
- Hose/Line HVAC
- Refrigerant
- Refrigerant Oil
- Refrigerant Pressure Sensor / Switch
- Relays and Modules - HVAC
- Sensors and Switches - HVAC
- Service Port HVAC
- Vacuum Harness HVAC
- Vacuum Reservoir HVAC
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Diagnostic Vacuum Diagrams
- Pinpoint Test Step Icons
- Test A: Incorrect/Erratic Direction Of Airflow From Outlet(s)
- Test B: Insufficient, Erratic, or No Heat
- Test C: Air Conditioning (A/C) Is Inoperative / Does Not Operate Correctly
- Test D: Air Conditioning Is Always On
- Test E: Insufficient Air Conditioning (A/C) Cooling
- Test F: No-Operation In All The Temperature Settings
- Test G: Blower Motor Does Not Operate/Or Operates Incorrectly
- Test H: Blower Motor Operates Continuously In High Speed
- Test J: No Operation In High Blower Setting
- Test K: No Operation In Lower Speeds
- Component Tests and General Diagnostics
- Locations
- Service and Repair
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Restraints and Safety Systems
- Repairs and Inspections Required After a Collision
- Air Bag Systems
- Air Bag(s) Arming and Disarming
- Air Bag
- Air Bag Control Module
- Air Bag Deactivation Switch
- Clockspring Assembly / Spiral Cable
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Test Step Icons
- Glossary of Terms Used While Performing Tests
- Test A: Air Bag Warning Ind. Is ON Continuously - RCM Disconnected or Inop. Loss of Batt. Feed/Loss of Signal Gnd.
- Test B: LFC 24/DTC B1342 - RCM Internal Fault
- Test C: LFC 19/DTC B1231 - RCM Crash Data Memory Full
- Test C: LFC 21 /DTC B1921 RCM Bracket Gnd. Resistance High
- Test D: LFC 29/DTC C1414 - Incorrect Vehicle Identification Code
- Test F: LFC 15/DTC B1887 - Driver Air Bag Circuit Shorted to Ground
- Test G : LFC 15/DTC B1916 - Driver Air Bag Circuit Shorted to Batt or Ign
- Test H: LFC 16/DTC B1888 - Passenger Air Bag Circuit Shorted to Ground
- Test I: LFC 16/DTC B1925 - Passenger Air Bag Circuit Shorted to Battery or Ignition
- Test J: LFC 32/DTC B1932 - Driver Air Bag Circuit Resistance High
- Test K: LFC 33/DTC B1933 - Passenger Air. Bag Circuit Resistance High
- Test L: LFC 34/DTC B1934 - Driver Air Bag Circuit Resistance Low
- Test M: LFC 35/DTC B1935 - Passenger Air Bag Circuit Resistance Low
- Test N: LFC 25/DTC B1871-Passenger Air Bag Deactivation Switch Fault
- Test O: LFC 27/DTC B1884 - Passenger Air Bag Deactivation (PAD) Warning Lamp Inoperative
- Test P: LFC 27/DTC 61890 - Passenger Air Bag Deactivation (PAD) Warning Lamp Short to Battery
- Test Q: B1892 - Air Bag Tone Warning Indicator CKT Short to GND or Open
- Test R: B1891 - Air Bag Tone Warning Indicator CKT Short to Batt or Ign
- Test S: DTC B1869 - Air Bag Indicator Inoperative
- Test T: DTC B1870 - Air Bag Indicator Shorted to Battery
- Test U: No Communication With the Restraint Control Module (RCM)
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Service and Repair
- Diagrams
- Specifications
- Tools and Equipment
- Relays and Modules - Restraints and Safety Systems
- Seat Belt Systems
- Sensors and Switches - Restraints and Safety Systems
- Service and Repair
- Technical Service Bulletins
- Accessories and Optional Equipment
- Accessory Delay Module
- Antenna
- Antitheft and Alarm Systems
- Alarm Module
- Alarm System Transponder
- Keyless Entry
- Keyless Entry Key-Pad
- Keyless Entry Module
- Keyless Entry Transmitter
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Diagnostic Trouble Code Tests and Associated Procedures
- B Code Charts
- B1213 - AntiTheft Number of Programmed Keys Is Below Minimum
- B1600 - No Key Code Received - Damaged or NonPATS Key
- B1601 - Unprogrammed Encoded Ignition Key (Keycode Format Ok)
- B1602 - PATS Received Invalid Key Code From Key Transponder
- B1681 - PATS Transceiver Signal Not Received
- B2103 - Antenna Not Connected - Defective Transceiver
- B2139 - PCM ID Does Not Match Between PATS and PCM
- B2141 - No Security ID Exchange Between PATS And PCM
- U Code Charts
- PATS Diagnostic Trouble Code (DTC) Index
- B Code Charts
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Scan Tool Testing and Procedures
- Programming and Relearning
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- General Module
- Radio, Stereo, and Compact Disc
- Amplifier
- Radio/Stereo
- Speaker
- Application and ID
- Testing and Inspection
- Technical Service Bulletins
- Relays and Modules - Accessories and Optional Equipment
- Towing / Trailer System
- Trailer Connector
- Body and Frame
- Air Bag(s) Arming and Disarming
- Repairs and Inspections Required After a Collision
- Bumper
- Cowl
- Doors, Hood and Trunk
- Exterior Moulding / Trim
- Fender
- Frame
- Grille
- Interior Moulding / Trim
- Locks
- Door Locks
- Keyless Entry
- Keyless Entry Key-Pad
- Keyless Entry Module
- Keyless Entry Transmitter
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Power Locks
- Trunk / Liftgate Lock Cylinder
- Technical Service Bulletins
- Mirrors
- Paint, Striping and Decals
- Relays and Modules - Body and Frame
- Seats
- Sensors and Switches - Body and Frame
- Sound Proofing / Insulation
- Tailgate
- Truck Bed
- Unibody
- Application and ID
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Specifications
- Technical Service Bulletins
- Cruise Control
- Brake Switch (Cruise Control)
- Clutch Switch
- Cruise Control Module
- Cruise Control Servo
- Cruise Control Servo Cable
- Cruise Control Switch
- Relays and Modules - Cruise Control
- Sensors and Switches - Cruise Control
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Reading and Clearing Diagnostic Trouble Codes
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Test Notes
- Test A: No Communication With the Generic Electronic Module/Central Timer Module
- Test B: Unable to Enter Self-Test
- Test C: Flash Code 1 - No Dynamic Pull At Speed Control Servo
- Test D: Flash Code 2 - Brake Pedal Position Switch Circuit Failure
- Test E: Flash Code 3 - Deactivator Switch Circuit Failure
- Test F: Flash Code 1 - Speed Control Inoperative
- Test G: Speed Control Is Inoperative - No Flash Codes
- Test H: Speed Control Does Not Disengage When the Clutch Is Applied
- Test I: Speed Control Switch Is Inoperative - Coast
- Test J: Speed Control Switch Is Inoperative - Set/Accel
- Test K: Speed Control Switch Is Inoperative - Resume
- Test L: Speed Control Switch Is Inoperative - Off
- Test M: Speed Control Indicator Lamp Is Always on
- Test N: Set Speed Fluctuates
- Scan Tool Testing and Procedures
- Locations
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Instrument Panel, Gauges and Warning Indicators
- Ammeter Gauge
- Audible Warning Device
- Audible Warning Device Control Module
- Charge Lamp/Indicator
- Cigarette Lighter
- Dashboard / Instrument Panel
- Dimmer Switch
- Door Switch
- Fuel Gauge
- Fuel Gauge Sender
- Instrument Cluster / Carrier
- Key Reminder Switch
- Maintenance Required Lamp/Indicator
- Malfunction Indicator Lamp
- Oil Change Reminder Lamp
- Oil Pressure Gauge
- Relays and Modules - Instrument Panel
- Sensors and Switches - Instrument Panel
- Speedometer Head
- Tachometer
- Temperature Gauge
- Temperature Sensor (Gauge)
- Transmission Mode Indicator - A/T
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Tests - Instrument Cluster
- Test A: Incorrect Fuel Gauge Indication
- Test B: Incorrect Temperature Gauge Indication
- Test C: Incorrect Oil Pressure Gauge Indication
- Test D: A Gauge Is Inaccurate - Speedometer
- Test E: Speedometer/Odometer Is Inoperative - With Rear Anti-Lock Brakes (RABS)
- Test F: Speedometer/Odometer Is Inoperative - With 4-Wheel Anti-Lock Brakes (4WABS)
- Test G: Tachometer Is Inoperative
- Test H: Incorrect Tachometer Indication
- Test J: Charge System Warning Indicator Is Never/Always on
- Test K: An Indicator Is Inoperative Anti-Lock Brake Warning
- Test L: An Indicator Is Inoperative - Fuel Reset
- Test M: An Indicator Is Inoperative-High Beam
- Test N: An Indicator Is Inoperative-Check Engine/Malfunction Indicator
- Test P: An Indicator Is Inoperative - LH Turn Signal
- Test Q: An Indicator Is Inoperative - RH Turn Signal
- Test R: An Indicator Is Inoperative - 0/D Off
- Test S: Speed Control Indicator Is Never/Always on
- Test T: An Indicator Is Inoperative - Red Brake Warning
- Test U: An Indicator Is Inoperative-Check Gage
- Test V: No Communication With the Module - GEM/CTM
- Test W: Door Ajar Indicator Does Not Operate Correctly
- Test X: Safety Belt Warning Indicator Does Not Operate Correctly
- Test Y: An Indicator Is Inoperative-4X4 High, 4X4 Low
- Test Z: An Indicator Is Inoperative-Air Bag
- Pinpoint Tests - Instrument Panel Illumination
- Test A: Control Illumination Is Inoperative
- Test B: Instrument Cluster Illumination Inoperative
- Test C: Climate Control Illumination Is Inoperative
- Test D: Audio System Illumination Inoperative
- Test E: Single Illumination Source Is Inoperative - Headlamp Switch
- Test F: Single Illumination Source Is Inoperative - 4WD Mode Switch
- Test G: Single Illumination Source Is Inoperative - Fog Lamp Switch
- Test H: Single Illumination Source Is Inoperative - Speed Control Actuator Switches
- Pinpoint Tests - Warning Devices
- Pinpoint Test Notes
- Test A: Safety Belt Warning Chime Does Not Operate Properly
- Test B: Headlamp on Reminder Chime Does Not Operate Properly
- Test C: Key-In-Ignition Chime Is Inoperative
- Test D: No Communication With the Module - Generic Electronic Module/Central Timer Module
- Test E: All the Chimes Are Inoperative
- Pinpoint Tests - Instrument Cluster
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Locations
- Service and Repair
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Lighting and Horns
- Backup Lamp
- Brake Lamp
- Brake Light Switch
- Cargo Lamp
- Center Mounted Brake Lamp
- Courtesy Lamp
- Interior Light Switch
- Service Precautions
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Test Notes
- Test A: No Communication With The GEM/CTM
- Test B: Courtesy Lamps Are Inoperative
- Test C: Courtesy Lamps Do Not Turn on With One Door Open
- Test D: Courtesy Lamps Stay ON Continuously
- Test E: Illuminated Entry Inoperative Using Remote Transmitter
- Test F: Battery Saver Does Not Deactivate After Time-Out
- Test G: An Individual Demand Lighting Lamp Is Inoperative
- Test H: An Individual Courtesy Lamp Is Inoperative - Dome Lamp
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Diagrams
- Tools and Equipment
- Daytime Running Lamp
- Dimmer Switch
- Battery Discharge Protection Relay
- Dome Lamp
- Door Switch
- Fog/Driving Lamp
- Hazard Warning Lamps
- Headlamp
- Horn
- Interior Lighting Module
- Interior Lighting Relay
- License Plate Lamp
- Map Light
- Marker Lamp
- Parking Lamp
- Relays and Modules - Lighting and Horns
- Sensors and Switches - Lighting and Horns
- Tail Lamp
- Trailer Lamps
- Trailer Lighting Relay
- Turn Signals
- Description and Operation
- Testing and Inspection
- Locations
- Diagrams
- Specifications
- Technical Service Bulletins
- Windows and Glass
- Relays and Modules - Windows and Glass
- Sensors and Switches - Windows and Glass
- Windows
- Windshield
- Service Precautions
- Description and Operation
- Testing and Inspection
- Locations
- Tools and Equipment
- Wiper and Washer Systems
- Relays and Modules - Wiper and Washer Systems
- Sensors and Switches - Wiper and Washer Systems
- Windshield Washer Control Module
- Windshield Washer Pump
- Windshield Washer Relay
- Windshield Washer Reservoir
- Windshield Washer Spray Nozzle
- Windshield Washer Switch
- Wiper Arm
- Wiper Blade
- Wiper Control Module
- Wiper Motor
- Wiper Motor Linkage
- Wiper Pivot
- Wiper Relay
- Wiper Switch
- Service Precautions
- Description and Operation
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Diagnostic Trouble Code Tests and Associated Procedures
- Symptom Related Diagnostic Procedures
- Pinpoint Tests
- Pinpoint Test Notes
- Test A: Wipers Are Inoperative
- Test B: Wipers Stay ON Continuously
- Test C: High/Low Wiper Speeds Do Not Operate Correctly
- Test D: Intermittent Wiper Speed Does Not Operate Properly
- Test E: Washer Pump Is Inoperative
- Test F: Speed Dependent Interval Mode Does Not Operate Correctly
- Test G: Low Wiper Speed Does Not Operate Properly
- Test H: No Communication With the Module - GEM/CTM
- Component Tests and General Diagnostics
- Scan Tool Testing and Procedures
- Locations
- Diagrams
- Technical Service Bulletins
- Tools and Equipment
- Service Precautions
- Application and ID
- Testing and Inspection
- Initial Inspection and Diagnostic Overview
- Symptom Related Diagnostic Procedures
- Noise, Vibration, and Harshness Diagnosis
- Symptom Charts
- Pinpoint Tests
- Test Notes
- Test A: Brake Vibration/shudder
- Test B: Engine Ticking Noise
- Test C: Accessory Drive Bearing Hoot
- Test D: Power Steering Moan
- Test E: Engine Driven Cooling Fan Moan
- Test F: Drumming Noise
- Test G: Engine Ticking, Knocking or Continuing Rattle
- Test H: Front Suspension Noise
- Test I: Rear Suspension Noise
- Test J: Wheel and Tire
- Test K: High Speed Shake or Shimmy
- Test L: Clutch Vibration
- Test M: Transfer Case Vibration
- Diagnostic Special Service Tools
- Guide To Diagnostic Procedures
- Diagnostic Guide
- Check OASIS/TSBs/Repair History
- Component Tests
- NVH Condition and Symptom Categories
- 1: Customer Interview
- 2: Pre-Drive Check
- 3: Preparing for the Road Test
- 4: Verify the Customer Concern
- 5: Road Test
- Tools and Techniques
- Noise, Vibration, and Harshness Diagnosis
- Component Tests and General Diagnostics
- Locations
- Diagrams
- Diagram Information and Instructions
- Diagnostic Aids
- Exploded Views
- Connector Views
- C105-C200
- C201-C261
- C309-C1006
- Accessory Delay Relay
- Air Bag Control Module
- Air Door Actuator / Motor, HVAC
- Air Flow Meter/Sensor
- Alarm Module, (Vehicle Antitheft)
- Automatic Transmission/Transaxle
- Blower Motor Relay
- Clockspring Assembly / Spiral Cable, Air Bag
- Clutch Switch
- Compressor Clutch Relay
- Cruise Control Servo
- Data Link Connector
- Diagnostic Connector - ABS
- Electronic Brake Control Module
- Engine Control Module
- Fuel Pump Relay
- Fuel Tank Unit
- General Module
- Ignition Switch
- Instrument Panel, Gauges and Warning Indicators
- Keyless Entry Module
- Lighting and Horns
- System Diagram
- Backup Lamp Switch
- Battery Discharge Protection Relay, Lighting
- Brake Light Switch
- Daytime Running Lamp Control Unit
- Fog/Driving Lamp Relay
- Fog/Driving Lamp Switch
- Hazard Flasher Relay
- Hazard Warning Flasher
- Hazard Warning Switch
- Headlamp Dimmer Switch
- Headlamp Switch
- Horn Relay
- Interior Lighting Module
- Interior Lighting Relay
- Turn Signal Flasher
- Turn Signal Relay
- Turn Signal Switch
- Multiple Junction Connector
- Neutral Safety Switch
- Oxygen Sensor
- Power Door Lock Switch
- Power Mirror Switch
- Power Window Control Module
- Power Window Switch
- Radiator Cooling Fan Motor Relay
- Radio/Stereo
- Relay Box
- Starter Relay
- Transmission Speed Sensor, M/T
- Windshield Washer Control Module
- Windshield Washer Switch
- Wiper Control Module
- Wiper Motor
- Wiper Switch
- Electrical Diagrams
- Diagrams By Number
- Please Note
- Diagram Set 10
- Diagram Set 12
- Diagram Set 13
- Diagram Set 14
- Diagram Set 20
- Diagram Set 21
- Diagram Set 23
- Diagram Set 29
- Diagram Set 31
- Diagram Set 34
- Diagram Set 37
- Diagram Set 42
- Diagram Set 44
- Diagram Set 46
- Diagram Set 53
- Diagram Set 54
- Diagram Set 59
- Diagram Set 60
- Diagram Set 64
- Diagram Set 66
- Diagram Set 71
- Diagram Set 81
- Diagram Set 85
- Diagram Set 86
- Diagram Set 89
- Diagram Set 90
- Diagram Set 92
- Diagram Set 93
- Diagram Set 95
- Diagram Set 97
- Diagram Set 100
- Diagram Set 110
- Diagram Set 112
- Diagram Set 117
- Diagram Set 124
- Diagram Set 130
- Power and Ground Distribution
- Accessory Delay Relay
- Air Bag Systems
- Antilock Brakes / Traction Control Systems
- Antitheft and Alarm Systems
- Automatic Transmission/Transaxle
- Charging System
- Cruise Control
- General Module
- Heating and Air Conditioning
- Instrument Panel, Gauges and Warning Indicators
- Keyless Entry
- Lighting and Horns
- Mirrors
- Power Locks
- Powertrain Management
- Radiator Cooling Fan Motor Relay
- Radio/Stereo
- Starting System
- Trailer Connector
- Windows
- Wiper and Washer Systems
- Diagrams By Number
- Mechanical Diagrams
- Fluid Diagrams
- Vacuum and Vapor Hose Diagrams
- Components
- Connectors
- Grounds
- Splices
- Specifications
- Electrical Specifications
- Mechanical Specifications
- Accelerator Pedal
- Accumulator HVAC
- Air Bag Systems
- Air Door Actuator / Motor, HVAC
- Air Duct
- Air Flow Meter/Sensor
- Alarm System Transponder
- Alignment
- Alternator
- Antenna
- Battery
- Blower Motor
- Blower Motor Resistor
- Body and Frame
- Brake Switch (Cruise Control)
- Brakes and Traction Control
- System Specifications
- Antilock Brakes / Traction Control Systems
- Brake Bleeding
- Brake Pedal Assy
- Disc Brake System
- Drum Brake System
- Hydraulic System, Brakes
- Parking Brake System
- Vacuum Brake Booster
- Camshaft Position Sensor
- Canister Purge Control Valve
- Catalytic Converter
- Compressor Fitting HVAC
- Compressor HVAC
- Condenser HVAC
- Coolant Temperature Sensor/Switch (For Computer)
- Crankshaft Position Sensor
- Cruise Control Servo
- Cruise Control Servo Cable
- Cruise Control Switch
- EGR Electronic Vacuum Regulator Solenoid
- EGR Tube
- EGR Valve
- Engine
- Engine Control Module
- Evaporative Emission Control Canister
- Evaporator Case
- Exhaust Manifold
- Exhaust Pipe
- Fan Clutch
- Fuel Filter
- Fuel Pressure Pulsation Damper
- Fuel Pressure Test Port
- Fuel Rail
- Fuel Supply Line
- Fuel Tank
- General Module
- Heater Core Case
- Heater Hose
- High Pressure Safety Valve HVAC
- Hose/Line HVAC
- Idle Speed
- Idle Speed/Throttle Actuator - Electronic
- Ignition System
- Inertia Fuel Shutoff Switch
- Instrument Cluster / Carrier
- Intake Air Duct
- Lighting and Horns
- Muffler
- Oil Separator
- Oxygen Sensor
- Pressure Feedback Exhaust Sensor, EGR
- Radiator
- Radiator Hose
- Radio/Stereo
- Refrigerant Pressure Sensor / Switch, HVAC
- Seat Belt
- Seat Belt Buckle
- Seat Belt Height Adjuster
- Seat Belt Retractor
- Speaker
- Starting System
- Steering
- Suspension
- Temperature Sensor (Gauge)
- Thermostat Housing, Engine Cooling
- Throttle Body
- Throttle Cable/Linkage
- Transmission and Drivetrain
- System Specifications
- Automatic Transmission/Transaxle
- System Specifications
- Band Adjustment and Torque Chart
- Band/Clutch Application Chart No. 601 (4R44E)
- Clutch Plate Usage and Clearance Specifications
- End Play Specification
- Fluid Maintenance
- General Specifications
- Line Pressure Chart
- Selective Snap Rings
- Shift Speeds-MPH (km/H)
- Solenoid Operation Chart-4R44E
- Stall Speed
- Torque Converter End Play
- Torque Specifications
- 4R44E Service Identification Model Chart
- Band Apply Servo, A/T
- Extension Housing, A/T
- Fluid Filter - A/T
- Fluid Line/Hose, A/T
- Fluid Pan, A/T
- Fluid Pump, A/T
- Shift Cable, A/T
- Shift Interlock Solenoid
- Shifter A/T
- Torque Converter
- Transmission Mount, A/T
- Transmission Position Sensor/Switch, A/T
- Transmission Speed Sensor, A/T
- Valve Body, A/T
- System Specifications
- Axle Joint Housing
- Axle Shaft
- Clutch, M/T
- Differential Assembly
- Drive/Propeller Shaft
- Flex Plate
- Flywheel
- Manual Transmission/Transaxle
- Vacuum Reservoir HVAC
- Vehicle Speed Sensor
- Voltage Regulator
- Water Pump
- Wheels and Tires
- Windows
- Windshield
- Windshield Washer Reservoir
- Wiper Motor
- Wiper Pivot
- Pressure, Vacuum and Temperature Specifications
- Capacity Specifications
- Fluid Type Specifications
- Technical Service Bulletins
Diagnostic Trouble Codes
