Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Recall 00V094000: Defroster Performance Compromised
- Recall - Multifunction Switch Replacement
- Recall 00V228001: Seat Belt Buckle Defect
- Recall - Seat Belt Buckle Inspection/Replacement
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter
- Customer Interest
- Throttle Position Sensor - High Engine Idle Speed
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C Clutch - Loud Engagement Noise
- A/T Cooler - Fluid Leaks at Radiator
- Leaf Springs - Vehicle Sits Low In Rear
- M/T Clutch - Hooting/Eeking/Moaning Noise
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine Controls - No Start/Hard Start/Rough Idle
- Speedometer/Odometer - Inaccurate/Inoperative
- Electrical - Water Intrusion Into Connectors
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Doors - Rear Door/Squeaking/Creaking Noise
- Radio - Reduced Volume/Inoperative or Intermittent
- Windshield Wipers - Operate While Switch is OFF
- Restraints - Seat Belts Slow to Retract
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- A/T - Inadvertent Shift Interlock Disabling
- Interior - Driver/Passenger Seat Track Rattles
- M/T - M5OD Buzzing/Grinding Noise
- Power Windows - Chatter/Binding When Operating
- Tailgate - Squeaking/Binding Condition
- EVAP Line - Idle Dips On Turns/Deceleration
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- A/C - Heater Core Electrolysis/Leakage
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Superceded Bulletins
- Front Wipers - Operate While Switch is in OFF Position
- Front Wipers - Operate While Switch Is In Off Position
- Recall - Speed Control Deactivation Switch Defects
- Recall - Cruise Control Switch Circuit Defect
- 05S28S12 - 08/20/07
- 05S28S11 - 08/03/07
- Body - Aluminum Corrosion Service Tip
- Interior - Front Seat Tracks Rattle
- Passive Antitheft System (PATS) - Diagnostics Tips
- Restraint System - Seat Belts Slow to retract
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Battery - Service/Charging Tips
- Battery - Charging Tips and Guidelines
- A/T - New Transmission Cooler Flusher/Service Tip
- A/T - No 2nd/3rd Gear/Possible DTC's Set
- A/T - Slipping Shifts/Delayed Engagements/DTC's Set
- Shift Interlock (BRAKE) - Inadvertent Disabling
- EVAP System - MIL ON Multiple DTC's Set
- Engine Controls - General PCM Reprogramming Procedures
- Emissions - MIL ON/EVAP System DTC's Set
- Heater Core - Repeated Failure
- Battery - Battery EYE Function/Charging Service Tips
- A/T - Fluid Application Charts
- A/T - Slipping/Delayed Engagement/DTC P1762 Set
- Engine - Oil Recommendations/Applications
- All Technical Service Bulletins
- Driveability - Vacuum Leak Detection
- Throttle Position Sensor - High Engine Idle Speed
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- A/C Clutch - Loud Engagement Noise
- A/T Cooler - Fluid Leaks at Radiator
- Recall - Firestone Tire Recall
- Recall - Firestone Tire Recall Supplement
- Leaf Springs - Vehicle Sits Low In Rear
- Body - Frame Mounted Front Bumper Service
- M/T Clutch - Hooting/Eeking/Moaning Noise
- A/T - Cooler Flushing Service Tips
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Emissions/Engine Controls - Driveability Diagnosis
- Engine Controls - No Start/Hard Start/Rough Idle
- Speedometer/Odometer - Inaccurate/Inoperative
- Engine Controls - General PCM Programming Procedures
- Restraints - Seat Belt Stop Button Service
- Electrical - Water Intrusion Into Connectors
- Recall 00V094000: Defroster Performance Compromised
- PATS System - Diagnostic Service Tips
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- A/T - No 2nd, 3rd Gear/No Engine Braking/DTC's Set
- Engine Controls - MIL ON/Lean DTC Service Tips
- Doors - Rear Door/Squeaking/Creaking Noise
- Radio - Reduced Volume/Inoperative or Intermittent
- Windshield Wipers - Operate While Switch is OFF
- Restraints - Seat Belts Slow to Retract
- Engine Oil - Oil Recommendations/Applications
- Engine Coolant - Propylene Glycol Recommendations
- A/T - In Line Fluid Filter Kit
- Ignition Switch - High Turning Effort/MIL ON/DTC's Set
- Engine - Oil System Priming Procedures
- Wire Harness - Terminal Repair Kit
- Electrical - Wiring Soldering/Crimping Service Tips
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Locks - Lock Service Packages Available
- A/T - Inadvertent Shift Interlock Disabling
- Seat Belts - Warning System Operation
- Recall - Multifunction Switch Replacement
- Interior - Driver/Passenger Seat Track Rattles
- A/C - Identification of Non Approved Refrigerants
- M/T - M5OD Buzzing/Grinding Noise
- Power Windows - Chatter/Binding When Operating
- Recall 00V228001: Seat Belt Buckle Defect
- Recall - Seat Belt Buckle Inspection/Replacement
- Tailgate - Squeaking/Binding Condition
- EVAP Line - Idle Dips On Turns/Deceleration
- Brakes - Vibration/Inspection Service Tips
- Steering/Suspension - Alignment Procedure Revision
- Quarter Trim Panel - Poor Fit/No Mounting Holes
- A/C - Heater Core Electrolysis/Leakage
- A/T - 5R44E/5R55E Part Level Change/Compatibility
- Body - Aluminum Body Panels - Corrosion
- Keyless Entry - Keypad Diagnostics
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Recall 07V336000: Cruise Control Fire Hazard
- Recall - Cruise Control Deactivation Switch Inspection
- Important Reminder Customer Letter - Truck
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - FJH Parts Application Chart
- Attachment V - Dealer Q & A
- Important Reminder Owner Letter - Car - Parts Available
- Important Reminder Owner Letter - Truck - Required Service Not Performed Yet
- Owner Letter