Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Generals
- Campaign - Tire Warranty Coverage Changes
- Campaign - Tire Replacement
- Campaign - Pick-Up Bed Butyl Pad Removal
- Campaign - Potential Pick Up Bed Corrosion
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Overview
- Corrosion Perforation - Initial Inspection
- Butyl Pad Removal & Secondary Inspection
- Pickup Bed Right Outer Panel Replacement
- Replacement Procedure Using STRSW
- Resistance Welder Set-Up and Adhesive Preparation
- Outer Panel Installation and Resistance Welding
- Finishing & Painting - Procedures Based on Resistance Welding
- Alternate Welding Procedure If STRSW Is Not Available
- Outer Panel Installation and MIG Welding
- Finishing & Painting - Procedures Based on MIG Welding
- Pickup Bed Installation
- Owner Letter
- Campaign - Fuel Injector Warranty Extension
- Safety
- Generals
- Customer Interest
- Engine - Intermittent Warm Engine Rattle Noise/Rough Idle/DTC's
- Engine Controls - Idle Fluctuation/DTC's P0505/P0506
- A/C - White Flakes/Powder Blow From Dash Vents
- Engine Controls - MIL ON/DTC's P2106 and P2135 Set
- Fuel System - MIL ON/Rough Idle/Long Crank/Misfire/DTC's
- A/C - Compressor Leaking/Inoperative
- Brakes - Front Brakes Shudder/Vibrate Upon Application
- Brakes - Front Brake Roughness/Shudder
- Engine - Ticking/Knocking Noises
- Cooling System - Fan Clutch Noise on Cold Start-Up
- Alignment - Rapid Inside Edge Tire Wear
- Interior - Headliner Buffeting or Rattling
- Driveline - Slip-Bump on Deceleration or Acceleration
- Drivetrain - Rear Differential Whine/Hum Noise
- Steering - Steering Column Clicking Noise
- Engine Controls - Harsh 3-2 A/T Downshifts/No DTC's
- Engine Controls - MIL ON/DTC's P2106/P061B
- Engine Controls - MIL ON/Various Driveability Concerns
- Axle - Intermittent Noise, 4 X 4 Inop. DTC's 1979/1980
- Drivetrain - ESOF System Inoperative/DTC P1867
- Driveline - Clunk/Bump When Starting From A Stop
- Restraints - Seat Belts Slow to Retract
- Frame - L/H Front Differential Bracket Frame/Separation
- Steering - Steering Column Clunk/Rattle Noise
- Keyless Entry - Keypad Inoperative
- Audio System - CD Player Skips/Locks-Up/Inoperative
- Instruments - False Parking Aid Warnings
- Body - Roof Ditch Molding Loose
- Engine - Ticking/Knocking/Start Up Rattle
- A/C - Heater Core Electrolysis/Leakage
- Drivetrain - Vibration On Hard Acceleration
- Charging System - DTC P0340/P0344/P0345/P0349
- Engine Controls - Stumble On Deceleration
- Starting System- No Crank Condition
- Parking Assist System - Speaker Inop./DTC C1742/C1743
- Body - Power Back Glass Noise While Driving
- Interior - Tip-Out Ashtray Rattles
- Body - Slow Power Window Operation
- Interior - Leather Wrapping On Steering Wheel Is Loose
- A/C - Water Leak Front Passenger Side
- Power Steering - Cold Weather High Pressure Line Leakage
- Body - Rattle Noise From Tailgate
- Fuel System - Erratic Fuel Gauge/MIL ON/DTC P0460/P0463
- A/C - Grinding Noise When Changing Modes
- Body - Rust Stains On Front Bumper
- Brakes - Vibration At 45 MPH/Park Brake Partial Release
- Ignition System - MIL ON/DTC P0300-P0308/P0316
- A/C - Cannot Control Output Temperature
- Body - Sunroof Water Leaks During High Pressure Car Wash
- Wheels/Tires - Steering Wheel Nibble/Vibration
- Body - L/H Cowl Panel Popped Up
- A/T - Uncommanded TCC Lock Up On 1-2 Upshift
- Drivetrain - Highway Speed Vibration
- Superceded Bulletins
- 05-22-20 - 10/31/05
- Body Power Back Glass Noise While Driving
- Campaign - Pick Up Box Butyl Pad Removal
- Campaign - Truck Box Corrosion Prevention
- Body - Water Leak From Rear of Sunroof
- Interior - Trim Paint Application Procedures
- Body/Interior - Sunroof/Headliner Buffeting/Rattle Noise
- Frame - Replacement Matrix Service Tip
- Body - Driver Side Cowl Panel Popped Up
- Body Rust Stains On Front Bumper
- Audio System - CD Player Skipping/Locks Up/Inoperative
- Parking Assist System - False Warnings
- Restraint System - Seat Belts Slow to retract
- Restraints - DTC And Associated Fault PID Service Tips
- Recall Driver's Air Bag/Clockspring Harness
- Recall - Inadvertent Air Bag Deployment
- Recall - Driver's Air Bag Harness Replacement
- A/C - White Flakes Blowing From Dash Vents
- A/C - White Flakes Are Blowing From Dash Vents
- A/C - White Flakes Come From Dash Vents With Blower ON
- A/C - White Flakes Blow From Dash Vents
- A/C - White Flakes From Vents With Blower ON
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wire Harness Replacement Service Tips
- Electrical - Wiring Harness Replacement Guidelines/Tips
- Battery - Service/Charging Tips
- Brakes Vibration at 45 MPH/park Brake Partial Release
- Brakes - Front End Shudder/Vibration When Braking
- Brakes - Front End Shudder/Vibration Upon Braking
- Drivetrain - Shudder Vibration On Hard Acceleration
- Drivetrain - Shudder/Vibration on Hard Acceleration
- Drivetrain - Drive Axle Whine/Hum on Accel/Decel/Cruise
- Drivetrain - L/S Rear Axle Shudder/Chatter
- Drivetrain - Rear Axle Whine or Hum
- A/T - Uncommanded TCC Lock-Up on 1-2 Shift
- A/T - Uncommanded TCC Application On 1-2 Upshift
- Engine Controls - Hesitation/MIL ON/DTC's P0505/P0506
- Charging System - DTC's P0340/P0344/P0345/P0349
- Alternator - DTC's P0340/P0344/P0345/P0349
- Engine Controls - MIL ON/Driveability Issues/DTC's Set
- Alternator - DTC's P0340/P0344 Set
- Charging System - DTC's P0340/P0344 Set
- Engine Controls - MIL ON/DTC's/Driveability Concerns
- Engine Controls - MIL/ETC Lamps ON/DTC's P106/P2135
- Engine Controls - MIL ON/DTC P061B and P2106 Set
- Engine Controls - MIL ON/DTC's P061B/P2106 Set
- Engine Controls - General PCM Reprogramming Procedures
- Engine Controls - MIL ON/DTC's P0505/P0506/Hard Start
- Engine - Knocking/Ticking Noises After Warmed Up
- Battery - Battery EYE Function/Charging Service Tips
- Drivetrain/Wheels/Tires - High Speed Vibration
- Driveline - Highway Speed Vibration
- Campaign - Tire Warranty Coverage Change
- 05B34 - 12/16/05
- Steering/Drivetrain - Steering Wheel Vibration/Nibble
- Steering/Drivetrain - Body Vibration at Highway Speeds
- Tires/Wheels - Excessive Run-Out Vibration
- Tires/Wheels - Vibration While Driving
- Steering - Steering Wheel Vibration at 50 MPH
- Drivetrain - Neutral Towing Kit/Applications
- A/T, M/T - Vehicle Neutral Tow Capability/Service Kit
- Ignition System - Engine Misfire Diagnostics Tips
- Engine Controls - Spark Knock/MIL ON/Misfire DTC's
- Engine - Spark Knock/DTC's P0300-P0308/P0316
- Ignition System - Spark Knock/MIL ON/Misfire DTC's Set
- Ignition System - Spark Plug Removal Instructions
- Engine/Ignition System - Spark Plug Removal
- All Technical Service Bulletins
- Interior - Door Trim Applique Removal Procedure
- Engine - Intermittent Warm Engine Rattle Noise/Rough Idle/DTC's
- Engine Controls - Idle Fluctuation/DTC's P0505/P0506
- A/C - White Flakes/Powder Blow From Dash Vents
- Recall 11V107000: Inadvertent Driver Air Bag Deployment
- Engine Controls - MIL ON/DTC's P2106 and P2135 Set
- Fuel System - MIL ON/Rough Idle/Long Crank/Misfire/DTC's
- A/C - Compressor Leaking/Inoperative
- Brakes - Front Brakes Shudder/Vibrate Upon Application
- Brakes - Front Brake Roughness/Shudder
- Engine - Camshaft/Valve Lash Adjuster Design Change
- Engine - Ticking/Knocking Noises
- Cooling System - Fan Clutch Noise on Cold Start-Up
- Campaign - Tire Warranty Coverage Changes
- Alignment - Rapid Inside Edge Tire Wear
- Campaign - Tire Replacement
- Wheels/Tires - Approved Off-Road Tires
- Interior - Headliner Buffeting or Rattling
- Driveline - Slip-Bump on Deceleration or Acceleration
- Drivetrain - Rear Differential Whine/Hum Noise
- Engine Controls - MAF Sensor Diagnostic Service Tip
- Steering - Steering Column Clicking Noise
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- Engine Controls - Harsh 3-2 A/T Downshifts/No DTC's
- Engine Controls - MIL ON/DTC's P2106/P061B
- Engine Controls - MIL ON/Various Driveability Concerns
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Body - Weld Bonding Procedure
- Body - Weld Bonding (MIG Procedure)
- Campaign - Pick-Up Bed Butyl Pad Removal
- Axle - Intermittent Noise, 4 X 4 Inop. DTC's 1979/1980
- Drivetrain - ESOF System Inoperative/DTC P1867
- Driveline - Clunk/Bump When Starting From A Stop
- Restraints - Seat Belts Slow to Retract
- Body - Rear Bolt-In Glass Installation/Removal Tips
- Instruments - Power Folding Mirror Operation
- Frame - L/H Front Differential Bracket Frame/Separation
- Steering - Steering Column Clunk/Rattle Noise
- Vehicle - Tow Capability/Service Kit Requirements
- Keyless Entry - Keypad Inoperative
- A/T - Shift Cable Repair or Replacement
- Electrical - Wiring Soldering/Crimping Service Tips
- Interior - Repair/Paint to Match Instructions
- Audio System - CD Player Skips/Locks-Up/Inoperative
- Paint - Repair Due To Iron Particles/Acid Rain
- Recall - Instrument Cluster Programming for ABS Light
- Instruments - False Parking Aid Warnings
- Body - Roof Ditch Molding Loose
- Campaign - Potential Pick Up Bed Corrosion
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Overview
- Corrosion Perforation - Initial Inspection
- Butyl Pad Removal & Secondary Inspection
- Pickup Bed Right Outer Panel Replacement
- Replacement Procedure Using STRSW
- Resistance Welder Set-Up and Adhesive Preparation
- Outer Panel Installation and Resistance Welding
- Finishing & Painting - Procedures Based on Resistance Welding
- Alternate Welding Procedure If STRSW Is Not Available
- Outer Panel Installation and MIG Welding
- Finishing & Painting - Procedures Based on MIG Welding
- Pickup Bed Installation
- Owner Letter
- Body/Frame - Magnesium Radiator Support Service Tips
- Engine - Reman Engine Head Gasket Identification
- Engine - Ticking/Knocking/Start Up Rattle
- A/C - Heater Core Electrolysis/Leakage
- Drivetrain - Vibration On Hard Acceleration
- Charging System - DTC P0340/P0344/P0345/P0349
- Engine Controls - Stumble On Deceleration
- Starting System- No Crank Condition
- Body - Aluminum Body Panels - Corrosion
- Parking Assist System - Speaker Inop./DTC C1742/C1743
- Body - Power Back Glass Noise While Driving
- Interior - Tip-Out Ashtray Rattles
- Keyless Entry - Keypad Diagnostics
- Body - Slow Power Window Operation
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Electrical - Wiring Harness Replacement Guidelines
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- A/C - Water Leak Front Passenger Side
- Body - Power Rear Sliding Window Motor Replacement
- Restraints - Control Module DTCs, Associated Fault PIDs
- Engine - Spark Plug Hole Thread Repair Procedure
- Power Steering - Cold Weather High Pressure Line Leakage
- Body/Frame - Frame Replacement Matrix
- Interior - Instrument Panel Scratch/Mar Repair Tips
- Body - Rattle Noise From Tailgate
- Campaign - Fuel Injector Warranty Extension
- Fuel System - Erratic Fuel Gauge/MIL ON/DTC P0460/P0463
- Ignition System - Spark Plug Removal Instructions
- A/C - Grinding Noise When Changing Modes
- Body - Rust Stains On Front Bumper
- Recall 08V208000: Brake Booster Vacuum Hose
- Brakes - Vibration At 45 MPH/Park Brake Partial Release
- Recall - Brake Booster Vacuum Hose Replacement
- Ignition System - MIL ON/DTC P0300-P0308/P0316
- A/C - Cannot Control Output Temperature
- Body - Sunroof Water Leaks During High Pressure Car Wash
- Wheels/Tires - Steering Wheel Nibble/Vibration
- Body - L/H Cowl Panel Popped Up
- A/T - Uncommanded TCC Lock Up On 1-2 Upshift
- Drivetrain - Highway Speed Vibration
- Recall - Air Bag Harness Chafes On Horn Plate