Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C, Cooling System - Heater Core Leaks
- A/C - Heater Core Electrolysis/Leakage
- Drivetrain - Front Wheel Bearing Noise
- Engine Controls - MIL ON/DTC's P2138/P2139/P2140
- Engine Controls - WIF Lamp ON/Flickering
- Engine Controls - Poor High Altitude Engine Performance
- Parking Assist System - Speaker Inop./DTC C1742/C1743
- Body - Power Sliding Back Window Sticking/Binding
- Drivetrain - Drive-Away Shudder/Vibration
- Body - Chrome Tow Hooks Rusting
- Body - Running Board Corrosion
- Cooling System - Engine Cooling Fan is Inoperative
- Frame - Verticle Body Vibration/Hopping at 42-48 MPH
- Engine Controls - Buck/Jerk Towing Gooseneck Trailer
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Diesel Engine - Oil/Boost Leaks At Hot Side CAC Duct
- Cooling System - Vehicle Overheating (Snowplow Package)
- Drivetrain - Driveline Noise Under Light Load
- Steering - Steering Wheel Oscillation After Wheel Impact
- Engine, A/T Controls - Erratic A/T Shifting Over 50 MPH
- Brakes - ABS Lamp ON/DTC's C1175/C1236/P0500/P0503
- Steering/Brakes - Brake Pedal Kick-Back/Grabbing
- Instruments - Speedo/Tach Jumping/Bouncing/Erratic
- Body - Front Door Window Scratched
- Engine - Controls - MIL ON/DTC P0470 in Extreme Cold
- Diesel Engine - Belt Chirp Noise On Cold Start
- Body - Rattle Noise From Tailgate
- Body - Rust Stains On Front Bumper
- A/C - Lack of Cooling Ability
- Cooling System - Fuel Contamination Diagnostics
- Body - Sunroof Water Leaks During High Pressure Car Wash
- Emissions - Low Power/Smoke/EGR DTC's Set
- Wheels/Tires - Steering Wheel Nibble/Vibration
- Cooling System - Overheating/Coolant Loss
- Diesel Engine - Engine Oil In Coolant
- Fuel System - WIF Lamp ON/No Driveability Issues
- Diesel Engine - Low Power/Exhaust Smoke/Surging
- Diesel Engine - Fuel In Coolant
- Engine Controls - ECM Update For Various Issues/DTC's
- Fuel System - Hard/No Start/Runs Rough
- Superceded Bulletins
- 07-21-4 - 10/29/07
- 07-8-4 - 04/04/30
- 06-24-1 - 11/20/06
- 06-17-1 - 09/04/06
- 06-14-15 - 07/24/06
- Body - Side Window Glass is Scratched
- Body - Side Window Glass Scratching
- Lighting - Adding Additional Turn Signal/Hazard Bulbs
- Body - Water Leak From Rear of Sunroof
- Body Rust Stains On Front Bumper
- A/C - Poor Cooling Performance
- Diesel Engine - Turbocharger Carbon Deposit Diagnosis
- Engine - Oil/Exhaust Leak At Hot Side Charge Air Cooler
- Diesel Engine - Hard or No Start/Long Crank Time
- Fuel System - Water in Aft-Axle Fuel Tank
- Fuel System - Water in Aft-Axle Fuel tank
- Fuel System - Low Power/Smoke/Misfire/Buck/Jerk
- Fuel System - Buck/Jerk/Misfire/Smoke/Low Power
- Diesel Fuel System - Smoke/Low Power/Bucking/Jerking
- Diesel Fuel System - No Start/Hard Start/Long Crank Time
- Diesel Engine - Exhaust Smoke/Surge/Low Power/DTC's
- Fuel System - No Start/Hard Start/Runs Rough
- Diesel Engine - Long Crank Time/Hard Start/No Start
- Diesel Engine - Low Power/Smoke/Surge/Possible DTC's
- Diesel Engine - Low Power/Surge/Smoke/Multiple DTC's
- Emissions - MIL ON/DTC P0401/P0402/P0404/P1335
- Diesel Engine - Surge/Lack of Power/Exhaust Smoke/DTC's
- Engine - Coking Deposit Diagnostics
- Emissions - MIL ON/DTC's P0401/P0402/P0404/P1335
- Diesel Engine - Low Power/Exhaust Smoke/Possible DTC
- Engine Controls - MIL ON/DTC's P2138, P2139 and P2140
- Diesel Fuel System - White Smoke/Low Power/Hard Start
- Diesel Fuel System - White Smoke/Low Power/Runs Rough
- Campaign - Accelerator Pedal Sensor Corrosion Inspection
- Diesel Engine - Smoke/Low Power/Surge/Stall
- Diesel Engine - Exhaust Smoke/Low Power/Surge
- Cooling System - Cooling Fan Inoperative
- Diesel Engine - Low Power/Exhaust Smoke/Possible DTC's
- Diesel Engine - Hard Start/No Start/Long Crank Time
- Engine - Revised Head Gasket/Cylinder Head Service
- Diesel Engine - Cylinder Head Flatness Check Procedure
- Engine - Cylinder Block/Head Identification
- Steering - Steering Wheel Oscillation On Bumps
- Steering - Steering Wheel Oscillation On Rough Roads
- Diesel Engine - White/Black Smoke/Low Power/No Start
- Fuel System - Fuel Tank Hard To Fill/Nozzle Shuts Off
- Cooling System - Coolant Venting From Reservoir Cap
- Steering - Steering Wheel Oscillation
- Tires/Wheels - Vibration While Driving
- Cooling System - Coolant Vents From Coolant Reservoir
- Cooling System - Coolant Venting From Reservoir
- Cooling System - Oil in The Engine Coolant
- Cooling System Coolant Venting From Coolant Reservoir
- Cooling System - Coolant Venting From Coolant Reservoir
- All Technical Service Bulletins
- Recall 11V352000: Multifunction Switch Defect
- Recall - Multifunction Switch Replacement
- Campaign - Customer Vehicle Maintenance Reminder Letter
- A/C, Cooling System - Heater Core Leaks
- A/C - Heater Core Electrolysis/Leakage
- Drivetrain - Front Wheel Bearing Noise
- Cooling System - Engine Overheating With Snow Plow On
- Engine Controls - MIL ON/DTC's P2138/P2139/P2140
- Engine Controls - WIF Lamp ON/Flickering
- Engine Controls - Poor High Altitude Engine Performance
- Lighting - Addition of Bulbs to Turn/Hazard Flashers
- Parking Assist System - Speaker Inop./DTC C1742/C1743
- Body - Power Sliding Back Window Sticking/Binding
- Drivetrain - Drive-Away Shudder/Vibration
- Steering - Mercon V(R) Fluid Usage
- M/T - Mercon(R) V ATF Usage Information
- Body - Chrome Tow Hooks Rusting
- Body - Running Board Corrosion
- Cooling System - Engine Cooling Fan is Inoperative
- Frame - Verticle Body Vibration/Hopping at 42-48 MPH
- Battery - Battery Eye Function/Charging/Service
- Engine Controls - Buck/Jerk Towing Gooseneck Trailer
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Diesel Engine - Oil/Boost Leaks At Hot Side CAC Duct
- Diesel Engine - Reman Cylinder Block/Head Identification
- Cooling System - Vehicle Overheating (Snowplow Package)
- Drivetrain - Driveline Noise Under Light Load
- Steering - Steering Wheel Oscillation After Wheel Impact
- Engine, A/T Controls - Erratic A/T Shifting Over 50 MPH
- Brakes - ABS Lamp ON/DTC's C1175/C1236/P0500/P0503
- Steering/Brakes - Brake Pedal Kick-Back/Grabbing
- Instruments - Speedo/Tach Jumping/Bouncing/Erratic
- Body - Front Door Window Scratched
- Campaign - Accelerator Pedal Inspection
- Engine - Controls - MIL ON/DTC P0470 in Extreme Cold
- Diesel Engine - Belt Chirp Noise On Cold Start
- Body - Rattle Noise From Tailgate
- Body - Rust Stains On Front Bumper
- A/C - Lack of Cooling Ability
- Cooling System - Oil/ATF/Fuel Contamination Flushing
- Cooling System - Fuel Contamination Diagnostics
- Body - Sunroof Water Leaks During High Pressure Car Wash
- Emissions - Low Power/Smoke/EGR DTC's Set
- Wheels/Tires - Steering Wheel Nibble/Vibration
- Cooling System - Overheating/Coolant Loss
- Cooling System - Coolant Maintenance Service Tips
- Diesel Engine - Engine Oil In Coolant
- Fuel System - WIF Lamp ON/No Driveability Issues
- Diesel Engine - Low Power/Exhaust Smoke/Surging
- Campaign - Diesel Engine Warranty Extension
- Campaign - Diesel Engine Component Warranty Extension
- Campaign - Diesel Engine Replacement Warranty Extension
- Diesel Engine - Head Gskt./Cyl. Head Cleaning/Inspection
- Diesel Engine - Various Driveability/Starting Issues
- Diesel Engine - Fuel In Coolant
- Engine Controls - ECM Update For Various Issues/DTC's
- Cooling System - Water Quality For Cooling Sys. Flushing
- Fuel System - Hard/No Start/Runs Rough