Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- A/C - Musty Odor Coming From Vents
- Engine - Rough Idle/No Start/No WOT Kickdown
- Brakes - Roughness During Application
- Spark Plug - Seizes or Breaks/Removal Procedure
- Engine Timing Belt - Chirping/Squeaking Noise
- Engine - No Start/Hard Start/Poor Performance
- Engine - Hard/No Start/Poor Performance
- Engine - Low Oil Pressure/Oil Sludge Build-Up
- Aluminum Wheel - Air Leaks
- Door Trim Panels - Rattling Noise
- EGR/EVP Sensor - MIL ON/Self Test Code 16 Set
- Axle Shafts - Fluid Leaks
- Rear Brakes - Squeal During Light Applications
- Battery - No Engine Crank/Low Battery Charge
- Engine - No Start Condition
- Engine - No Start or Hard Start Condition
- Engine - Hesitation On Acceleration/Surge While Driving
- Electric Rear Window Defroster - Inoperative
- M/T - Click/Clunk/Rattle In Reverse Gear
- Horn - Goes Off By Itself At High Temperatures
- Oil Pressure Switch - Leaks Oil
- M/T - Hard to Shift/Gear Clash
- Vent Windows - May Stick to Weatherstrip
- Windshield Wipers - Inoperative
- Rear Quarter Windows - Water Leaks
- Speed Control - Abnormal Operation When Hot
- Carpeting - Loose At Lower Cowl Panel
- Exterior Door Handle - Breaks Off In Freezing Weather
- Seat - Does Not Easily Move Full Travel Fore and Aft
- M/T - MTX Whining Noise Above 40 MPH
- Gear Shift Knob - Insert Loose
- Parking Brakes - Difficult to Release
- Exhaust System - Sulfur Smell
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Emblem - Chrome Peeling/Moisture Inside
- Seals, Gaskets
- Superceded Bulletins
- 9173 - 04/05/91
- 91245 - 11/27/91
- 9094 - 04/27/90
- 9023 - 01/17/90
- 90137 - 06/20/90
- 90128 - 06/07/90
- 89311 - 02/08/89
- 89255 - 12/13/89
- 89252 - 12/13/89
- 891012 - 05/17/89
- 881710 - 08/17/88
- 88148 - 07/07/88
- 88108 - 05/11/88
- 861116 - 06/05/86
- A/C - Identification Of Non Approved Refrigerants
- A/C - R134A Retrofit Kit Availability
- A/C - R12 to R134a Retrofit Kit Availability
- A/C - Approved Flushing Procedures
- Air Conditioning - Musty or Mildew Type Odors
- A/C - O Ring Removal From Spring Lock Coupling
- Wire Splicing And Wire Harness- Terminal Repair Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Procedure
- Wire Harness - Terminal Repair And Wire Splice Kit
- Wire Harness - Terminal Repair Kit/Wire Splice Repair
- Wire Harness - Terminal Repair Kit/Splice Procedure
- Wire Harness - New Terminal Repair Kit
- Charging - Generator Discharge/Damaged Connector
- Brake Rotor - Machining With On-Vehicle Equipment
- Brakes - Occasional or Intermittent Squeal
- A/T - New Transmission Cooler Flusher/Service Tip
- Fuel Economy - Customer Expectations Vs. Vehicle Usage
- Fuel Economy - Expectations Versus Usage
- Exhaust Gas Oxygen Sensors - Silicone Contamination
- Exhaust System - Buzz or Rattle Noise
- Exhaust System - Buzzing/Rattling Noises
- Exhaust System - Rattling/Buzzing Noise
- Exhaust System - Buzz/Rattle Noise
- Heater - Poor Performance
- Heater Core - Repeated Failure
- A/T - Fluid Application Charts
- A/C System - New A/C Filter Kit
- A/C - Refrigerant Filtering Tips
- A/C - Refrigerant Filtering Service Tips
- A/C System - Refrigerant Filtering Service Tips
- Wheels - Proper Lug Torque Procedures
- Brakes - Vibration Prevention Service tip
- Recycled Engine Coolant - Service Tip
- Wheel Bearing/Halfshaft Locknuts - Service Tips
- A/T - Transmission Fluid Usage Charts
- Automatic Transmission - Fluid Usage Charts
- A/C System - Use of R12 Refrigerant Substitutes
- A/C - Non Approved Refrigerants
- A/C - Approved/Alternate Refrigerants
- A/C - Identification of Non-Approved Refrigerants
- A/C - Identifying Non-Approved Refrigerants
- Vehicle - Towing Guidelines
- Vehicle - RV Towing Precautions
- All Technical Service Bulletins
- Ford RTV Sealer - Shelf Life
- Vehicle - Build Date Location and Information
- Production Build Date Stamp - Relocation
- Vehicle - Towing Behind RVs Guidelines
- A/C - Musty Odor Coming From Vents
- Air Conditioning - Odor Service Procedure
- A/C System - Service TSB List
- Air Conditioning - R12 to R134A Retrofit Kit
- A/C - Filtering Refrigerant After Compressor Replacement
- Adhesives and Sealants - Availability and Usage
- Engine Gasket Surface - Cleaning Procedures
- Engine - Repair Tips to Avoid Potential Damage
- Engine - Rough Idle/No Start/No WOT Kickdown
- Electrical - New Terminal Grease Released For Service
- Maintenance - Interval Correction
- Brakes - Roughness During Application
- Spark Plug - Seizes or Breaks/Removal Procedure
- Air Conditioning - Approved Flushing Procedures
- Heater Core - Core Leak Test Procedure
- Cylinder Head - Seized Camshaft Service Tips
- Camshaft Timing/Ignition System Service - Revision
- Engine Timing Belt - Chirping/Squeaking Noise
- Engine - No Start/Hard Start/Poor Performance
- Engine - Hard/No Start/Poor Performance
- Cooling System - New System Diagnostics
- Engine - Low Oil Pressure/Oil Sludge Build-Up
- Recall 96E017000: MOOG Control Arm Incorrectly Packed
- Aluminum Wheel - Air Leaks
- Lug Nuts - Proper Installation/Torqueing Procedure
- Front/Rear Bumper - Aftermarket Paint Information
- Door Trim Panels - Rattling Noise
- Torque Converter - Cleaning and Replacement Guidelines
- A/T Torque Converter - Leak Test Procedure
- Clutch Pedal - Free Play Adjustment Correction
- Fuel System - Injector Tester/Cleaner Service Tips
- EGO Sensors - Silicone Contamination
- EGR/EVP Sensor - MIL ON/Self Test Code 16 Set
- EVP Sensor - Manual Revision
- Overview
- 1985 Pinpoint Tests - DM - EGR, EVP and EVR
- 1985 Pinpoint Tests - Fa - Neutral Drive Switch -A/C Input
- 1986 (EGR) Systems Functional Diagnosis
- 1986 Quick Test: Continuous Self-Test 6.0
- Pinpoint Test - DN - EGR - EVP & EVR
- Axle Shafts - Fluid Leaks
- Wheel Hub/Rotor Assembly - Removal Revision
- Rear Brakes - Squeal During Light Applications
- Battery - Test Procedure
- Battery - No Engine Crank/Low Battery Charge
- Engine - No Start Condition
- Engine - No Start or Hard Start Condition
- `Star Tester' - Proper Hook Up Procedure
- Distributor Diaphragm - Request For Return
- Engine - Hesitation On Acceleration/Surge While Driving
- Distributor Diaphragm - Parts Return
- Carburetor - Fast Idle Manual Correction
- Malfunction Indicator Light - Explanation
- Audio Systems - Authorized Service Centers
- Electric Rear Window Defroster - Inoperative
- Brake Rotor - Machining Equipment/Warranty Information
- Engine - Oil Dipstick May Not Be Read Correctly
- M/T Input Shaft Play/Output Shaft Preload - Correction
- M/T - Click/Clunk/Rattle In Reverse Gear
- Horn - Goes Off By Itself At High Temperatures
- Oil Pressure Switch - Leaks Oil
- Speedometer/Odometer - Inaccurate Readings
- M/T - Hard to Shift/Gear Clash
- Chassis Components - Cosmetic Surface Rust
- Emission Control Systems - Identification
- EEC IV Emissions Diagnosis - Supplemental Information
- Overview
- EEC IV - Pinpoint Tests - All Vehicles 1986 19-253A
- EEC-IV Quick Test-All Engines 1987 16-15
- EEC IV - Pinpoint Tests - All Vehicles 1987 19-3
- Carburetors, Fuel Charging Assemblies, Throttle Bodies and Injectors 1988
- EEC-IV -Quick Test -All Engines 1988 16-11
- Quick Test:Engine Running Self-Test
- Appendix:Self-Test With "Check Engine" Light (MIL)
- Reference Voltage
- EGR Valve Position Sensor (EVP) Control/Vent (EGRC/EGRV)
- Vane Airflow Sensor (VAF)
- Pressure Feedback EGR (PFE) EGR Valve Regulator (EVR)
- EGR Valve Position Sensor (EVP) EGR Valve Regulator (EVR)
- Fuel Control
- Fuel Pump Circuit
- Idle Speed Control (Bypass Air)
- WOT A/C Cutoff (WAC) A/C Demand
- RE-Initialization Check
- System Check
- Transmission - AXOD
- Integrated Controller
- VECI Label - Final Issue
- Emission Control System - Technician's Glossary
- Key On Engine Off Self Test Procedure - Manual Revision
- Electronic Fuel Control Quick Test - Manual Correction
- EFCS - Service Code Erasure
- Electronic Modules - Protection From Static Electricity
- Breakout Box Diagnostic Routines - Manual Revision
- Overview
- Ignition Diagnostic Monitor Pinpoint Test A
- Vane Air Temperature Pinpoint Test DA
- Manifold Absolute Pressure Sensor
- Vane Air Flow Meter Pinpoint Test DK
- EGR Valve Position Sensor Pinpoint Test DN
- Neutral Gear and Clutch Switch Pinpoint Test Fa
- Neutral Safety Switch Pinpoint Test FB
- Vehicle (Key) Power Pinpoint Test FC
- Brake On/Off Switch Pinpoint Test Fd
- Idle Switch Pinpoint Test FE
- Refrigerant Pressure Switch Pinpoint Test Ff
- Wide Open Throttle Switch Pinpoint Test Fh
- Headlamp Switch Pinpoint Test Fj
- WOT Vacuum Switch Pinpont Test Fo
- EGO Sensor Pinpoint Test Ha
- EGO Sensor Feedback Pinpoint Test He
- Fuel Control Pinpoint Test HO
- Canister Purge Solenod Pinpoint Test Kd
- Idle Speed Control Solenoid Pinpoint Test Ke
- Early Fuel Evaporization Heater Pinpoint Test Kf
- Electrical Load Control Solenoid Pinpoint Test KG
- A/C Load Control Solenoid Pinpoint Test Kh
- Feedback Carburetor Actuator Pinpoint Test Kj
- Decel Fuel Shut-Off Solenoid Pinpoint Test Ko
- Shift Indicator Lamp Pinpoint Test Kr
- Pressure Regulator Control Solenoid Pinpoint Test KV
- No Codes, Codes Not Listed Pinpoint Test Q
- Electrical/Electronic/Fuel Induction - Glossary
- Door Latches - Adjustment/Modification Prohibition
- Safety Belt - Tongue Cover Now Available
- Owner Guide - Illustration Correction
- Windshield - Material Usage Procedure
- Windshield/Interior Glass - Fog/Film
- Vent Windows - May Stick to Weatherstrip
- Glass - Iridescence or Mottling In Tempered Glass
- Windshield Wipers - Inoperative
- Rear Quarter Windows - Water Leaks
- R/H Exterior Mirror - Service Part Availability
- Adhesive Mouldings and Nameplates - Replacement
- Tail Lights - Lens Replacement Procedure
- Cooling System - Proper Fluid Concentrations
- Engine Coolant - Recycled Coolant Not Authorized
- Recycled Engine Coolant - Service Tips
- Engine Coolant - Propylene Glycol Recommendations
- A/T - New Rotunda Fluid Changer Service Tip
- A/T - Transmission Flush and Fill Tool Available
- A/T - Engine Vacuum Testing
- A/T - How To Use A Pressure Gauge
- A/T - EEC Trouble Codes
- A/T - Diagnostic Trouble Codes for 1983-1992
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - Math Formulas Part I
- A/T - Twenty Steps To Successful Repairs
- A/T - Math Part II
- A/T - Choosing the Right ATF
- Recall - EGR Valve Replacement
- A/T - Mercon V ATF Usage
- Speed Control - Abnormal Operation When Hot
- Replacement Odometer Sticker - Manual Revision
- Driveability TSB's - Summary
- Engine - Normal Oil Consumption
- Wire Harness - Terminal Repair Kit
- Wiring - Circuit Number/Color Code Charts
- Wire Harness Terminal and Connector - Service Kit
- Fuel System - Technician's Glossary
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Safety Belts - Service Procedure, Manual Revision
- Paint - Cosmetic Damage From Airborn Materials
- Lower Body Stone Protection - Repair Procedure
- Paint - Codes/Cross References
- Paint - Difficulty Matching Production Colors
- Paint - Preparation Procedure And MSDS Information
- Paint - Poor Paint Appearance
- Exterior Paint - Comprehensive Repair Procedures
- Overview
- Section A Has Been Superseded By TSB # 9264, Dated 3/92.
- (B) Paint Exterior Color Peeling From Ultra Violet Light
- (C) Lower Body Stone Protection Repair Tips
- (D) Procedure For PVC Body Side Moldings
- (E) Lower Body-Side Stone Chip Protection Program
- (F) Surface Defect Removal Without Repainting
- (G) Color Compatible Spray Primer Chart
- (H) Paint Repair For Tinted Clear Coat
- (I) Paintable Plastics
- (J) 1992 Paint Color Codes
- Paint - Iron Particle Removal
- Carpeting - Loose At Lower Cowl Panel
- Electrical Diode - Identification and Replacement
- Exterior Door Handle - Breaks Off In Freezing Weather
- Recall 93V106001: Subframe Mount Retainer Plate
- Seat - Does Not Easily Move Full Travel Fore and Aft
- A/C - R12 Refrigerant Service Tips
- A/C - R12 Refrigerant Substitutes Service Tip
- R-12 Refrigerant - Substitutes
- Air Conditioning - Use of Correct Fluorescent Tracer Dye
- A/C - Identification of Non Approved Refrigerants
- M/T - MTX Whining Noise Above 40 MPH
- License Plate - Installation Kit
- Gear Shift Knob - Insert Loose
- Recall - Seat Belt Buckle Inspection/Replacement
- Recall 95V103011: Seat Belt Buckle Breakage
- Vehicle Storage - Maintenance Tips
- Parking Brakes - Difficult to Release
- Exhaust System - Sulfur Smell
- Engine - Rough Idle/Hesitation/Backfire/Stalling
- Rotunda Gas Chek Kit - Requires Modification
- Rear Wheel Alignment/Repair Procedures - Revision
- Suspension - Rear Alignment Specifications/Adustments
- Emblem - Chrome Peeling/Moisture Inside