Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Emissions
- Generals
- Campaign - Steel Wheel Warranty Extension
- Campaign - Steel Wheels Extended Warranty Coverage
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Flow Chart
- Owner Letter - VINs Not Previously In 03M03 or 03S05
- Owner Letter - 2003 Vehicles That 03S05 Completed
- Owner Letter - 2003 Vehicles That Have Not Completed
- Campaign - Police Interceptor Optional Upgrade
- Dealer Letter - Technical Instructions Reinforcement
- Dealer Letter - Retail Customer Purchase of Kits
- Dealer Letter - Parts Update
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Fleet Manager Letter
- Dealer Letter - S1
- Attachment I - S1
- Attachment II - S1
- Attachment III - S1
- Owner Letter - S1
- Dealer Letter - S2
- Owner Letter - S2
- Safety
- Recall - Rear Axle Shaft Fracture
- Recall - Steel Wheel Inspection/Replacement
- Recall 05V206000: Dash Sound Insulator Replacement
- Recall - Outer Dash Insulator Pad Modification
- Recall 04V328000: Potential Rear Axle/Bearing Failure
- Recall 07V079000: Wheel Replacement (Police Vehicle)
- Recall - Police Vehicle, 16 Inch Steel Wheel Replacement
- Customer Interest
- A/C - Lack of Cooling/Restricted Air Flow From Vents
- Engine - Ticking Noise When Idling
- Engine - Timing Chain Grinding Noise
- Cooling System - Radiator Alignment Pins Hit Ground
- Suspension - Harsh Ride/Sits Low In Front
- Suspension - Air Compressor Noisy
- Door - Catches on Weatherstrip
- Brakes - Multiple ABS DTC's Set
- A/T - 4R70W Overdrive Inoperative/Police Package Only
- Engine Controls - Engine Idle Vibration
- Engine Controls - MIL ON/DTC P0460 in Memory
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Lighting - Excessive Moisture in Headlamp Assembly
- Wipers/Washers - Uncommanded Wiper Operation
- Ignition System - Ignition Lock Cylinder Binding
- Electrical - Aftermarket Accessories Inoperative
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Emissions - MIL ON/DTC P0442 (EVAP System Leak)
- Interior - Door Trim Panel Carpet Inserts Loose/Peeling
- Restraints - Seat Belts Slow to Retract
- Drivetrain - Premature Axle Bearing Wear
- A/C - FEAD Belt Chirping Upon Compressor Engagement
- A/T - Inadvertent Shift Interlock Disabling
- Engine/Exhaust - Cold Start Knocking Noise
- Suspension - Squeaking/Rubbing Noise
- A/C - Register Rattles with Blower ON
- Interior - Driver's Seat Cover Wear Through
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Superceded Bulletins
- 04S16 - 07/01/04
- Body - Aluminum Corrosion Service Tip
- Body - Snapping Noise When Opening Front Doors
- Interior - Door Panel Carpet Inserts Loose/Peeling
- A/C/Audio System - Rear Defroster Grid/Antenna Repair
- SRS - DTC B1342 (Restraints Control Module Fault)
- Restraint System - Seat Belts Slow to retract
- Restraints - DTC And Associated Fault PID Service Tips
- A/C - Lack of Cooling/Low Air Flow From Vents
- A/C - White Flakes Come From Dash Vents With Blower ON
- A/C - White Flakes Blow From Dash Vents
- A/C - White Flakes From Vents With Blower ON
- Suspension - Vehicle Sits Low In Front/Harsh Ride
- Steering - Leather Coming Loose From Steering Wheel
- Electrical - Wiring Soldering/Crimping Tips
- Battery - Service/Charging Tips
- ABS - Multiple Wheel Speed Sensor DTC's Set
- Drivetrain - Premature Rear Axle Shaft/Bearing Wear
- Drivetrain - L/S Rear Axle Shudder/Chatter
- Engine Controls - General PCM Reprogramming Procedures
- Engine Controls - MIL ON/DTC P0460 Set
- Engine Controls - Battery Lamp ON/DTC P1246 Set
- Emissions - MIL ON/EVAP System DTC's Set
- Engine - Cylinder Head Straightedge Flatness Check
- Engine - Ticking Noise at Idle
- Battery - Battery EYE Function/Charging Service Tips
- Cooling System - 'Premium Gold Coolant' Service Tips
- 07S48 - 03/05/07
- Recall - 16 Inch Steel Wheel Replacement
- Recall - 16 In. Steel Wheel Replacement (Police Vehicle)
- Ignition System - Engine Misfire Diagnostics Tips
- Engine Controls - Idle Vibration
- Ignition System - Engine Misfire Diagnostic Tips
- All Technical Service Bulletins
- A/C System - Diagnosis and Service Tips
- A/C - Lack of Cooling/Restricted Air Flow From Vents
- Recall - Rear Axle Shaft Fracture
- Engine - Ticking Noise When Idling
- Engine - Timing Chain Grinding Noise
- Engine - Cylinder Head Straightedge Surface Check
- Cooling System - Radiator Alignment Pins Hit Ground
- Suspension - Harsh Ride/Sits Low In Front
- Campaign - Steel Wheel Warranty Extension
- Recall - Steel Wheel Inspection/Replacement
- Campaign - Steel Wheels Extended Warranty Coverage
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Attachment IV - Flow Chart
- Owner Letter - VINs Not Previously In 03M03 or 03S05
- Owner Letter - 2003 Vehicles That 03S05 Completed
- Owner Letter - 2003 Vehicles That Have Not Completed
- Suspension - Air Compressor Noisy
- Tires - Warning, Not to Mix Tire Types
- Door - Catches on Weatherstrip
- Engine Controls - MAF Sensor Diagnostic Service Tip
- Brakes - Multiple ABS DTC's Set
- Charging System - High Output Alternator Availability
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- A/T - 4R70W Overdrive Inoperative/Police Package Only
- Engine Controls - General PCM Programming Procedures
- Engine Controls - Engine Idle Vibration
- Engine Controls - MIL ON/DTC P0460 in Memory
- Campaign - Police Interceptor Optional Upgrade
- Dealer Letter - Technical Instructions Reinforcement
- Dealer Letter - Retail Customer Purchase of Kits
- Dealer Letter - Parts Update
- Dealer Letter
- Attachment I - Administrative Information
- Attachment II - Labor and Parts Information
- Attachment III - Technical Information
- Fleet Manager Letter
- Dealer Letter - S1
- Attachment I - S1
- Attachment II - S1
- Attachment III - S1
- Owner Letter - S1
- Dealer Letter - S2
- Owner Letter - S2
- Recall - Incorrect R/H Catalytic Converter Installed
- A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair
- A/C - Rear Window Defroster/Antenna Diagnosis/Repair
- Restraints - Seat Belt Stop Button Service
- Restraint System - SRS Lamp ON/DTC B1342 Set
- Engine - Oil Level Indicator Markings
- Lighting - Excessive Moisture in Headlamp Assembly
- Lighting - Moisture In Headlamp Assembly
- Wipers/Washers - Uncommanded Wiper Operation
- Ignition System - Ignition Lock Cylinder Binding
- Recall 05V206000: Dash Sound Insulator Replacement
- Recall - Outer Dash Insulator Pad Modification
- Body - Collision Repair Tips
- Electrical - Aftermarket Accessories Inoperative
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Emissions - MIL ON/DTC P0442 (EVAP System Leak)
- Engine Controls - MIL ON/Lean DTC Service Tips
- Interior - Door Trim Panel Carpet Inserts Loose/Peeling
- Restraints - Seat Belts Slow to Retract
- Body - Exterior Mirror Glass/Motor Service Tips
- Cooling System - Premium Gold Coolant Service Info
- Drivetrain - Premature Axle Bearing Wear
- Recall 04V328000: Potential Rear Axle/Bearing Failure
- A/C - FEAD Belt Chirping Upon Compressor Engagement
- Electrical - Wiring Soldering/Crimping Service Tips
- Cruise Control - Diagnostic Updates
- Keyless Entry System - Service Tips
- Paint - New Polishing Products and Procedures
- Paint - Approved Paint Materials
- Paint - Plastic Bumper/Fascia Service Tips
- A/T - Inadvertent Shift Interlock Disabling
- Engine/Exhaust - Cold Start Knocking Noise
- A/T - 4R70W Needle Bearing/Race Kit Service Tip
- Air Bag System - DTC B2290/B2295 Diagnostic Tips
- Suspension - Squeaking/Rubbing Noise
- A/C - Register Rattles with Blower ON
- Fuel System - Fuel Pressure Relief Valve Discontinued
- Interior - Driver's Seat Cover Wear Through
- Engine - Reman Engine Head Gasket Identification
- A/C - Heater Core Electrolysis/Leakage
- Starting System- No Crank Condition
- Body - Aluminum Body Panels - Corrosion
- Engine Controls - Reduction in Power at WOT
- Steering - Mercon V(R) Fluid Usage
- Battery - Battery Eye Function/Charging/Service
- Interior - Leather Wrapping On Steering Wheel Is Loose
- Recall 07V079000: Wheel Replacement (Police Vehicle)
- Restraints - Control Module DTCs, Associated Fault PIDs
- Engine - Spark Plug Hole Thread Repair Procedure
- Recall - Police Vehicle, 16 Inch Steel Wheel Replacement